NHTSA vehicle safety data

2005 Dodge Caravan Recalls, Ratings & Complaints

The 2005 Dodge Caravan has 9 NHTSA recall campaigns and 537 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2005 Dodge Caravan, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Dodge Caravan owner complaints

Owners have filed 537 complaints with NHTSA about the 2005 Dodge Caravan, describing incidents dated April 25, 2004 to August 4, 2022.

Most-cited components

Latches/Locks/Linkages 203 complaints
Electrical System 123 complaints
Exterior Lighting 90 complaints
Air Bags 49 complaints
Fuel/Propulsion System 37 complaints
Steering 28 complaints

Of the 537 complaints on file, 19 report a crash; across all 537 complaints, owners report 19 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11500887 · Filed January 9, 2023
Air bag Light stays On, even with seat belt attached, so this means air bag is not working, not sure driver side, or passenger. went to Dodge dealer, they would NOT fix it!!
ODI #11446727 · Filed January 8, 2022
The door locks do not work for the sliding doors or the passenger side of the vehicle. We tried to fix this issue by checking the door lock fuse out to make sure it was okay, and it was. The driver's side is the only one that locks. The passenger door lock will not push down and lock when pressed…
ODI #11373501 · Filed November 6, 2020
TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE AND ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE'S FAILURE BEGAN TO OCCUR WITHIN APPROXIMATELY 2 MINUTES OF STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER (MOUNTAIN…

Read all 537 complaints

Owner-reported

2005 Dodge Caravan mileage at failure

443 of the 537 complaints on file for the 2005 Dodge Caravan give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Latches/Locks/Linkages	Median 65,000 miles	Middle half 50,000–85,000 miles	Based on 166 complaints
Electrical System	Median 70,000 miles	Middle half 50,000–95,000 miles	Based on 99 complaints
Exterior Lighting	Median 90,000 miles	Middle half 55,000–115,000 miles	Based on 76 complaints
Air Bags	Median 65,000 miles	Middle half 35,000–85,000 miles	Based on 39 complaints
Fuel/Propulsion System	Median 100,000 miles	Middle half 65,000–140,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Dodge Caravan in 7 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Audit Query AQ10-001: Fleet Vehicle Recall Completion Audit
Closed December 28, 2015
Defect Petition DP14-002: Engine Stall After Refueling
Closed April 6, 2015
Engineering Analysis EA11-010: Loss of headlight illumination
Closed November 29, 2012
Preliminary Evaluation PE10-022: Loss of Headlight Illumination
Closed September 13, 2011
Recall Query RQ09-003: FRONT AIR BAG CRASH SENSOR FAILURE
Closed February 18, 2010
- Recall 10V-008

2 more NHTSA investigations

Engineering Analysis EA06-003: FRONT AIR BAG CRASH SENSOR FAILURE
Closed May 22, 2007
- Recall 07V-192
Preliminary Evaluation PE05-061: FRONT AIR BAG CRASH SENSOR FAILURE
Closed March 8, 2006

Open and recently closed NHTSA defect investigations

AFTERMARKET RECEIVER HITCH

NHTSA #10E034000 · Equipment · NHTSA notice

Reported August 10, 2010 · CURT MFG. INC.

Potentially affected: 6,686 vehicles

Owners notified August 13, 2010

Defect description

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Safety consequence

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT AIR BAG CRASH SENSOR FAILURE

NHTSA #10V008000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported January 11, 2010 · CHRYSLER GROUP LLC

Potentially affected: 308,950 vehicles

Manufacturer campaign J38 · Owners notified April 19, 2010 · Vehicles built January 19, 2005 – April 5, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Safety consequence

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Manufacturer remedy

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes

CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

FMVSS 108/REPLACEMENT HEADLAMPS

NHTSA #08E048000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 8, 2008 · EAGLE EYES TRAFFIC INDUSTRIAL CO. LTD

Potentially affected: 11,534 vehicles

Owners notified September 30, 2008

Defect description

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/LIGHT REFLECTION

NHTSA #08E039000 · Exterior Lighting — Headlights · NHTSA notice

Reported June 10, 2008 · MAXZONE AUTO PARTS CORPORATION

Potentially affected: 2,520 vehicles

Owners notified June 16, 2008

Defect description

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIR BAG SENSORS

NHTSA #07V192000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported May 3, 2007 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 270,958 vehicles

Manufacturer campaign G09/X16 · Owners notified July 2, 2007 · Vehicles built April 24, 2003 – February 2, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS INSTALLED IN THESE VEHICLES MAY CORRODE AND CRACK ALLOWING WATER TO ENTER THE SENSOR. THESE SENSORS PROVIDE ENHANCED AIR BAG PERFORMANCE IN CERTAIN TYPES OF FRONTAL CRASHES.

Safety consequence

IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.

Manufacturer remedy

FOR VEHICLES REGISTERED IN THE RECALL STATES, DEALERS WILL REPLACE THE ORIGINAL UF AIR BAG SENSORS WITH ONES WITH GREATER CORROSION RESISTANCE. VEHICLES REGISTERED IN OTHER STATES WILL OBTAIN A LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. THE CAMPAIGN BEGAN ON JULY 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER'S CAMPAIGN NOS. G09/X16. DAIMLERCHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, IT HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE. CUSTOMERS ALSO MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

BRAKE HYDRAULIC MASTER CYLINDER

NHTSA #06E022000 · Service Brakes, Hydraulic · NHTSA notice

Reported March 13, 2006 · BRAKE PARTS, INC.

Potentially affected: 7,440 vehicles

Owners notified March 20, 2006

Defect description

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Safety consequence

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT WINDSHIELD WIPER MOTOR

NHTSA #06V067000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported March 8, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 268,800 vehicles

Manufacturer campaign F10 · Owners notified June 19, 2006 · Vehicles built March 27, 2005 – July 1, 2005 (per NHTSA)

Defect description

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Safety consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DAIMLERCHRYSLER/SEAT BELT RETRACTOR ASSEMBLY

NHTSA #04V047000 · Seat Belts — Front — Retractor · NHTSA notice

Reported February 3, 2004 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 3,200 vehicles

Manufacturer campaign D04 · Owners notified February 23, 2004 · Vehicles built October 20, 2003 – January 16, 2004 (per NHTSA)

Defect description

AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.

Safety consequence

AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. D04.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2005 Dodge Caravan Early Release

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

7 investigations

2005 Dodge Caravan Later Release

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

7 investigations

537 owner complaints have been filed with NHTSA for the 2005 Dodge Caravan.

Air Bags

ODI #11500887

Incident: August 4, 2022 · Filed: January 9, 2023

Air bag Light stays On, even with seat belt attached, so this means air bag is not working, not sure driver side, or passenger. went to Dodge dealer, they would NOT fix it!!

Electrical System; Structure

ODI #11446727

Incident: June 7, 2021 · Filed: January 8, 2022

The door locks do not work for the sliding doors or the passenger side of the vehicle. We tried to fix this issue by checking the door lock fuse out to make sure it was okay, and it was. The driver's side is the only one that locks. The passenger door lock will not push down and lock when pressed down manually. I feel this is a safety issue and I have seen that others online are having problems with their door locks not working or getting stuck and not unlocking. I don't understand why there is no recall on this issue with the 2005 Dodge Grand Caravan. This is a serious safe issue on any vehicle. My sliding doors have to be manually locked and as I said, the passenger side won't lock, so it's dangerous for me to have passengers. My local Dodge dealership offered to diagnose it, but it's $125.00 for them to just find out what's causing this if they could even do that. Clearly it is an issue of some kind since one door locks. Can you please look into this? Again, I know others have had door lock issues with the Dodge Caravan. Why hasn't this been fixed and recalled already? This is very frustrating. Also, I don't remember the exact date I purchased my vehicle in June, so I've given it my best guess. Thank you for your time in reviewing this. Resolution that fixes this for myself and everyone else who is dealing with this, would be much appreciated.

Vehicle Speed Control; Fuel/Propulsion System

ODI #11373501

Incident: December 10, 2017 · Filed: November 6, 2020

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE AND ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE'S FAILURE BEGAN TO OCCUR WITHIN APPROXIMATELY 2 MINUTES OF STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER (MOUNTAIN VALLEY MOTORS, INC. 7535 APPALACHIAN HWY, BLUE RIDGE, GA 30513; (706) 516-1053) WHO INFORMED THEM THAT THE CHECK VALVE FAILED AND NEEDED TO BE REPLACED, THEREFORE, THE ENTIRE TANK NEEDED TO BE REPLACED DUE TO WHERE THE VALVE WAS LOCATED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE NUMBER. THE MANUFACTURER INFORMED THE CONTACT THAT THEIR VEHICLE WAS NO LONGER COVERED UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

Fuel/Propulsion System

ODI #11309976

Incident: February 18, 2020 · Filed: February 18, 2020

TL* THE CONTACT OWNS A 2005 DODGE CARAVAN. THE CONTACT STATED THAT A SMOG TEST DETECTED A FUEL LEAK FROM THE FUEL TANK. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT THERE WAS A STRONG FUEL ODOR OUTSIDE OF THE VEHICLE PRIOR TO THE SMOG TEST BEING PERFORMED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 148,936.

Unknown or Other

ODI #11286891

Crash 1 injury

Incident: November 22, 2019 · Filed: December 4, 2019

TL* THE CONTACT OWNS A 2005 DODGE CARAVAN. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO STOP. ALSO, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THERE WAS A STRONG ODOR OF FUEL INSIDE THE VEHICLE. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED BRUISING AROUND HER CHEST THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THERE WAS A LEAK FROM THE RADIATOR AND THEY REPLACED THE HOOD. THE CONTACT ALSO MENTIONED THAT HER EMPLOYER OWNED A FLEET OF VEHICLES THAT EXPERIENCED THE SAME FAILURES. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 22,000.

Electrical System

ODI #11192740

Incident: March 30, 2019 · Filed: March 31, 2019

REMOTE RANDOMLY WILL NOT LOCK/ UNLOCK DOORS. PULL THE BATTERY CABLE AND REMOTE WORKS. CHRYSLER SENT OUT TSB 08-040-04 ON SUBJECT. THEY HAVE A GLITCH IN ORIGINAL SOFTWARE AND SEEMS UNFAIR THAT CONSUMER MUST PAY TO HAVE IT FIXED. SLIDING DOORS DO NOT HAVE KEYS TO LOCK SO ONE MUST CRAWL THROUGH THE DRIVER / PASSENGER SEAT TO LOCK MANUALLY. AS AN OLDER ADULT THIS IS A SAFETY HAZARD. IT SHOULD BE RECALLED.

Steering

ODI #11183164

Crash

Incident: January 8, 2019 · Filed: February 28, 2019

TL* THE CONTACT OWNED A 2005 DODGE CARAVAN. WHILE DRIVING 40 MPH, THE STEERING WHEEL SEIZED AND CAUSED THE CONTACT TO CRASH INTO A GUARDRAIL. THERE WERE NO INJURIES. THE AIRS BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY AN INDEPENDENT TOWING COMPANY TO A SALVAGE LOT WHERE IT WAS DEEMED DESTROYED. BLEVINS SEAWAY MOTORS (98 CENTER ST, MASSENA, NY 13662, (315) 764-0283) WAS CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 136,000.

Fuel/Propulsion System

ODI #11173726

Incident: December 15, 2018 · Filed: February 2, 2019

WHEN PUMPING GASOLINE INTO THE TANK, WITHIN A FEW SECONDS THE GASOLINE BACKLOWS AND TURNS OFF THE PUMP. IN ORDER TO GET 5 GALLONS INTO THE TANK IT MAY TAKE 20 STOPS, WAIT & STARTS WHICH MAY TAKE 5 MINUTES. THE CHARCOAL VAPOR TRAP IS WORKING FINE SINCE THE HOSE TO IT FROM THE GASOLINE TANK WAS DISCONNECTED TO TEST THE VAPOR CANISTER. MECHANIC DOES NOT HAVE A CLUE HOW TO RESOLVE THIS PROBLEM. THIS IS AN ONGOING PROBLEM FOR OVER A MONTH AND A HALF.

Air Bags

ODI #11155516

Incident: December 2, 2018 · Filed: December 2, 2018

HAD A RECALL ON THE AIRBAG SENSOR AND HAD IT FIXED 3 OR 4 YEARS AGO. ON 12-2-2018 THE WARNING LIGHT CAME ON, DOING THE SAME PROBLEM. I HAVE NOT AS YET FOUND IF THE SENSOR WAS FIXED WITH ANOTHER BAD ONE. THIS NEEDS LOOKED INTO. TO SEE IF OTHERS HAVE THIS REACURRING SAFTY PROBLEM. COMES ON 10 MINUTES INTO DRIVE,GOES OFF AFTER SITTING 2 MINUTES WITH SWITCH OFF

Tires

ODI #11113459

Incident: June 11, 2018 · Filed: July 24, 2018

TIRE CRACKING AND TREAD SEPARATION ON TOURMAX GFT SOLD BY ELDORADO. ITS NOT IN YOUR LIST. POOR WEAR CHARACTERISTICS. I TOOK MY CAR IN TO AN ALIGNMENT SHOP BECAUSE IT WAS PULLING TOWARD THE CENTER OF THE ROAD. I WAS INFORMED THAT A NEAR NEW TIRE HAD STRESS CRACKS AND TREAD SEPARATION AND THE ALIGNMENT AND INFLATION PRESSURE WAS OK.TWO MORE OF THE SAME TIRES ON THE SAME CAR WERE WEARING UNUSUALLY FAST WITH NO ALIGNMENT ISSUES. I FEEL THESE TIRES HAVE THE POTENTIAL TO BE UNSAFE. THE TOURMAX GFT FROM ELDORADO HAS NOT INSTILLED SAFETY CONFIDENCE.

Other Dodge Caravan model years

Check your 2005 Dodge Caravan VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Caravan at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN