NHTSA vehicle safety data

2000 Ford E-Series Recalls & Complaints

The 2000 Ford E-Series has 2 NHTSA recall campaigns and 6 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2000 Ford E-Series. Recall data is refreshed daily from NHTSA.

2000 Ford E-Series owner complaints

Owners have filed 6 complaints with NHTSA about the 2000 Ford E-Series, describing incidents dated March 1, 2004 to May 28, 2025.

Most-cited components

Engine 1 complaint
Equipment 1 complaint
Exterior Lighting 1 complaint
Fuel/Propulsion System 1 complaint
Structure 1 complaint
Suspension 1 complaint

Newest complaints

ODI #11671852 · Filed July 8, 2025
We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph)…
ODI #10643893 · Filed October 10, 2014
ONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES…
ODI #10171394 · Filed October 20, 2006
I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND…

Read all 6 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2000 Ford E-Series in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP05-005: SPARK PLUG EJECTION FROM CYLINDER HEAD
Closed January 4, 2006
Recall Query RQ02-002: TIRE VALVE STEM
Closed August 19, 2002
- Recall 01V-046

Open and recently closed NHTSA defect investigations

CAMSHAFT POSITION SENSOR

NHTSA #07V553000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported December 5, 2007 · FORD MOTOR COMPANY

Potentially affected: 1,176,000 vehicles

Ford campaign 07S57 · Owners notified December 29, 2007 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Safety consequence

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Notes

FORD RECALL NO. 07S57.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SOUTHERN COMFORT/RUNNING BOARDS

NHTSA #03V094000 · Structure · NHTSA notice

Reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS

Potentially affected: 3,674 vehicles

Owners notified March 7, 2003 · Vehicles built August 1, 2000 – March 3, 2003 (per NHTSA)

Defect description

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Safety consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2000 Ford E-Series. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

6 owner complaints have been filed with NHTSA for the 2000 Ford E-Series.

Suspension; Wheels; Unknown or Other

ODI #11671852

Incident: May 28, 2025 · Filed: July 8, 2025

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Tires

ODI #10643893

Incident: October 9, 2014 · Filed: October 10, 2014

ONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY. *TR

Engine and Engine Cooling; Fuel System, Gasoline

ODI #10171394

Incident: October 19, 2006 · Filed: October 20, 2006

I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT. *NM

Structure

ODI #10121938

Incident: May 1, 2004 · Filed: May 23, 2005

DT: PROBLEMS WITH THE FRAMES ; CRACKS IN THE FRAMES; RECEIVED A SVC. BULLETIN AND AN ARTICLE BY THE NATIONAL AMB. ASSOC. TO REPORT THIS

Vehicle Speed Control; Equipment

ODI #10114549

Incident: March 1, 2004 · Filed: March 23, 2005

MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.*AK

Exterior Lighting

ODI #550038

Filed: December 20, 1999

BRAKE LIGHT ON THE DASH ILLUMINATES INTERMITTENTLY. NLM

Other Ford E-Series model years

Check your 2000 Ford E-Series VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford E-Series at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN