2016 Fiat 500 Recalls, Ratings & Complaints

Incident: May 17, 2025 · Filed: May 22, 2025

El auto se detuvo sin avisar solo ya no quiso acelerar. Me marcó muchas fallas en las cuales les tomé foto, me tuvieron que remolcar y mi hijo se pegó en la cabeza, por suerte nada grave. Pondre las fotos de los códigos que aparecen. Tuve q ser remolcado hasta ahorita la batería sigue en un 47% pero aún así sigue sin funcionar el vehículo

Incident: July 11, 2023 · Filed: July 12, 2023

The contact owns a 2016 Fiat 500. The contact stated while driving 50 MPH, the transmission was slipping, and the vehicle lost motive power. No warning light was illuminated. The failure recurred several times. The contact restarted the vehicle and forcefully shifted the transmission into 2nd gear to prevent losing motive power. The contact was able to drive to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,350.

Incident: May 6, 2022 · Filed: May 13, 2022

Passenger side drive axle failed on 2016 500e with only 35650 miles but no longer under warranty. Method of failure: Bolts holding axle to transmission sheered resulting in a loss of power. Car was brought to Orange County Chrysler for repair. Dealer informed me that there was a Chrysler Recall N51 for 2013 Fiat 500e for the same problem, but it didn't apply to my year. Numerous blogs on the internet show similar failures for newer models. A sound engineering fix should be developed and implemented as a Safety Recall.

Incident: June 20, 2018 · Filed: March 31, 2020

MY VEHICLE WAS T-BONED ON MY DRIVERSIDE DOOR. THE VEHICLE THAT HIT ME WAS GOING 50MPH ACCORDING TO THE POLICE REPORT. I WAS CROSSING THE STREET AT ABOUT 10-15MPH. NOT A SINGLE AIRBAG ENGAGED, SIDE CURTAIN, SEAT, ETC. IT WAS ON A CITY STREET AND THE CAR THAT HIT ME WAS SPEEDING.

Incident: July 15, 2019 · Filed: December 11, 2019

FIAT 500E VEHICLE BRAKING BEHAVIOR IS UNEXPECTEDLY HARD, SUDDEN, OR UNPREDICTABLE UNTIL THE USER USES AN OBD SCAN TOOL WITH APPROPRIATE DIAGNOSTIC SOFTWARE- AND INITIATES BRAKE CONTROLLER SENSOR RE-CALIBRATION. THIS OPTION IS FOUND UNDER THE DIAGNOSTIC MENU UNDER: ABS>RENENERATIVE BRAKE CONTROLLER>ACTIVE DIAGNOSTICS, AND THEN SELECTING THE PROCEDURE TO START (RBC SENSOR CALIBRATION). ONLINE FORUM USERS (PLEASE SEE LINK BELOW) ARE CURRENTLY USING 3RD PARTY SOFTWARE, AT THEIR OWN EXPENSE, TO CORRECT THE BRAKING DEFICIENCY (APPROXIMATELY $49). MY PERSONAL VEHICLE WAS PURCHASED USED AND WAS EXHIBITING SUDDEN AND UNEXPECTED BRAKING ISSUES AT APPROXIMATELY 8,500 MILES; THIS IS IN MY OPINION A VERY LOW NUMBER OF MILES TO BE EXPERIENCING REGENERATE BRAKING AND CONTROL ISSUES. PLEASE REFERENCE THE ONGOING DISCUSSION THREAD AT FIAT 500E ONLINE FORUMS: HTTPS://WWW.FIAT500OWNERS.COM/THREADS/FIX-GRABBY-BRAKES-FOR-70.149282/#POST-1292483

Incident: August 19, 2019 · Filed: September 27, 2019

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE DRIVING 45 MPH, THE MANUAL CLUTCH FAILED AND PREVENTED THE CONTACT FROM CHANGING GEARS. AS A RESULT, THE CONTACT DROVE INTO A CEMENT BARRIER TO AVOID TRAFFIC. THE DRIVER AND PASSENGER FRONTAL AIR BAGS FAILED TO DEPLOY, CAUSING THE CONTACT'S HEAD TO STRIKE THE STEERING WHEEL. THE CONTACT INJURED HER NECK, LEFT SHOULDER, AND LEFT FOOT. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL BY FAMILY MEMBERS. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. *DT *TR *DT*JB

Incident: March 1, 2019 · Filed: March 20, 2019

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHIFTED INTO NEUTRAL WITHOUT WARNING AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE WIRE HARNESS AND POWER TRAIN CONTROL MODULE NEEDED TO BE REPAIRED. THE CONTACT SCHEDULED AN APPOINTMENT WITH ACADIANA DODGE CHRYSLER JEEP RAM FIAT (1700 SW EVANGELINE THRUWAY, LAFAYETTE, LA 70508, (337) 232-7361). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 67,000.

Incident: August 1, 2017 · Filed: August 17, 2018

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE OPERATING THE VEHICLE, THE TRANSMISSION JERKED AND SHIFTED ROUGHLY. OCCASIONALLY, THE VEHICLE WOULD SHIFT OUT OF GEAR AND FAIL TO IMMEDIATELY ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER (NYLE MAXWELL FIAT, 13049 RESEARCH BLVD, AUSTIN, TX) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS FAULTY. COMPUTER UPDATES WERE PERFORMED TO THE POWER TRAIN CONTROL MODULE AND THE TRANSMISSION CONTROL MODULE, BUT THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 28,000.

Incident: June 3, 2018 · Filed: June 21, 2018

CAR SWITCHES INTO NEUTRAL UNEXPECTEDLY CREATING A DANGEROUS INOPERABLE VEHICLE SCENARIO WHERE THE CAR WILL NOT MOVE FOR SEVERAL SECONDS. THIS HAS HAPPENED TO ME SEVERAL TIMES ON THE OPEN ROAD AND ALMOST CAUSED ME TO GET HIT FROM BEHIND. THIS IS A REGULAR OCCURRENCE WHICH I HAVE TO PREDICTIVELY ALLOW FOR BY ANTICIPATING THIS MAY HAPPEN.

Incident: November 28, 2017 · Filed: December 3, 2017

ON MULTIPLE OCCASIONS MY WIFE'S CARE HAS REFUSED TO SRMTART WITH NOW ANSWER FROM THE DEALERSHIP WHY, THE BRAKES HAVE BEEN REPLACED BY FIAT UNDER WARRANTY AND THEY STILL SQUEAK WHEN IN REVERSE, AND LATELY IT SAYS THERE IS A TIRE SENSOR THAT IS DAMAGED OR LOW ALONG WITH DRIVE MODE UNAVAILABLE, THIS KEEPS US FROM USING THE AWD SYSTEM EFFECTIVELY, AND FIAT SAID THEY FIXED THE ISSUE ONCE BEFORE AND IT CAME BACK WITHIN THE WEEK. THE CAR HAS HAD ELECTRICAL PROBLEMS FROM THE DAY SHE BOUGHT IT ALONG WITH MULTIPLE OCCASIONS WITH NOT STARTING AND MULTIPLE COMPUTER PROBLEMS WITH NOW HELP FROM THE DEALERSHIPS, THIS CAR IS STILL COVERED UNDER ALL WARRANTIES AND STILL CAUSES PROBLEMS WITH MY WIFE GOING TO WORK. ON TWO OCCASIONS THE DRIVE MODE UNAVAILABLE ERROR CAME UP WHILE DRIVING, THIS DOESN'T ALLOW THE CAR TO OPERATE THE AWD SYSTEM LIKE IT SHOULD