NHTSA vehicle safety data

1996 Eagle Talon Recalls, Ratings & Complaints

The 1996 Eagle Talon has 5 NHTSA recall campaigns and 44 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Eagle dealer.

NHTSA recall and complaint data for the 1996 Eagle Talon, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1996 Eagle Talon owner complaints

Owners have filed 44 complaints with NHTSA about the 1996 Eagle Talon, describing incidents dated November 20, 1995 to November 6, 2006.

Most-cited components

Suspension 12 complaints
Power Train 9 complaints
Engine 5 complaints
Air Bags 3 complaints
Equipment 3 complaints
Fuel/Propulsion System 3 complaints

Newest complaints

ODI #10187002 · Filed April 4, 2007
TL*THE CONTACT OWNS A 1996 EAGLE TALON. WHILE DRIVING 60 MPH THE CONTACT HEARD A NOISE AND THE TIRES LOCKED U WITHOUT WARNING. THE VEHICLE WAS TOWED ,AND A LOCAL MECHANIC DIAGNOSED THE FAILURE AS A LEAK IN THE TRANSFER CASE. THE DEALER/MANUFACTURER DIAGNOSED THE VEHICLE AS NEEDING A NEW TRANSFER…
ODI #10174868 · Filed December 1, 2006
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, A GASOLINE ODOR FUMIGATED THE VEHICLE ON A CONSISTENT BASIS. THE CONTACT ENCOUNTERED MANY COMPLAINTS ON THIS MATTER # 509463 REGARDING FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY. THE VEHICLE HAD NOT BEEN EXAMINED BY A MECHANIC OR DEALER.
ODI #10152168 · Filed March 8, 2006
THE TRANSFER CASE WENT OUT OF MY TALON TSI AWD TURBO IN 06/05. I WAS DRIVING DOWN THE ROAD 75 MPH & BANG!-JERK!BANG!JERK!BANG!JERK! THE STEERING WHEEL ALSO FELT FUNNY, LIKE IT GOT LOOSE AND WASN'T HOOKED TO THE TIRES ANYMORE. I PULLED OVER THE AND HEARD A LOUD CLUNK (METAL ON METAL SORT OF SOUND)…

Read all 44 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 1996 Eagle Talon in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA98-002: TRANSFER CASE LOCKUP
Closed April 30, 1998
- Recall 98V069001
- Recall 98V069002
Preliminary Evaluation PE97-040: TRANSFER CASE LOCKUP
Closed January 30, 1998

Open and recently closed NHTSA defect investigations

AFTERMARKET FUEL PUMP MODULE ASSEMBLIES/LEAKS

NHTSA #07E055000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported July 26, 2007 · AIRTEX PRODUCTS

Potentially affected: 222 vehicles

Manufacturer campaign FP072007-1 · Owners notified November 19, 2007

Defect description

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Safety consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Manufacturer remedy

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DAIMLERCHRYSLER/LOWER BALL JOINT BOOT

NHTSA #00V421002 · Suspension — Front — Control Arm — Lower Ball Joint · NHTSA notice

Reported December 18, 2000 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 393,796 vehicles

Manufacturer campaign 967 · Owners notified May 21, 2001 · Vehicles built March 1, 1994 – January 31, 1998 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Safety consequence

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Manufacturer remedy

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DAIMLERCHRYSLER/LOWER BALL JOINT BOOT

NHTSA #99V066003 · Suspension — Front — Control Arm — Lower Ball Joint · NHTSA notice

Reported April 5, 1999 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 165,857 vehicles

Manufacturer campaign 827 · Owners notified August 2, 1999 · Vehicles built June 16, 1994 – June 30, 1996 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Safety consequence

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Notes

OWNER NOTIFICATION BEGAN AUGUST 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

CHRYSLER/TRANSFER CASE

NHTSA #98V069002 · Power Train — Automatic Transmission · NHTSA notice

Reported April 7, 1998 · CHRYSLER CORPORATION

Potentially affected: 42,214 vehicles

Owners notified July 6, 1998 · Vehicles built May 15, 1989 – February 2, 1998 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.

Safety consequence

THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.

Notes

OWNER NOTIFICATION BEGAN JULY 6, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

CHRYSLER/FUEL

NHTSA #96V158002 · Fuel System, Gasoline · NHTSA notice

Reported August 27, 1996 · CHRYSLER CORPORATION

Potentially affected: 9,616 vehicles

Owners notified November 27, 1996 · Vehicles built March 1, 1994 – July 31, 1996 (per NHTSA)

Defect description

THE FUEL TANK GASKETS FOR THE FUEL PUMP AND/OR GAUGE UNIT GASKET COULD HAVE BEEN INCORRECTLY INSTALLED ALLOWING FUEL OR FUMES TO ESCAPE.

Safety consequence

IF AN IGNITION SOURCE WERE PRESENT, THE FUEL LEAKAGE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE FUEL TANK AND IF THE GASKETS ARE FOUND TO BE LEAKING, REPLACE THE FUEL TANK, CAPS AND GASKETS.

Notes

OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

1996 Eagle Talon 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

2 investigations

44 owner complaints have been filed with NHTSA for the 1996 Eagle Talon.

Power Train

ODI #10187002

Incident: November 6, 2006 · Filed: April 4, 2007

TL*THE CONTACT OWNS A 1996 EAGLE TALON. WHILE DRIVING 60 MPH THE CONTACT HEARD A NOISE AND THE TIRES LOCKED U WITHOUT WARNING. THE VEHICLE WAS TOWED ,AND A LOCAL MECHANIC DIAGNOSED THE FAILURE AS A LEAK IN THE TRANSFER CASE. THE DEALER/MANUFACTURER DIAGNOSED THE VEHICLE AS NEEDING A NEW TRANSFER CASE. THE DEALER STATED THAT THE VEHICLE WAS PART OF RECALL # 098V069002. RECORDS INDICATED THAT NO REPAIRS HAVE BEEN PERFORMED. THE CURRENT AND FAILURE MILEAGE WERE 112,000.*AK

Fuel System, Gasoline

ODI #10174868

Incident: November 2, 2004 · Filed: December 1, 2006

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, A GASOLINE ODOR FUMIGATED THE VEHICLE ON A CONSISTENT BASIS. THE CONTACT ENCOUNTERED MANY COMPLAINTS ON THIS MATTER # 509463 REGARDING FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY. THE VEHICLE HAD NOT BEEN EXAMINED BY A MECHANIC OR DEALER.

Power Train

ODI #10152168

Incident: July 15, 2005 · Filed: March 8, 2006

THE TRANSFER CASE WENT OUT OF MY TALON TSI AWD TURBO IN 06/05. I WAS DRIVING DOWN THE ROAD 75 MPH & BANG!-JERK!BANG!JERK!BANG!JERK! THE STEERING WHEEL ALSO FELT FUNNY, LIKE IT GOT LOOSE AND WASN'T HOOKED TO THE TIRES ANYMORE. I PULLED OVER THE AND HEARD A LOUD CLUNK (METAL ON METAL SORT OF SOUND) AND PUT IT INTO GEAR TO BABY IT INTO WORK, IT MADE MORE NOISES AND JERKS BUT SEEMED TO RUN. I COULD SMELL A BURNING SMELL SO I PARKED. THE SHOP PICKED IT UP AND COULD NOT FIND ANYTHING WRONG WITH IT. THEY ASKED IF I WAS SURE I KNEW WHAT I WAS TALKING ABOUT! I HAD DRIVEN THE CAR FOR 90000 MILES! I KNEW WHAT WASN'T NORMAL! I PICKED IT UP AND GUESS WHAT, IT RAN GREAT! I SPEEDED UP AND SLOWED DOWN AGAIN AND AGAIN AND IT JUST WOULDN'T ACT UP! I COULD FAINTLY SMELL THE BURNING SMELL BUT FIGURED I PICKED UP SOME PIECE OF SOMETHING OFF OF THE ROAD AND IT HAD BEEN STUCK BUT FELL OUT WHEN I STOPPED. I WENT FOR 50 MILES, NO PROBLEMS, THEN THE BANGING AND JERKING STARTED AGAIN MUCH WORSE THIS TIME. I KEPT GOING TO SEE IF IT WOULD STOP AND IT GOT SO LOUD THAT IT SOUNDED LIKE A SLEDGEHAMMER WAS HITTING SOME PART OF THE ENGINE OVER AND OVER. IT WOULD BANG-JERK- BANG -JERK ETC.. AND KEPT GETTING WORSE. THEN IT JUST DIED. THE SHIFTER WENT SLACK. THERE WAS A PUDDLE OF OIL UNDER THE CAR AND THE SMELL OF BURNING FLUID. THE MECHANIC PICKED IT UP AND REPLACED THE TRANSMISSION/TRANSFER WITH A USED ONE. I'M WONDERING IF THIS WAS THE TRANSFER CASE AND NOT THE TRANSMISSION AT ALL! THE MECHANIC SAID THERE WASN'T ENOUGH OIL IN THE TRANSMISSION. I DIDN'T KNOW IF THE TRANSFER CASE AND TRANSMISSION SHARE THE SAME OIL SUPPLY OR NOT. AFTER READING THIS ARTICLE ABOUT THE LOCKING UP THING IT MAKES PERFECT SENSE. ITS FELT JUST LIKE IT WANTED TO LOCK UP BUT FOR SOME REASON DIDN'T THAT FIRST TIME IT ACTED UP. THE TRANSMISSION PLACE SAID THEY HADN'T HEARD OF A TRANSMISSION BANGING AND CLANGING LIKE THAT. *JB

Unknown or Other

ODI #10138179

Incident: March 25, 2005 · Filed: September 29, 2005

I WENT THROUGH EMISSIONS AND FAILED BECAUSE THERE WAS AN OBD ERROR SAYING THAT MY CHECK ENGINE LIGHT IS ON, HOWEVER IT WAS NOT. I CALLED TO THE STATE EMISSIONS BOARD AND THEY SAID IT WAS A RECALL. I TOOK IT TO THE DEALERSHIP, AT THE END OF MAY AND IT HAS BEEN IN AND OUT EVER SINCE TRYING TO FIX THIS RECALL. IT HAS NOW BEEN IN THE DEALERSHIP CONSEQUENTLY FOR TWO MONTHS. THE DEALERSHIP HAS TOLD ME MORE THAN ONCE THAT THEY ARE GOING TO DO ONE MORE TEST AND THEN IF IT FAILS THEY WILL CALL CHRYSLER AND TELL THEM IT CAN NOT BE FIXED. BUT EVERY TIME THEY DO THE TEST AND IT FAILS THEY END UP DOING THE TESTS OVER AND OVER AGAIN. I ACTUALLY HAD TO PURCHASE A VEHICLE SO I WOULD HAVE A CAR TO DRIVE TO AND FROM HOME WORK SCHOOL AND DR'S APPOINTMENTS. I AM 8 MOTHS PREGNANT RIGHT NOW AND ON BED REST AND MY DOCTOR IS SAYING I DO NOT NEED ALL THIS EXTRA STRESS. I CALLED THE MANUFACTURER THREE TIMES WHOM TELLS ME ALL I CAN DO IS CONTINUE TO WORK WITH THE DEALERSHIP. I HAVE SPOKEN WITH THE GENERAL MANAGER OF THE DEALERSHIP AND SAME THING, NO ANSWERS. THE GENERAL MANAGER ACTUALLY TOLD ME TO GET A LAWYER. I HAVE WROTE THE BETTER BUSINESS BUREAU AND NOW I AM WRITING YOU. I DO NOT KNOW WHAT ELSE I CAN POSSIBLY DO. PLEASE HELP ME!! *JB

Suspension

ODI #10065605

Incident: April 5, 2004 · Filed: April 6, 2004

BALL JOINT OF FRONT RIGHT WHEEL SEPARATED AFTER HITTING BUMP ON HIGHWAY CAUSING LIMITED CONTROL OF VEHICLE. *LA

Suspension; Engine and Engine Cooling; Equipment

ODI #10065176

Filed: March 11, 2004

THE 1996 EAGLE TALON TSI HAD THE SAME DEFECTS AS THE 1995 EAGLE TALON TSI. *PH THE VEHICLE HAD MULTIPLE FAILURE TO INCLUDE THE A/C UNIT, TRANS AXLE, TRANSMISSION, UPPER AND LOWER BALL JOINTS, ENGINE AT 75000 MILES. *NM

Engine and Engine Cooling

ODI #10018872

Incident: May 16, 2003 · Filed: May 18, 2003

WE TOOK A CAR THAT WE RECENTLY PURCHASED FROM A PRIVATE PARTY TO OUR MECHANIC FOR AN OIL CHANGE AND FOUND THAT THE HEAD GASKET IS LEAKING AND IT WILL COST $1000.00 FOR REPAIR. ALSO FOUND OUT THIS IS A PROBLEM THAT THE EAGLE TALON HAD AND THAT THERE WAS NEVER A RECALL ON IT. WE FEEL THAT CHRYSLER SHOULD DO THE REPAIR AT NO COST TO US. WE WOULD APPRECIATE ANY HELP THAT YOU COULD GIVE US. THANK YOU FOR YOUR ATTENTION TO THIS MATTER. ANN PIRRELLO. *JB

Steering; Electrical System

ODI #10016156

Incident: April 18, 2003 · Filed: April 18, 2003

POWER STEERING AND ALTERNATOR BELTS FELL OFF. DURING RE-INSTALLATION AND INSPECTION OF THE CRANKSHAFT, IT WAS NOTICED THAT THE CRANKSHAFT WAS LOOSE. *NLM

Structure

ODI #8021362

Incident: September 1, 2002 · Filed: October 22, 2002

CONSUMER STATES THAT VEHICLE SHAKES AND SHIMMY'S AT HIGH SPEED AND LOWS SPEEDS THERE IS A CLUNK NOISE. PLEASE PROVIDE ANY FURTHER INFORMATION. MR

Suspension

ODI #8014352

Incident: December 10, 2001 · Filed: July 19, 2002

VEHICLE WAS TAKEN TO DEALER FOR RECALL 00V421002 REPAIRS ON LOWER BALL JOINTS. DEALER STATED THEY WERE WORN, BUT REFUSED TO REPLACE THEM. CONSUMER HAD BALL JOINTS REPLACED AT AN INDEPENDENT REPAIR SHOP. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK

Other Eagle Talon model years

Check your 1996 Eagle Talon VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Eagle Talon at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Eagle VIN