2014 Ford F-53 Recalls & Complaints

Incident: July 24, 2018 · Filed: June 26, 2019

TL* THE CONTACT OWNED A 2014 FORD F53 THE CONTACT STATED THAT WHILE DRIVING 55 MPH IN THE RAIN, THE WINDSHIELD WIPERS WERE INCREASED TO HIGH SPEED BUT, SEIZED IN THE UPWARD POSITION AND THE CONTACT CRASHED THE VEHICLE INTO A UNKNOWN OBJECT. THERE WERE NO INJURIES OR FIRE DUE TO THE CRASH. A POLICE REPORT WAS NOT FILED. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LAZYDAYS RV OF TAMPA 6130 LAZY DAYS BLVD, SEFFNER, FL 33584 (800) 306-4002 BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED .THE FAILURE MILEAGE WAS APPROXIMATELY 29,000.

Incident: March 10, 2019 · Filed: March 11, 2019

WIPERS TRAVEL TOO FAR AND CATCH ON DRIVERS MIRROR (DRIVERS SIDE) AND ON PASSENGERS SIDE, OFF OF THE WINDSHIELD BELOW THE RUBBER GASKET AND HANGS ON GASKET. WHILE IN USE, I MUST EITHER STOP, OR TURN THE WIPERS OFF AFTER ONE SWEEP. I CALLED THOR OWNERS HELPLINE SEVERAL TIMES WITH NO HELP. I CALLED AGAIN TODAY (3/11/2019) AND TALKED TO KIRK. AGAIN NO HELP. *DT *DT *DT*JB *BF... CONSUMER TAKING VEHICLE TO DEALER (4/17/19)*JB *DT CONSUMER STATED WIPER ISSUE IS COMPLETELT RESOLVED.*JB

Incident: August 5, 2018 · Filed: August 6, 2018

THE ENTRY DOOR DOES NOT LOCK AND MULTIPLE TIMES HAS OPENED WHILE DRIVING. THERE IS A RECALL ON LATER MODEL YEARS, BUT THIS MODEL YEAR WAS NOT INCLUDED. WHY?? THIS IS A SERIOUS SAFETY ISSUE AND CERTAINLY ONE THAT EXISTS IN PRIOR YEARS. *TT *TR

Incident: July 5, 2016 · Filed: May 2, 2018

ENTRY DOOR POPS OPEN IN MOTION *TT *TR

Incident: August 9, 2017 · Filed: March 28, 2018

TL* THE CONTACT OWNS A 2014 FORD F-53. THE CONTACT STATED THAT THE DEADBOLT LOCK ON THE ENTRY DOOR WOULD LOCK INDEPENDENTLY. THE OCCUPANTS WERE UNABLE TO ENTER OR EXIT THE VEHICLE. THE CONTACT ALSO STATED THAT THE ELECTRIC STEPS OPENED INDEPENDENTLY WITHOUT WARNING WHILE THE VEHICLE WAS IN MOTION, THE VEHICLE WAS TAKEN TO CAMPING WORLD OF SACRAMENTO (1039 ORLANDO AVE, ROSEVILLE, CA 95661, (916) 772-1155), BUT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V510000 (LATCHES/LOCKS/LINKAGES) AND 15V866000 (STRUCTURE). THE MANUFACTURER WAS NOT CONTACTED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000.

Incident: March 1, 2018 · Filed: March 21, 2018

INADEQUATE LIGHT FROM HEADLIGHT VERY UNSAFE TO DRIVE AT NIGHT ! BARELY SEE 5 FT IN FRONT AT NIGHT

Incident: June 9, 2016 · Filed: August 22, 2016

HEADLIGHTS ARE NOT STRONG ENOUGH TO LIGHT UP THE ROAD. HAVE TO USE HIGH BEAM AT NIGHT. LEG LIGHTS LIKE THESE JUST DISAPPEAR OUT IN THE DARK, IS NOT BEAMED AT ALL. CANNOT SEE THE ROAD, PERIOD. CONTACTED FR BUT THEY DON'T RECOGNIZE THIS PROBLEM OR TAKE ANY RESPONSIBILITY. LIGHT FIXTURE ARE ALSO LOOSE AND HARD TO TIGHTEN BACK UP. THE FORD F53 CHASSIS IS A 2014 MAKE. SUSPENSION IS REALLY BAD IN THE FRONT. 3 TIMES REPLACED BEARINGS AND SPINDLE. ON WARRANTY BUT THERE IS REALLY NOT ENOUGH SUSPENSION AND IT MAKES THE FRONT VIBRATE. SO MUCH SO THAT THE OVERHEAD BED HAS FALLEN DOWN SEVERAL TIMES AND HAS TO BE SUPPORTED BY A WOODEN BRACE. DASHBOARD VIBRATE AS WELL. THIS IS ALL HAPPENING WHILE DRIVING. BAD ROADS MAKES IT WORSE.

Incident: July 9, 2016 · Filed: July 18, 2016

THOR ACE MOTOR HOME IS EQUIPPED WITH AN ONAN GENERATOR AND GENERATOR OVERHEATS WHILE DRIVING. GENERATOR NECESSARY TO RUN AIR CONDITIONER TO COOL INTERIOR OF RV DURING IN WARMER MONTHS. GENERATOR WORKS FINE WHEN NOT TRAVELING DOWN HIGHWAY, BUT CUTS OFF DUE TO OVERHEATING WITHIN MINUTES OF DRIVING IN HOTTER WEATHER. WITHOUT COOLING INTERIOR OF MOTOR HOME BECOMES VERY HOT.

Incident: July 15, 2016 · Filed: July 15, 2016

FOUND THE RIGHT REAR LOWER SWAY BAR MOUNT BOLT MISSING AND THE MOUNT BENT UPWARD, CAUSING THE SWAY BAR TO BECOME INEFFECTIVE AND THE BODY LEANING 3" LOWER ON THE RIGHT SIDE THAN THE LEFT SIDE. HANDLING WAS ALSO AFFECTED DRASTICALLY, ALMOST CAUSING LOSS OF CONTROL SIMILAR TO A FLAT TIRE.

Incident: June 24, 2016 · Filed: July 13, 2016

AN ALMOST NEW 2014 NEWMAR BAY STAR 3303 MOTORHOME WITH A FORD V10 GASOLINE ENGINE ON A FORD CHASSIS. MY FAMILY AND I WERE PREPARING TO LEAVE ON OUR FIRST BIG FAMILY OUTING IN OUR NEW RV. AT THE LAST MINUTE WHILE LOADING THE VEHICLE A GASOLINE ODOR WAS NOTICED. UPON VACATING THE VEHICLE, GASOLINE WAS SEEN DRIPPING FROM THE HOT EXHAUST PIPES UNDER THE RV. THE RV WAS SHUT OFF AND TOWED TO A FORD TRUCK GARAGE. FORD TECHS DISCOVERED GASOLINE UNDER PRESSURE WAS SQUIRTING ONTO THE ENGINE EXHAUST AND WITHIN MINUTES OF LEAVING ON OUR VACATION THE GAS FUMES WOULD HAVE IGNITED AND EXPLODED. THE FIRE WOULD NOW HAVE BE FUELED BY GAS FROM A MELTED HIGH PRESSURE PLASTIC GASOLINE LINE. THEN, AS A RV WITH THE ENGINE LOCATED BETWEEN THE FRONT SEATS, THE FIRE AND EXPLOSION WOULD HAVE PREVENTED ANYONE FROM EXITING THROUGH THE DOOR. THE GASOLINE FUELED FIRE AND EXPLOSION WOULD HAVE INJURED OR KILLED MY ENTIRE FAMILY. FORD HAS NO REPAIR FOR THE DESIGN/MANUFACTURING DEFECT IN THEIR HIGH PRESSURE FUEL LINE FOR THIS VEHICLE. IT SEEMS FORD'S NYLON/PLASTIC FUEL LINE IS INSULATED WITH A SOY BASED FOAM AND/OR OTHER INGREDIENTS THAT ARE NATURALLY GOOD TASTING FOOD PRODUCTS FOR RODENTS/CRITTERS. AS A FOOD BASED PRODUCT, THE FOAM INSULATION AND PLASTIC LINES ATTRACT RODENTS/CRITTERS TO EAT THE FOAM AND FUEL LINE THUS DAMAGING THE PLASTIC LINE CREATING A DANGEROUS GASOLINE LEAK. ON DISCUSSIONS WITH FORD THEY HAVE NO CORRECTION FOR THE PROBLEM. FORD RECOMMENDS PLACING MOTHBALLS UNDER THE VEHICLE AND TO AVOID PARKING IN WOODED AREAS. THE DANGER IS THAT THE PLASTIC FUEL LINE COATED WITH A FOOD BASED FOAM INSULATION IS LOCATED NEAR THE ENGINE CAUSING THE GASOLINE TO LEAK DIRECTLY ONTO THE HOT ENGINE MANIFOLD AND EXHAUST. THE SAFETY OF MY FAMILY IS AT RISK EVERY TIME WE USE THE RV DUE TO A DESIGN AND ENGINEERING DEFECT BY FORD AND THE LOCATION OF THE ENGINE AND EXIT DOOR ON THE NEWMAR.