NHTSA vehicle safety data

2006 Fleetwood Excursion Recalls & Complaints

The 2006 Fleetwood Excursion has 5 NHTSA recall campaigns and 7 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2006 Fleetwood Excursion. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Fleetwood Excursion owner complaints

Owners have filed 7 complaints with NHTSA about the 2006 Fleetwood Excursion, describing incidents dated December 30, 2005 to January 1, 2014.

Most-cited components

Equipment 3 complaints
Visibility/Wiper 3 complaints
Electrical System 1 complaint
Latches/Locks/Linkages 1 complaint
Service Brakes 1 complaint
Steering 1 complaint

Of the 7 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10607894 · Filed July 2, 2014
TL* THE CONTACT OWNS A 2006 FLEETWOOD EXCURSION. THE CONTACT STATED THAT THE DUAL PANE WINDOW BECAME FOGGED AND IMPAIRED HIS VISION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,000.
ODI #10588322 · Filed May 14, 2014
THE WINDOWS STARTED FOGGY UP IN MY RV AND HAVE STEADY GOTTEN WORSE, ESPECIALLY THE DRIVERS WINDOW. AT NIGHT IT'S ALMOST IMPOSSIBLE TO SEE OUT OF THE SIDE MIRROR DUE TO THE "FOGGING" OF THE WINDOW. FROM THE MANY COMPLAINTS I HAVE READ FROM OTHER RVERS, FLEETWOOD SEEMS TO HAVE USED INFERIOR WINDOWS…
ODI #10470823 · Filed August 15, 2012
BOUGHT A 2006 FLEETWOOD EXCURSION NEW IN 2007 WITH IN 3 YEARS SEVERAL WINDOWS LOST THEIR SEAL. TOTAL OF 5 SO FAR INCLUDING WINDOW BY DRIVER'S SEAT,CAUSING PROBLEMS WITH VISION. I CONTACTED FLEETWOOD WHO SAID THEY HAD NO LIABILITY. I CONTACTED A GLASS COMPANY WHO SAID THAT SHOULD NOT HAVE OCCURRED…

Read all 7 complaints

BATTERY CABLE

NHTSA #09V056000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice

Reported February 18, 2009 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 3,782 vehicles

Fleetwood campaign 90209 · Owners notified May 26, 2009 · Vehicles built October 1, 2005 – March 31, 2008 (per NHTSA)

Defect description

FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.

Safety consequence

THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.

Manufacturer remedy

DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO. 90209.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR/DOMETIC

NHTSA #08V320000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 15, 2008 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 70,101 vehicles

Owners notified October 24, 2008 · Vehicles built April 1, 2003 – November 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ENTRY STEP

NHTSA #06V055000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported February 23, 2006 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 1,236 vehicles

Fleetwood campaign 60220 · Owners notified March 17, 2006 · Vehicles built September 1, 2005 – December 31, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.

Safety consequence

THIS WILL MAKE THE STEP INOPERABLE AND POSSIBLY RESULT IN A RISK OF PERSONAL INJURY, VEHICLE OR OTHER PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO.60220.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

CERTIFICATION LABEL

NHTSA #06V032000 · Equipment — Other — Labels · NHTSA notice

Reported February 8, 2006 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 42 vehicles

Fleetwood campaign 60123 · Owners notified February 27, 2006 · Vehicles built June 20, 2005 – September 1, 2005 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG MAY BE PRINTED WITH THE INCORRECT GROSS VEHICLE WEIGHT RATING (GVWR) WEIGHT VALUE OF 31,000 POUNDS. THE CORRECT GVWR WEIGHT VALUE IS 28,000 POUNDS. THE SAME WEIGHT ERROR MAY OCCUR ON THE CARGO CARRYING CAPACITY TAG.

Safety consequence

OVERLOADING COULD DAMAGE THE VEHICLE, ADVERSELY AFFECTING VEHICLE PERFORMANCE INCLUDING HANDLING AND BRAKING, CAUSE TIRE FAILURE, AND RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL SEND REPLACEMENT LABELS ALONG WITH INSTRUCTIONS. IF NECESSARY, DEALERS WILL CHANGE CERTAIN FRONT SUSPENSION COMPONENTS AND CERTIFY THE CHASSIS FOR THE 31,000 POUNDS GVWR WEIGHT VALUE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO. 60123.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

INCORRECT TOW HITCH CERTIFICATION LABEL

NHTSA #05V333000 · Equipment — Other — Labels · NHTSA notice

Reported July 27, 2005 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 2,435 vehicles

Fleetwood campaign 50719 · Owners notified August 4, 2005 · Vehicles built June 1, 2004 – April 11, 2005 (per NHTSA)

Defect description

CERTAIN DIESEL CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE MANUFACTURERS' TOW HITCH RECEIVER INFORMATION LABEL WAS PRINTED WITH THE INCORRECT WEIGHT CARRYING CAPACITY VALUE AND THE INCORRECT TONGUE WEIGHT VALUE.

Safety consequence

THE WEIGHT LABEL ON THE HITCH RECEIVER PROVIDES THE MAXIMUM TRAILER WEIGHT RATING AND THE MAXIMUM TONGUE WEIGHT RATING. IT IS IMPORTANT THAT THESE RATINGS NOT BE EXCEEDED. FAILURE TO COMPLY COULD RESULT IN DAMAGE TO THE MOTOR HOME FRAME, BODY, OR HITCH RECEIVER AND COULD CAUSE UNSTABLE DRIVING AND HANDLING CHARACTERISTRICS WHICH MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FLEETWOOD WILL MAIL OWNERS THE CORRECT TOW HITCH RECEIVER WEIGHT INFORMATION LABEL. IF OWNERS DO NOT FEEL COMFORTABLE INSTALLING THE LABEL, DEALERS WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN AUGUST 4, 2005. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Notes

FLEETWOOD RECALL NO. 50719. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Fleetwood Excursion. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

7 owner complaints have been filed with NHTSA for the 2006 Fleetwood Excursion.

Visibility

ODI #10607894

Incident: January 1, 2014 · Filed: July 2, 2014

TL* THE CONTACT OWNS A 2006 FLEETWOOD EXCURSION. THE CONTACT STATED THAT THE DUAL PANE WINDOW BECAME FOGGED AND IMPAIRED HIS VISION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,000.

Visibility; Visibility/Wiper

ODI #10588322

Incident: August 15, 2012 · Filed: May 14, 2014

THE WINDOWS STARTED FOGGY UP IN MY RV AND HAVE STEADY GOTTEN WORSE, ESPECIALLY THE DRIVERS WINDOW. AT NIGHT IT'S ALMOST IMPOSSIBLE TO SEE OUT OF THE SIDE MIRROR DUE TO THE "FOGGING" OF THE WINDOW. FROM THE MANY COMPLAINTS I HAVE READ FROM OTHER RVERS, FLEETWOOD SEEMS TO HAVE USED INFERIOR WINDOWS WHEN THE RV WAS MANUFACTURED. I HAVE NEVER RECEIVED A RECALL ON THESE WINDOWS FROM FLEETWOOD FOR REPLACEMENT DUE TO THE INFERIOR PRODUCT. I HAVE GOTTEN AN ESTIMATE FOR THE COSTS TO FIX THE WINDOWS THAT IS OVER $2000, NOT INCLUDING THE COSTS TO DRIVE THE RV TO THE REPAIR SHOP APPROXIMATELY 175 MILES FROM MY HOME AND TIME LOST FROM WORK SINCE MOST REPAIR SHOPS ARE ONLY OPEN M-F. I BELIEVE FLEETWOOD SHOULD BE RESPONSIBLE FOR FIXING THEIR PROBLEM DUE TO USE OF A PRODUCT THAT CREATES A POTENTIAL DANGER FOR VISIBILITY ESPECIALLY DUE TO THE HUGE INVESTMENT I HAVE PUT INTO THEIR PRODUCT. I SHOULD NOT HAVE TO INCUR THE COSTS TO REPLACE WINDOWS THAT ARE FAULTY. *TR

Visibility; Structure; Equipment

ODI #10470823

Incident: August 15, 2009 · Filed: August 15, 2012

BOUGHT A 2006 FLEETWOOD EXCURSION NEW IN 2007 WITH IN 3 YEARS SEVERAL WINDOWS LOST THEIR SEAL. TOTAL OF 5 SO FAR INCLUDING WINDOW BY DRIVER'S SEAT,CAUSING PROBLEMS WITH VISION. I CONTACTED FLEETWOOD WHO SAID THEY HAD NO LIABILITY. I CONTACTED A GLASS COMPANY WHO SAID THAT SHOULD NOT HAVE OCCURRED . I HAVE OWNED CARS 40 TO 50 YEARS OLD WHICH DID NOT HAVE THIS PROBLEM . IS THERE NOT A STANDARD FOR GLASS INSTALLED IN MOTORHOMES. THANKS FOR ANY HELP HERE REPLACEMENT WILL RUN 200 TO 300 EACH ,BUT I THINK THIS IS A FLEETWOOD DEFECT. *TR

Equipment

ODI #10236125

Incident: June 28, 2008 · Filed: July 28, 2008

TL*THE CONTACT OWNS A 2006 FLEETWOOD EXCURSION. THE MOTOR HOME WAS JACKED UP AND LEVELED. WHEN THE CONTACT PRESSED THE BUTTON TO RETRACT THE JACKS, ALL BUT ONE RETRACTED BECAUSE IT WAS HUNG UP. HE CALLED ROADSIDE ASSISTANCE AFTER TWO HOURS OF ATTEMPTING TO GET IT BACK IN AND HE EVEN USED HYDRAULIC PRESSURE TO ASSIST. HE IS CURRENTLY WAITING FOR ANOTHER JACK TO BE MADE FOR THE MOTOR HOME. THE CURRENT AND FAILURE MILEAGES WERE 40,000.

Latches/Locks/Linkages; Equipment

ODI #10219148

Incident: April 14, 2007 · Filed: February 25, 2008

SLIDE TRAVEL LOCKS FAILED TO ENGAGE. *TR

Electrical System

ODI #10177358

Incident: March 27, 2006 · Filed: December 29, 2006

WHY DOESN'T FLEETWOOD SAFETY RECALL # 06004 SHOW UP IN THE NHTSA DATABSE. ISN'T IT THE SAME KWIKEE STEP & SIMILAR WIRING PROBLEM AS FLEETWOOD'S RECALL # 60220 FOR SIMILAR VEHICLES. WHILE THIS RECALL IS CALLED AN UPGRADE NOTING THAT "THE WIRE IS NOT INTENDED TO CARRY THIS AMOUNT OF ELECTRICAL ENERGY & MAY BURN THROUGH AND MELT" , #60220 REGARDS THIS AS A SAFETY HAZARD.

Steering; Service Brakes, Hydraulic

ODI #10149871

Crash

Incident: December 30, 2005 · Filed: February 9, 2006

DT*: THE CONTACT STATED WHILE DRIVING 60 MPH AT NIGHT THE STEERING WHEEL MADE A WINDING NOISE AND WAS HARD TO MANEUVER CAUSING THE VEHICLE TO HIT AN OBJECT. THIS OCCURRED ON NORMAL ROAD CONDITIONS AND DURING NORMAL STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP REPLACED THE STEERING PUMP, BOTH FRONT BRAKES AND PADS WHICH REMEDIED THE PROBLEM. THE MANUFACTURER WAS ALERTED. UPDATED 3/9/2006 - *NM

Other Fleetwood Excursion model years

Check your 2006 Fleetwood Excursion VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Excursion at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN