NHTSA vehicle safety data

2004 Fleetwood Terry Recalls & Complaints

The 2004 Fleetwood Terry has 9 NHTSA recall campaigns and 8 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2004 Fleetwood Terry. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Fleetwood Terry owner complaints

Owners have filed 8 complaints with NHTSA about the 2004 Fleetwood Terry, describing incidents dated April 6, 2004 to December 12, 2020.

Most-cited components

Structure 4 complaints
Equipment 2 complaints
Suspension 1 complaint
Tires 1 complaint
Unknown or Other 1 complaint

Of the 8 complaints on file, 2 report a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11383230 · Filed December 13, 2020
THE FRAME OF MY FIFTH WHEEL CAMPING TRAILER BROKE IN TWO WHERE THE KING PIN BOX IS WELDED IN THE FRONT WHILE I WAS TOWING IT ON THE HIGHWAY. I WAS TOWING AT APPROXIMATELY 60 MPH WHEN I WENT OVER AN OVERPASS WITH AN UNEVEN LIP AT ITS EDGE WHICH CAUSED THE FAILURE. ONLINE RESEARCH THAT I'VE DONE SHOWS…
ODI #10386794 · Filed March 7, 2011
2004 TERRY TRAILER W/ DOMETIC REFRIGERATOR MODEL 2852 SERIAL# 605-03267. ITEM WAS RECALLED FOR DEFECT BUT WAS NEVER NOTIFIED OF THIS UNTIL FAILURE OF COMPONENT. DOMETIC REFUSING TO REPAIR REFRIGERATOR. DUE TO THE LEAKAGE OF AMMONIA THIS IS A SAFETY HAZARD. *TR
ODI #10344038 · Filed July 19, 2010
TL*THE CONTACT OWNS A 2004 FLEETWOOD TERRY TRAILER. WHILE DRIVING 55 MPH THE FIRE ALARMS IN THE TRAILER WERE ACTIVATED. AFTER EXAMINING THE VEHICLE THE CONTACT NOTICED THAT THE REAR PASSENGER TIRE WAS RUBBING AGAINST THE TIRE WHEEL WELL CAUSING SMOKE TO ACCUMULATE. THE FIRE DEPARTMENT WAS NOT…

Read all 8 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2004 Fleetwood Terry in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE06-005: INADVERTENT SLIDE-OUT EXTENSION MOVEMENT
Closed May 2, 2006
Engineering Analysis EA04-009: WHEEL SEPARATIONS
Closed November 24, 2004
- Recall 04V-310

Open and recently closed NHTSA defect investigations

REFRIGERATOR/DOMETIC

NHTSA #08V320000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 15, 2008 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 70,101 vehicles

Owners notified October 24, 2008 · Vehicles built April 1, 2003 – November 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #07V120000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 19, 2007 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 167,096 vehicles

Owners notified May 10, 2007 · Vehicles built April 1, 1997 – July 31, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

INCORRECT LOAD RANGE TIRES

NHTSA #05V511000 · Equipment — Other — Labels · NHTSA notice

Reported November 7, 2005 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 48 vehicles

Fleetwood campaign 51024 · Owners notified November 30, 2005 · Vehicles built November 19, 2002 – February 4, 2003 (per NHTSA)

Defect description

CERTAIN TRAVEL TRAILERS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE TIRE AND LOADING INFORMATION PLACARD CONTAINS INCORRECT "LOAD RANGE "B" INFORMATION REGARDING THE MAXIMUM CARGO CARRYING CAPACITY. THE CORRECT TIRE IS A LOAD RANGE "C".

Safety consequence

A FULLY LOADED TRAVEL TRAILER WILL OVERLOAD THE TIRES, WHICH COULD LEAD TO TIRE FAILURE, LOSS OF VEHICLE CONTROL, AND COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE TIRES THAT ARE MARKED "LOAD RANGE "B" AND REPLACE IT WITH A "LOAD RANGE "C" TIRE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-445-3307.

Notes

FLEETWOOD RECALL NO. 51024.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

PROPANE GAS PIPE INSTALLATION

NHTSA #05V433000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Lines and Fittings · NHTSA notice

Reported September 27, 2005 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 180 vehicles

Fleetwood campaign 50825 · Owners notified October 24, 2005 · Vehicles built February 7, 2003 – March 29, 2005 (per NHTSA)

Defect description

ON CERTAIN FIFTH WHEEL TRAILERS, THE PROPANE GAS LINES THAT RUN THROUGH THE FLOOR OF THE SLIDE OUT ROOM PENETRATE THE FLOOR TOO FAR FROM THE OUTSIDE WALL CAUSING THE POTENTIAL FOR PINCHED LINES DURING SLIDE OUT ROOM OPERATION.

Safety consequence

THIS COULD LEAD TO A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.

Manufacturer remedy

DEALERS WILL INSPECT AND, AS NECESSARY, REROUTE THE PROPANE GAS LINE. THIS RECALL BEGAN ON OCTOBER 24, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

Notes

FLEETWOOD RECALL NO. 50825.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

CHASSIS CROSS MEMBER WELDS

NHTSA #05V289000 · Structure · NHTSA notice

Reported June 21, 2005 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 496 vehicles

Fleetwood campaign 50615 · Owners notified August 4, 2005 · Vehicles built January 1, 2003 – January 31, 2004 (per NHTSA)

Defect description

CERTAIN FIFTH WHEEL TRAVEL TRAILERS HAVE MISSING WELDS ON THE CHASSIS CROSS-MEMBERS.

Safety consequence

THIS CONDITION CAN CAUSE THE CROSS-MEMBER TO BECOME DISLODGED, CREATING A ROAD HAZARD IF THE FIFTH WHEEL TRAVEL TRAILER IS IN MOTION, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

LIPPERT COMPONENTS, IN CONJUNCTION WITH FLEETWOOD, WILL INSPECT THE CROSS-MEMBERS FOR MISSING WELDS, REPAIR THE WELDS IF NECESSARY, AND ADD ADDITIONAL SUPPORT TO THE AFFECTED AREA. OWNERS MAY CONTACT LIPPERT DIRECTLY AT 1-866-524-7821 TO MAKE ARRANGEMENTS TO HAVE THIS INSPECTION AND REPAIR PERFORMED. THE RECALL BEGAN ON AUGUST 4, 2005.

Notes

FLEETWOOD RECALL NO. 50615. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FLEETWOOD/ALUMINUM WHEELS

NHTSA #04V310000 · Wheels · NHTSA notice

Reported June 28, 2004 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 3,426 vehicles

Fleetwood campaign 40521 · Owners notified August 5, 2004 · Vehicles built January 4, 2002 – April 21, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN FIFTH WHEEL AND CONVENTIONAL TRAVEL TRAILERS EQUIPPED WITH ALUMINUM WHEELS MAY NOT HAVE HAD THE PROPER WHEEL LUG NUT TORQUE APPLIED. ADDITIONALLY, PAINT APPLIED TO THE MATING SURFACE OF THE HUB MAY CAUSE THE LUG NUTS TO BE MORE SENSITIVE TO LOOSENING DURING THE INITIAL SETTLING-IN OF COMPONENTS AND AFTER A WHEEL HAS BEEN REMOVED FOR SERVICE.

Safety consequence

A WHEEL SEPARATION COULD OCCUR, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT, REPAIR, OR REPLACE ANY DAMAGED WHEELS, LUG NUTS, LUG STUDS, AND MATING SURFACES. DEALERS WILL ALSO REMOVE PAINT FILM FROM THE MATING SURFACES. THE RECALL BEGAN ON AUGUST 5, 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-509-3418.

Notes

FLEETWOOD RECALL NO. 40521.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FLEETWOOD/SIEMENS/CIRCUIT BREAKERS

NHTSA #04V145000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice

Reported March 22, 2004 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 765 vehicles

Fleetwood campaign 40322 · Owners notified April 14, 2004 · Vehicles built July 18, 2003 – September 10, 2003 (per NHTSA)

Defect description

ON CERTAIN CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH SIEMENS Q CIRCUIT BREAKER, THE CIRCUIT BREAKERS WERE MIS-MARKED.

Safety consequence

THIS COULD RESULT IN AN OVERHEATED CONDUCTOR IN A SUSTAINED OVERLOAD CONDITION WHICH COULD CAUSE PERSONAL INJURY AND/OR PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE CIRCUIT BREAKER IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN BY APRIL 5, 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Notes

FLEETWOOD RECALL NO. 40322.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FLEETWOOD/WHEEL LUG NUT TORQUE

NHTSA #03V437000 · Wheels · NHTSA notice

Reported November 4, 2003 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 4,933 vehicles

Fleetwood campaign 31028 · Owners notified November 26, 2003 · Vehicles built January 4, 2002 – May 31, 2003 (per NHTSA)

Defect description

ON CERTAIN CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS, THE OWNER MANUALS EITHER DO NOT CONTAIN THE WHEEL LUG NUT TORQUE INFORMATION OR CONTAIN INCORRECT WHEEL LUG NUT TORQUE INFORMATION FOR THE OPTIONAL "ALUMINUM WHEEL"

Safety consequence

VEHICLE OPERATION WITHOUT THE PROPER TORQUE APPLIED TO THE WHEEL LUG NUTS COULD RESULT IN THE LUG NUTS BECOMING LOOSE AND A WHEEL SEPARATION THAT COULD RESULT IN A CRASH.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH A LABEL AND INSERT TO BE ADDED TO THE OWNER'S MANUAL. IF THE VEHICLE HAS THE "ALUMINUM WHEEL" OPTION, OWNERS ARE REQUESTED TO BRING THEIR VEHICLE INTO A DEALER TO HAVE THE WHEEL LUG NUTS TORQUED TO THE PROPER SPECIFICATIONS. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2003. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.

Notes

FLEETWOOD RECALL NO. 31028.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FLEETWOOD/SAMSUNG/MICROWAVE

NHTSA #03V452000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 4, 2003 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 60,877 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2004 Fleetwood Terry. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

8 owner complaints have been filed with NHTSA for the 2004 Fleetwood Terry.

Structure; Unknown or Other

ODI #11383230

Incident: December 12, 2020 · Filed: December 13, 2020

THE FRAME OF MY FIFTH WHEEL CAMPING TRAILER BROKE IN TWO WHERE THE KING PIN BOX IS WELDED IN THE FRONT WHILE I WAS TOWING IT ON THE HIGHWAY. I WAS TOWING AT APPROXIMATELY 60 MPH WHEN I WENT OVER AN OVERPASS WITH AN UNEVEN LIP AT ITS EDGE WHICH CAUSED THE FAILURE. ONLINE RESEARCH THAT I'VE DONE SHOWS THAT THIS IS A PROBLEM COMMON TO TRAILER FRAMES MADE BY LIPPERT COMPONENTS AND SUPPLIED TO NUMEROUS RV MANUFACTURERS. IT IS CHALKED UP TO "NORMAL WEAR AND TEAR". LIPPERT ONLY WARRANTIES THEIR TRAILER FRAMES FOR TWO YEARS. IN MY OPINION, A VEHICLE, REGARDLESS OF TYPE OR SIZE, SHOULD NEVER SUFFER A BROKEN FRAME DUE TO WEAR AND TEAR. THIS IS A TREMENDOUS SAFETY HAZARD THAT MUST BE ADDRESSED.

Equipment

ODI #10386794

Incident: February 28, 2011 · Filed: March 7, 2011

2004 TERRY TRAILER W/ DOMETIC REFRIGERATOR MODEL 2852 SERIAL# 605-03267. ITEM WAS RECALLED FOR DEFECT BUT WAS NEVER NOTIFIED OF THIS UNTIL FAILURE OF COMPONENT. DOMETIC REFUSING TO REPAIR REFRIGERATOR. DUE TO THE LEAKAGE OF AMMONIA THIS IS A SAFETY HAZARD. *TR

Structure

ODI #10344038

Fire

Incident: July 15, 2010 · Filed: July 19, 2010

TL*THE CONTACT OWNS A 2004 FLEETWOOD TERRY TRAILER. WHILE DRIVING 55 MPH THE FIRE ALARMS IN THE TRAILER WERE ACTIVATED. AFTER EXAMINING THE VEHICLE THE CONTACT NOTICED THAT THE REAR PASSENGER TIRE WAS RUBBING AGAINST THE TIRE WHEEL WELL CAUSING SMOKE TO ACCUMULATE. THE FIRE DEPARTMENT WAS NOT NOTIFIED. THE FAILURE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE MILEAGE WAS NOT AVAILABLE.

Equipment

ODI #10249380

Fire

Incident: November 7, 2008 · Filed: November 20, 2008

TL*THE CONTACT OWNS A 2004 FLEETWOOD TERRY. THE VEHICLE HAS A DOMETIC REFRIGERATOR, MODEL RM2652. THE CONTACT STATED THAT THE TRAILER CAUGHT FIRE AND WAS COMPLETELY DESTROYED. A UTILITY BUILDING ALSO SUSTAINED DAMAGE. THE FIRE DEPARTMENT AND THE INSURANCE INVESTIGATOR STATED THAT THE REFRIGERATOR WAS THE CAUSE OF THE FAILURE. THERE WERE NO INJURIES AND A FIRE REPORT WAS FILED. THE SERIAL AND PART NUMBERS WERE UNKNOWN. THE FAILURE MILEAGE WAS NOT APPLICABLE. UPDATED 12/12/08 *CN UPDATED 12/15/08

Structure

ODI #10164102

Incident: August 1, 2006 · Filed: August 1, 2006

DT*: THE CONTACT STATED THAT THE CENTER SUPPORT BETWEEN THE AXLE BROKE WHICH CAUSED THE CAMPER TO SHIFT 3 INCHES AND ADDED FRICTION TO THE TIRES. THERE WAS A NHTSA RECALL, # 05V289000 , REGARDING THE STRUCTURE. THE VIN WAS NOT INCLUDED IN THE RECALL. THE DEALERSHIP HAD AGREED TO REPLACE THE BEAM THAT BROKE AND PLACE A SUPPORT BEAM IN THE FRONT AND IN THE BACK.

Structure

ODI #10151887

Filed: February 15, 2006

2004 TERRY 5TH WHEEL CAMPER HAS A ROD AND ANGLE CROSS MEMBER WELD AND POOR DESIGN WEAKNESS PROBLEM. *TS ***NO ANSWER REQUIRED*** THE CONSUMER STATED THERE IS A RECALL REGARDING THE ISSUE, HOWEVER HE IS HAVING DIFFICULTY GETTING A DEALER TO FIX IT. THE CONSUMER DID EVENTUALLY FIND SOMEONE TO PERFORM THE RECALL, HOWEVER HE HAD TO PAY FOR THE REPAIRS. RECALL 05V289000 *JB

Suspension

ODI #10131966

Incident: April 6, 2004 · Filed: September 23, 2005

DT: CALLER SAID THAT TRAVEL TRAILER CAME FROM THE FACTORY WITH A BENT AXLE AND AXLE ALIGNMENT. CALLER SAID VEHICLE JUMPED AROUND THE ROAD. DEALER FIXED THE PROBLEM. MANUFACTURER PAID DEALER FOR THE REPAIRS. CALLER WAS CONCERNED ABOUT VEHICLE SAFETY ON THE ROAD. *AK

Tires

ODI #10127248

Incident: April 1, 2005 · Filed: July 1, 2005

DT: CONTACT HAD THREE BLOWOUTS ON THREE DIFFERENT OCCASIONS ON TRAILER. CONTACT STATES THE TRAILER WAS NOT OVER LOADED, AND HE WAS GOING THE SPEED LIMIT. THE VIN NUMBER AND OTHER INFORMATION WAS NOT AVAILABLE. *AK

Other Fleetwood Terry model years

Check your 2004 Fleetwood Terry VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Terry at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN