NHTSA vehicle safety data
2008 Fleetwood Excursion Recalls & Complaints
The 2008 Fleetwood Excursion has 7 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.
NHTSA recall and complaint data for the 2008 Fleetwood Excursion. Recall data is refreshed daily from NHTSA.
2008 Fleetwood Excursion owner complaints
Owners have filed 1 complaint with NHTSA about the 2008 Fleetwood Excursion, describing incidents dated September 5, 2008.
Most-cited components
- Structure 1 complaint
Newest complaints
ODI #10265178 · Filed
DEFECTIVE ROCK WHEEL GUARD JN 2008 FLEETWOOD EXCURSION MOTORHOME. LARGE POORLY DESIGNED GUARD BRAKES AND FALL IN THE ROAD , POTENTIALLY CAUSING AN ACCIDENT. *TR
UNSECURE BATTERY CABLE HARNESS
NHTSA #09V175000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice
Reported May 21, 2009 · FLEETWOOD ENTERPRISES, INC.
Potentially affected: 383 vehicles
Fleetwood campaign 90519 · Vehicles built April 29, 2008 – April 21, 2009 (per NHTSA)
Defect description
FLEETWOOD IS RECALLING 311 MY 2008-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOUNDER DIESEL MOTOR HOME. THE BATTERY CABLE MAY BECOME DISLODGED AND COME IN CONTACT WITH THE DRIVER SHAFT CAUSING ENTANGLEMENT OR ABRASION TO THE BATTERY CABLE.
Safety consequence
THIS COULD LEAD TO AN ELECTRICAL SHORT WHICH MAY RESULT IN A FIRE OR UN-COMMANDED VEHICLE SHUTDOWN WHICH MAY RESULT IN A LOSS OF VEHICLE CONTROL.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE DAMAGE BATTERY CABLES AND SECURE THE BATTERY CABLE HARNESS ABOVE THE DRIVE SHAFT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Notes
FLEETWOOD RECALL NO. 90519.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
BATTERY CABLE
NHTSA #09V056000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice
Reported February 18, 2009 · FLEETWOOD ENTERPRISES, INC.
Potentially affected: 3,782 vehicles
Fleetwood campaign 90209 · Owners notified May 26, 2009 · Vehicles built October 1, 2005 – March 31, 2008 (per NHTSA)
Defect description
FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Safety consequence
THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Manufacturer remedy
DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Notes
FLEETWOOD RECALL NO. 90209.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
PART 567/CERTIFICATION LABEL INCORRECT
NHTSA #08V292000 · Equipment — Other — Labels · NHTSA notice
Reported July 1, 2008 · FLEETWOOD ENTERPRISES, INC.
Potentially affected: 226 vehicles
Fleetwood campaign 80624 · Owners notified July 28, 2008 · Vehicles built May 19, 2008 – June 20, 2008 (per NHTSA)
Defect description
FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.
Safety consequence
OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 28, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Notes
FLEETWOOD RECALL NO. 80624.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
TRANSVERSE BEAM/SAF HOLLAND
NHTSA #08V269000 · Suspension · NHTSA notice
Reported June 17, 2008 · DAIMLER TRUCKS NORTH AMERICA
Potentially affected: 2,506 vehicles
Manufacturer campaign FL-530 · Owners notified September 12, 2008 · Vehicles built July 31, 2007 – January 16, 2008 (per NHTSA)
Defect description
DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.
Safety consequence
IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.
Manufacturer remedy
DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.
Notes
DAIMLER TRUCKS RECALL NO. FL-530.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
INOPERATIVE INVERTER/MAGNUM
NHTSA #08V013000 · Electrical System — Wiring · NHTSA notice
Reported January 10, 2008 · FLEETWOOD ENTERPRISES, INC.
Potentially affected: 376 vehicles
Fleetwood campaign 71221 · Owners notified February 19, 2008 · Vehicles built April 18, 2007 – November 8, 2007 (per NHTSA)
Defect description
ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.
Safety consequence
OVERHEATING OF THE INVERTER MAY RESULT IN A POTENTIAL FIRE.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE THE INVERTER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 19, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Notes
FLEETWOOD RECALL NO. 71221.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
PROPANE HOSE ABRASION OR KINKING
NHTSA #07V365000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Lines and Fittings · NHTSA notice
Reported August 15, 2007 · FLEETWOOD ENTERPRISES, INC.
Potentially affected: 41 vehicles
Fleetwood campaign 70802 · Owners notified August 3, 2007 · Vehicles built April 5, 2007 – May 22, 2007 (per NHTSA)
Defect description
ON CERTAIN 39R MOTOR HOMES, THE PROPANE HOSE, UNDER THE GALLEY SLIDE-OUT ROOM, CAN FLEX AND MAKE CONTACT WITH OTHER COMPONENTS DURING THE SLIDE-OUT ROOM OPERATION.
Safety consequence
THIS MAY LEAD TO ABRASION OR KINKING OF THE PROPANE HOSE WHICH MAY RESULT IN A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.
Manufacturer remedy
FLEETWOOD WILL REPLACE THE PROPANE GAS HOSE IF IT IS KINKED OR DAMAGED. IF THE HOSE IS NOT KINKED OR DAMAGED, FLEETWOOD WILL INSTALL INSULATED LOOP CLAMPS TO SECURE THE PROPANE HOSE AWAY FROM COMPONENTS. FLEETWOOD BEGAN CALLING CUSTOMERS ON AUGUST 3, 2007. A CUSTOMER NOTIFICATION MAILING BEGAN ON SEPTEMBER 6, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
Notes
FLEETWOOD RECALL NO. 70802.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
STEERING ARM/TIE ROD ARM
NHTSA #07V306000 · Steering · NHTSA notice
Reported July 18, 2007 · FREIGHTLINER LLC
Potentially affected: 18,000 vehicles
Manufacturer campaign FL-501 · Owners notified December 21, 2007 · Vehicles built February 15, 2007 – April 25, 2007 (per NHTSA)
Defect description
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Safety consequence
INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Manufacturer remedy
THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-501.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Other Fleetwood Excursion model years
Check your 2008 Fleetwood Excursion VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Excursion at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Fleetwood VIN