NHTSA vehicle safety data

2004 Chrysler Sebring Recalls, Ratings & Complaints

The 2004 Chrysler Sebring has 7 NHTSA recall campaigns and 219 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chrysler dealer.

NHTSA recall and complaint data for the 2004 Chrysler Sebring, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Chrysler Sebring owner complaints

Owners have filed 219 complaints with NHTSA about the 2004 Chrysler Sebring, describing incidents dated June 20, 2003 to March 14, 2025.

Most-cited components

Engine 63 complaints
Air Bags 32 complaints
Suspension 26 complaints
Electrical System 23 complaints
Power Train 23 complaints
Vehicle Speed Control 20 complaints

Of the 219 complaints on file, 21 report a crash and 12 a fire; across all 219 complaints, owners report 22 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11648298 · Filed March 14, 2025
Driving on [XXX] in Indiana my rpm’s began to accelerate and I hit my breaks and once I got to 30 mph my breaks went out. I looked online and one after another of complaints for exactly this has been posted in rooms. It was towed to our mechanic and hopefully he can figure out why INFORMATION…
ODI #11527525 · Filed June 17, 2023
Random stalling upon deceleration with no warning lights after stalling (as if the engine thinks it is still running). Occurs at low speed. Sometimes the engine will surge when the rpm drops off instead of stalling. I have almost run into other cars when the surging happens. The stalling occurs…
ODI #11512130 · Filed March 16, 2023
The contact owns a 2004 Chrysler Sebring. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with smoke coming from underneath the hood. Smoke then entered the cabin of the vehicle. No warning light was illuminated. Additionally, the odometer was inoperable…

Read all 219 complaints

Owner-reported

2004 Chrysler Sebring mileage at failure

164 of the 219 complaints on file for the 2004 Chrysler Sebring give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 45,000 miles	Middle half 13,000–80,000 miles	Based on 52 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Sun Visor May Detach During Air Bag Deployment

NHTSA #15V338000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 2, 2015 · Mitsubishi Motors North America, Inc.

Potentially affected: 443,442 vehicles

Repair completion: 3.62% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SR-15-005 (FCA R30) · Owners notified July 20, 2015 · Vehicles built April 17, 2000 – February 21, 2005 (per NHTSA)

Defect description

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2000-2005 Eclipse vehicles manufactured April 5, 1999, to December 17, 2004, 2001-2005 Eclipse Spyder vehicles manufactured January 19, 2000, to March 18, 2005, 2001-2005 Chrysler Sebring vehicles manufactured April 17, 2000, to February 21, 2005, and 2001-2005 Dodge Stratus vehicles manufactured April 17, 2000, to February 22, 2005. In the affected vehicles, the passenger side sun visor may be folded down in such a position that, if the passenger frontal air bag deploys, the passenger side sun visor may detach.

Safety consequence

If the passenger side sun visor detaches and is propelled rearward, there is an increased risk of occupant injury.

Manufacturer remedy

MMNA will notify their owners, and Chrysler will notify the Chrysler and Dodge owners. Dealers will install a tether strap to retain the passenger sun visor, free of charge. The recall began on July 20, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-005. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R30.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

AFTERMARKET BALL JOINTS/SEPARATION

NHTSA #09E056000 · Suspension — Front — Control Arm — Lower Ball Joint · NHTSA notice

Reported October 9, 2009 · QUALIS AUTOMOTIVE LLC

Potentially affected: 5,787 vehicles

Owners notified November 9, 2009

Defect description

QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.

Safety consequence

SEPARATION OF THE BALL STUD FROM THE SOCKET OF THE BALL JOINT HOUSING WOULD ALLOW THE CONTROL ARM TO COLLAPSE AND THE WHEEL TO FOLD IN CAUSING LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

QUALIS AUTOMOTIVE WILL REPLACE THE BALL JOINTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT QUALIS AUTOMOTIVE AT 1-800-493-4128.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET BALL JOINTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY CHRYSLER.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

MASTER CYLINDER LEAK

NHTSA #07E023000 · Service Brakes, Hydraulic — Foundation Components — Master Cylinder · NHTSA notice

Reported March 29, 2007 · CARDONE INDUSTRIES, INC.

Potentially affected: 13,128 vehicles

Owners notified April 2, 2007

Defect description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Safety consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CARDONE MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DAIMLERCHRYSLER/REAR SEAT BELT

NHTSA #04V336000 · Seat Belts — Rear/Other · NHTSA notice

Reported July 8, 2004 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 312 vehicles

Manufacturer campaign D32 · Owners notified July 19, 2004 · Vehicles built June 1, 2004 – June 7, 2004 (per NHTSA)

Defect description

ON CERTAIN CONVERTIBLE MODEL VEHICLES, THE LEFT HAND REAR SEAT BELT RETRACTOR BOLT MAY NOT HAVE BEEN PROPERLY TIGHTENED.

Safety consequence

THIS MAY RESULT IN THE REAR SEAT OCCUPANT BEING IMPROPERLY RESTRAINED IN A CRASH.

Manufacturer remedy

DEALERS WILL TIGHTEN THE LEFT SIDE REAR SEAT BELT RETRACTOR BOLT TO THE PROPER SPECIFICATION. OWNER NOTIFICATION BEGAN ON JULY 19, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. D32.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH 2-DOT (1-888-327-4236).

DAIMLERCHRYSLER/FUEL RETURN LINE HOSE, FUEL PUMP

NHTSA #04V313000 · Fuel System, Gasoline — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported June 29, 2004 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 8,108 vehicles

Owners notified August 9, 2004 · Vehicles built April 16, 2004 – June 20, 2004 (per NHTSA)

Defect description

ON CERTAIN 2-DOOR PASSENGER VEHICLES, THE FUEL RETURN LINE HOSE FITTING ON THE ELECTRIC FUEL PUMP MAY BE IMPROPERLY MOLDED.

Safety consequence

BREAKAGE COULD RESULT IN A LEAKAGE OF FUEL AND IN THE PRESENCE OF AN IGNITION SOURCE, IT COULD RESULT A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL PUMP. THE RECALL WILL BEGIN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DAIMLERCHRYSLER/FUEL RETURN LINE HOSE FITTING

NHTSA #03V443000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported November 4, 2003 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 5,911 vehicles

Manufacturer campaign C38 · Owners notified December 15, 2003 · Vehicles built July 25, 2003 – September 11, 2003 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, THE FUEL RETURN LINE HOSE FITTING ON THE ELECTRIC FUEL PUMP MAY BE RESTRICTED, CAUSING EXCESSIVE FUEL PRESSURE TO BUILD UP IN THE FUEL INJECTION SYSTEM. EXCESSIVE FUEL PRESSURE MAY RESULT IN A LEAK IN THE FUEL RETURN HOSE.

Safety consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE FUEL PUMP PRESSURE. THOSE VEHICLES EXHIBITING HIGHER THAN NORMAL FUEL PUMP PRESSURE WILL RECEIVE FUEL PUMP MODIFICATIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Notes

DAIMLERCHRYSLER RECALL NO. C38.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 Chrysler Sebring Convertible

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 3

Side Crash

Not Rated

Driver: 3, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

2004 Chrysler Sebring 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 3, Passenger: 3

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

2004 Chrysler Sebring 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 3, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

219 owner complaints have been filed with NHTSA for the 2004 Chrysler Sebring.

Service Brakes; Engine; Fuel/Propulsion System

ODI #11648298

Incident: March 14, 2025 · Filed: March 14, 2025

Driving on [XXX] in Indiana my rpm’s began to accelerate and I hit my breaks and once I got to 30 mph my breaks went out. I looked online and one after another of complaints for exactly this has been posted in rooms. It was towed to our mechanic and hopefully he can figure out why INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine

ODI #11527525

Incident: June 17, 2023 · Filed: June 17, 2023

Random stalling upon deceleration with no warning lights after stalling (as if the engine thinks it is still running). Occurs at low speed. Sometimes the engine will surge when the rpm drops off instead of stalling. I have almost run into other cars when the surging happens. The stalling occurs randomly and is becoming more frequent. A scan of the internet shows many others with same issue. No CEL.

Engine

ODI #11512130

Incident: March 16, 2023 · Filed: March 16, 2023

The contact owns a 2004 Chrysler Sebring. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with smoke coming from underneath the hood. Smoke then entered the cabin of the vehicle. No warning light was illuminated. Additionally, the odometer was inoperable. The contact restarted the vehicle; however, the failure recurred. The contact stated that her daughter had asthma; however, the contact and her two children did not receive medical attention. The dealer was made aware of the failure and informed the contact to tow the vehicle to their location. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.

Electrical System

ODI #11507509

Incident: February 2, 2023 · Filed: February 15, 2023

Car will start sometimes and then will not. Replaced 20 amp fuse and it will start. Maybe 10-15 times it will start and then it will not. My wife drives the car and is very concerning to her. Have looked at other complaints on your site about this and no one has had it resolved!!!!

Fuel System, Gasoline

ODI #11464986

Incident: May 12, 2022 · Filed: May 17, 2022

The contact owns a 2004 Chrysler Sebring. The contact stated that while her fiancée was driving approximately 30 MPH, the vehicle seemed as if it was running out of gasoline. The check engine and a fuel warning light were illuminated. The driver pulled over at a service station and became aware of gasoline pouring from the fuel return. The driver parked the vehicle in a nearby parking lot. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 95,000.

Electrical System; Air Bags

ODI #11413631

Incident: April 22, 2021 · Filed: April 24, 2021

AIR BAG LIGHT ON DASH IS ON. MEANING AIR BAG IS NOT OPERATIONAL.

Suspension

ODI #11377440

Incident: November 30, 2020 · Filed: December 2, 2020

DRIVERS SIDE BALL JOINT BROKE WHILE TURNING ONTO HIGHWAY. TIRE SEPARATED FROM CAR AND AXLE SEPARATED FROM TRANSAXLE. APPROXIMATE SPEED LESS THAN 6MPH. NO CONTOL OF CAR AFTER INCIDENT.

Fuel/Propulsion System

ODI #11328482

Fire

Incident: June 8, 2020 · Filed: June 12, 2020

I HEARD A POP THE A LOT OF SMOKE CAME IN THE CAR, I PULLED OVER AND POPPED THE HOOD AND THERE WAS A FIRE BY THE FIREWALL, THE FUEL RLN HAD CAUGHT FIRE. *TR

Suspension

ODI #11271345

Incident: October 24, 2019 · Filed: October 27, 2019

THIS CHRYSLER SEBRING CONVERTIBLE HAD THE LEFT FRONT LOWER BALL JOINT FAIL AND SEPARATE FROM THE LOWER CONTROL ARM WHILE BEING DRIVEN. THIS FAILURE RESULTED IN LOSS OF STEERING CONTROL AT A SPEED OF APPROXIMATELY 30 MILES PER HOUR. THE LOCATION HAPPENED ON SMOOTHLY PAVED SPRING RUN ROAD EXTENSION LOCATED IN PENNSYLVANIA, ALLEGHENY COUNTY,IN MOON TOWNSHIP. THE TIME OF THIS EVENT WAS APPROXIMATELY 6:15 A.M.

Suspension

ODI #11210844

Incident: May 22, 2019 · Filed: May 30, 2019

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. WHILE DRIVING 5 MPH, THE FRONT PASSENGER SIDE BALL JOINT DETACHED FROM THE VEHICLE. THE CONTACT LOST CONTROL OF THE VEHICLE AND THE FRONT PASSENGER TIRE TURNED SIDEWAYS. THE VEHICLE SWERVED ON THE ROAD AND THE CONTACT HAD TO PULL OVER QUICKLY. THE VEHICLE WAS IMMOBILIZED AND WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 109,021.

Other Chrysler Sebring model years

Check your 2004 Chrysler Sebring VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chrysler Sebring at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chrysler VIN