2006 Dodge Ram Recalls & Complaints

Incident: August 20, 2019 · Filed: August 5, 2022

The contact owns a 2006 Dodge Ram 1500. The contact stated that after the vehicle was repaired under NHTSA Campaign Number: 16V352000 (Air Bags), the airbag warning light remained illuminated after starting the vehicle. Additionally, the contact stated that whenever the airbag light was illuminated, there were other electrical failures with the vehicle. The contact stated that the A/C and the heater would become inoperable. The contact drove the vehicle to a local dealer who diagnosed and determined that there was an electrical short underneath the driver's side airbag sensor wiring harness. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.

Incident: February 28, 2022 · Filed: March 7, 2022

The contact owns 2006 Dodge Ram 1500. The contact stated while having the vehicle serviced by a local dealer, the fuel pump was found to be cracked and leaking fuel. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the fuel pump replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 143,000.

Incident: May 31, 2021 · Filed: June 1, 2021

The contact owns a 2006 Dodge Ram. The contact stated that the vehicle was hauling a trailer while driving at 65 mph when a loud bang was heard and the steering wheel went in circles, which led the vehicle from the center lane into the median and hit the guard rail. The rear driver's side corner of the vehicle was damaged and the front driver and front passenger side of the trailer were damaged from the collision. The contact and passenger did not sustain injuries and medical attention was not received. A police report was filed. The vehicle and trailer were towed to the contact's residence. The vehicle was not diagnosed nor repaired. The contact stated that this was a recurring failure after the tie rod assembly and steering linkage were replaced in October 2020 by an independent mechanic. The contact had also received notifications of NHTSA Campaign numbers: 09E001000 (Steering) and 13V528000 (Steering), after the repair in October 2020. The manufacturer was not made aware of the failure. The failure mileage was 100,660.

Incident: February 1, 2012 · Filed: May 13, 2012

THE RAM 1500 HAD A FAILURE OF THE TIPM THAT CONTROLS THE HEAD LIGHTS LEAVING THE TRUCK WITH INADEQUATE ILLUMINATION. *TR

Incident: March 1, 2012 · Filed: March 15, 2012

LETTER FROM CONGRESSMAN DENT ON BEHALF OF CONSTITUENT RE HEATER BOX FAILURE IN DODGE TRUCKS *TGW THE CONSUMER STATED THE INITIAL PROBLEM WITH THE FRESH AIR/RECIRCULATION DOOR STARTED 2-3 YEARS AGO. SHORTLY, AFTER REPLACING THE FRESH AIR/RECIRCULATION DOOR, THE HEAT AND DEFROSTER STOPPED WORKING. THE CONSUMER TRIED TO REPLACE THE CONTROL SWITCH IN THE DASH, THINKING IT WAS BAD AND NOT WORKING THE INTERNAL DOORS PROPERLY, BUT AFTER THE REPLACEMENT, THE PROBLEM REMAINED THE SAME. HE THEN REPLACED THE MODE DOOR ACTUATORS, AND THE MOTOR CONTROL THAT CONTROLLED THE DOORS. HOWEVER, THAT DID NOT RESOLVE THE PROBLEM EITHER. THE CONSUMER WENT TO THE DEALER WHERE HE WAS INFORMED THE ENTIRE DASH WOULD HAVE TO BE REMOVED, BECAUSE THE DOORS FAILED AND A NEW HEATER BOX WAS NEEDED. *JB..UPDATED 04/19/12 *BF UPDATED 04/23/12

Incident: January 19, 2012 · Filed: January 24, 2012

TL* THE CONTACT OWNS A 2006 DODGE RAM. THE CONTACT WAS DRIVING 40 MPH WHEN THE FRONT PASSENGER SIDE HEADLIGHT FAILED. THE CONTACT THEN PULLED OVER TO CHECK THE HEADLIGHTS BUT ONLY THE HIGH BEAMS WERE OPERABLE. THE VEHICLE WAS NOT DIAGNOSED FOR THE FAILURE. THE BULB WAS REPLACED BUT THE HEADLIGHTS WERE STILL INOPERABLE.THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 128,000 AND THE CURRENT MILEAGE WAS 128,100.

Incident: October 16, 2011 · Filed: October 17, 2011

TL* THE CONTACT OWNS A 2006 DODGE RAM. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD BECOME STUCK WHEN DEPRESSED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,470 AND THE CURRENT MILEAGE WAS 36,545.

Incident: September 26, 2011 · Filed: September 28, 2011

THE MULTI FUNCTION SWITCH WAS DEFECTIVE IN MY VEHICLE. THIS CAUSED THE FOLLOWING SAFETY CONCERNS WITH THE VEHICLE: 1) THE WINDSHIELD WIPERS DID NOT WORK, 2) THE TURN SIGNALS DID NOT WORK, AND 3) THE HAZZARD LIGHTS DID NOT WORK. I HAVE TWO PROBLEMS WITH THE SITUATION: 1) WHILE DRIVING THE VEHICLE DURING A RAIN STORM ON 9/26/2011, THE WINDSHIELD WIPERS DID NOT WORK. THIS CAUSED A SAFETY CONCERN AND COULD HAVE CAUSED A POTENTIAL ACCIDENT AND 2) WHILE DRIVING THE VEHICLE, THE TURN SIGNALS DID NOT WORK. THIS CAUSED A SAFETY CONCERN AND COULD HAVE CAUSED AN ACCIDENT. AFTER TAKING THE VEHICLE TO THE LOCAL DODGE DEALERSHIP, I WAS INFORMED THAT THE MULTI FUNCTION SWITCH WAS ON BACK ORDER. TO BE EXACT, FOUR THOUSAND MULTI FUNCTION SWITCHES WERE ON BACK ORDER PER THE LOCAL DEALERSHIP AND CHRYSLER GROUP CUSTOMER ASSISTANCE. NEITHER THE LOCAL DEALERSHIP OR THE CHRYSLER GROUP CUSTOMER ASSISTANCE HAD ANY IDEA WHEN THE PART WOULD BE AVAILABLE. I ASKED BOTH PARTIES WHY THE PART IS ON BACK ORDER SINCE THIS IS A MATTER OF SAFETY. NO ANSWER WAS GIVEN. AFTER FURTHER RESEARCH VIA THE INTERNET, IT WAS DETERMINE THAT OTHER DODGE RAM TRUCK OWNERS HAD THE SAME TYPE ISSUE WITH THEIR MULTI FUNCTION SWITCH BEING DEFECTIVE. IT WOULD BE GREAT IF DODGE WOULD NOTIFY ALL OWNERS OF THE PROBLEM WITH THE MULTI FUNCTION SWITCH AND HAVE THEM REVIEWED AND/OR REPLACED IF NEEDED. THIS COULD POTENTIALLY SAVE SOMEONE FROM SERIOUS INJURY OR DEATH FROM THE THE MULTI FUNCTION SWITCH BEING DEFECTIVE WHILE DRIVING. MY HOPE AND PRAYER IS TO HAVE OTHER DODGE RAM TRUCK OWNERS UNDERSTAND THE IMPORTANCE OF THIS PROBLEM. IT COULD POTENTIALLY SAVE THEIR LIFE. *TT

Incident: July 1, 2011 · Filed: August 2, 2011

THE LEFT TIE ROD END DROPPED OFF MY VEHICLE WHILE BACKING INTO MY DRIVEWAY. THERE HAVE BEEN RECALLS ISSUED ON SIMILAR TRUCKS. DODGE OFFERS NO HELP ON MY VEHICLE BECAUSE RECALLS ARE VIN SPECIFIC. TO REPAIR THE COST WAS $1062. IF DODGE HADN'T REDESIGNED THE PARTS, MY COST WOULD HAVE BEEN $0 DUE TO THE 3 YEAR/36,000 MILE "BUMPER TO BUMPER" WARRANTY WE PURCHASED WITH THE TRUCK. (IT WAS A USED TRUCK WHEN WE PURCHASED IT.) WHY HAVEN'T ALL OF THESE TRUCKS BEEN RECALLED FOR THIS ISSUE? I SUPPOSE THE FACT THAT THERE HAVE BEEN NO DEATHS OR MAJOR PROPERTY DAMAGE WILL BE THE REASON. THIS IS A MAJOR HIT TO ME AND MY FAMILY. WE NEED THE TRUCK. WE NEED THE $1000 IT COST TO REPAIR. DODGE SAYS THE ONLY WAY THEY CAN HELP ME IS IF THE NHTSA EXPANDS THE RECALL. I KNOW THAT WON'T HAPPEN BUT WOULD YOU PLEASE THINK ABOUT ME AND MY FAMILY'S DILEMMA THE NEXT TIME YOU ISSUE A NON-LIFE THREATENING RECALL. I THOUGHT RECALLS WERE ALL INCLUSIVE. GUESS I THOUGHT WRONG. THANKS FOR LISTENING.

Incident: July 1, 2011 · Filed: July 15, 2011

TL* THE CONTACT OWNS A 2006 DODGE RAM. THE CONTACT STATED THAT THE FLAP UNDER THE DASH BOARD WHICH OPERATED THE HEATER AND AIR CONDITIONER ON THE PASSENGER SIDE OF THE VEHICLE FRACTURED, CAUSING EXCESS AIR TO RELEASE INTO THE VEHICLE. A LOCAL MECHANIC DIAGNOSED THAT A HINGE WAS FRACTURED AND WOULD NEED TO BE REPLACED. THE DEALER TOLD THE CONTACT THAT THE PLASTIC FLAP WAS DISCONTINUED AND WOULD NEED TO BE REPLACED WITH A METAL FLAP. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 49,000 AND THE CURRENT MILEAGE WAS 49,200. MALFUNCTION OF PLASTIC SPONGE FLAP THAT ALLOWS COOLED AIR TO ENTER THE PUCALS. THE DODGE MECHANICAL DEPT. SAID THIS DEFECTIVE OR BROKEN PART HAS NOW BEEN REPLACED BY ONE MADE OF METAL. I THINK THIS SHOULD BE A RECALL AND REPLACED AT THE EXPENSE OF DODGE. THE ESTIMATED REPAIR COST IS ABOUT. UPDATED 10/12/2011 *LN *TR