NHTSA vehicle safety data

2005 Coachmen Concord Recalls & Complaints

The 2005 Coachmen Concord has 2 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Coachmen dealer.

NHTSA recall and complaint data for the 2005 Coachmen Concord. Recall data is refreshed daily from NHTSA.

2005 Coachmen Concord owner complaints

Owners have filed 2 complaints with NHTSA about the 2005 Coachmen Concord, describing incidents dated October 15, 2005 to October 9, 2007.

Most-cited components

Service Brakes 1 complaint
Tires 1 complaint

Newest complaints

ODI #10205295 · Filed October 9, 2007
TL*THE CONTACT OWNS A 2005 COACHMEN CONCORD RV. WHILE DRIVING 60MPH, THE PASSENGER SIDE REAR TIRE BLEW OUT. THERE WAS MAJOR DAMAGE TO HIS RV. THE TIRE BLOW OUT TORE OFF SIDE OF THE CAMPER, THE WIRING ON THE FENDER WHEEL AND A GAS PIPE. THE ROAD CONDITIONS WERE NOT A FACTOR. A TOW TRUCK MECHANIC…
ODI #10145853 · Filed December 21, 2005
DT: THE CONTACT STATED THERE WAS A SQUEAKING NOISE COMING FROM THE BRAKES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY FOUND THE ENTIRE BRAKE SYSTEM HAD RUSTED. THE DEALERSHIP REPLACED THE BRAKES. THE MANUFACTURER HAS BEEN CONTACTED, BUT THEY HAVE NOT RESPONDED. THIS IS A 2005 , COACHMEN…

Read all 2 complaints

SHOWER DOOR TOWEL BAR

NHTSA #08V639000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported December 4, 2008 · COACHMEN RV COMPANY, LLC

Potentially affected: 13,662 vehicles

Owners notified February 9, 2009 · Vehicles built June 15, 2001 – August 6, 2007 (per NHTSA)

Defect description

COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.

Safety consequence

GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #08V279000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported June 25, 2008 · COACHMEN RV COMPANY, LLC

Potentially affected: 37,293 vehicles

Owners notified July 30, 2008 · Vehicles built June 1, 2003 – February 28, 2007 (per NHTSA)

Defect description

COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Manufacturer remedy

COACHMEN IS WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COACHMEN AT 574-825-5821.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Coachmen Concord. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2005 Coachmen Concord.

Tires

ODI #10205295

Incident: October 9, 2007 · Filed: October 9, 2007

TL*THE CONTACT OWNS A 2005 COACHMEN CONCORD RV. WHILE DRIVING 60MPH, THE PASSENGER SIDE REAR TIRE BLEW OUT. THERE WAS MAJOR DAMAGE TO HIS RV. THE TIRE BLOW OUT TORE OFF SIDE OF THE CAMPER, THE WIRING ON THE FENDER WHEEL AND A GAS PIPE. THE ROAD CONDITIONS WERE NOT A FACTOR. A TOW TRUCK MECHANIC REPLACED THE TIRE WITH A SPARE. THE TIRE WAS AN ORIGINAL TIRE. THE MILEAGE ON THE TIRE WAS 1850. THERE IS LIMITED VEHICLE INFORMATION ON AN RV. THE TIRE SIZE WAS LT235/85R16. THE TIRE PRESSURE WAS 80. THE DOT NUMBER WAS 7Y9JANA3303. THE CURRENT AND FAILURE MILEAGE OF THE TIRE WAS 1850.

Service Brakes, Hydraulic

ODI #10145853

Incident: October 15, 2005 · Filed: December 21, 2005

DT: THE CONTACT STATED THERE WAS A SQUEAKING NOISE COMING FROM THE BRAKES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY FOUND THE ENTIRE BRAKE SYSTEM HAD RUSTED. THE DEALERSHIP REPLACED THE BRAKES. THE MANUFACTURER HAS BEEN CONTACTED, BUT THEY HAVE NOT RESPONDED. THIS IS A 2005 , COACHMEN CONCORD. *AK

Other Coachmen Concord model years

Check your 2005 Coachmen Concord VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Coachmen Concord at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Coachmen VIN