NHTSA vehicle safety data

2007 Chrysler Aspen Recalls, Ratings & Complaints

The 2007 Chrysler Aspen has 3 NHTSA recall campaigns and 129 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chrysler dealer.

NHTSA recall and complaint data for the 2007 Chrysler Aspen, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Chrysler Aspen owner complaints

Owners have filed 129 complaints with NHTSA about the 2007 Chrysler Aspen, describing incidents dated December 24, 2006 to February 21, 2025.

Most-cited components

Fuel/Propulsion System 46 complaints
Air Bags 35 complaints
Electrical System 11 complaints
Unknown or Other 9 complaints
Steering 8 complaints
Suspension 7 complaints

Of the 129 complaints on file, 10 report a crash and 2 a fire; across all 129 complaints, owners report 5 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11645161 · Filed February 26, 2025
When fueling the vehicle as soon as the pump pops off indicating your tank is filled gass will sphew/ or spray back out of the vehicle and onto the person fueling, the side of the vehicle and the ground. This happens every single time no matter what fuel station you use,regardless of the time of day…
ODI #11632737 · Filed December 27, 2024
When filling the gas tank up using the "fill lock" feature on nearly all modern fuel pump nozzles, when the tank gets full the fill nozzle clicks off and about a half a pint of raw fuel is "purged" back out of the tank filler neck. At first I thought this was a problem at a specific fuel station. I…
ODI #11459417 · Filed April 3, 2022
My 07 Chrysler aspen has a huge fuel problem and as I have read it’s happening to a lot of people! When I fill my car up with fuel no matter what store I am at the gas starts spewing back out of the tank. I do not over fill my car the moment the gas pump clicks that it’s done, a lot of gas starts…

Read all 129 complaints

Owner-reported

2007 Chrysler Aspen mileage at failure

94 of the 129 complaints on file for the 2007 Chrysler Aspen give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 60,000 miles	Middle half 50,000–100,000 miles	Based on 38 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2007 Chrysler Aspen in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Do Not Drive - Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V352000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 24, 2016 · Chrysler (FCA US LLC)

Potentially affected: 4,648,270 vehicles

Repair completion: 43.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Chrysler campaign S43 · Owners notified March 27, 2017 · Vehicles built starting February 1, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Chrysler dealer immediately.

Defect description

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Safety consequence

These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Do Not Drive - Driver Side Frontal Air Bag May Rupture

NHTSA #15V313000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 26, 2015 · Chrysler (FCA US LLC)

Potentially affected: 4,077,169 vehicles

Repair completion: 47.11% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Chrysler campaign R25 · Owners notified June 8, 2015 · Vehicles built starting January 1, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Chrysler dealer immediately.

Defect description

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

RIGHT STEERING KNUCKLE

NHTSA #06V386000 · Steering · NHTSA notice

Reported October 11, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 6,644 vehicles

Manufacturer campaign F48 · Owners notified November 8, 2006 · Vehicles built July 24, 2006 – September 1, 2006 (per NHTSA)

Defect description

ON CERTAIN VEHICLES, THE RIGHT FRONT STEERING KNUCKLE MAY HAVE BEEN IMPROPERLY MANUFACTURED. BECAUSE OF A BROKEN COOLING LINE, PARTS CAST IN TOOL CAVITY #63 ON JULY 18 AND JULY 19, 2006, MAY HAVE A COLD SHUT CONDITION AND COULD FRACTURE.

Safety consequence

THIS COULD CAUSE A LOSS OF STEERING CONTROL AND RESULT IN A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT THE RECALLED VEHICLES TO IDENTIFY THE DEFECTIVE PARTS AND REPLACE IF THEY ARE WITHIN THAT LOT. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F48.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2007 Chrysler Aspen 4-Dr. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

19% rollover risk

Safety Technology

Electronic Stability Control

3 investigations

129 owner complaints have been filed with NHTSA for the 2007 Chrysler Aspen.

Fuel/Propulsion System

ODI #11645161

Incident: February 21, 2025 · Filed: February 26, 2025

When fueling the vehicle as soon as the pump pops off indicating your tank is filled gass will sphew/ or spray back out of the vehicle and onto the person fueling, the side of the vehicle and the ground. This happens every single time no matter what fuel station you use,regardless of the time of day or temperature outside. After looking online I can see there have been numerous reports of this from other 2007 Chrysler Aspen owners going back several years; however, I have not been able to locate anything indicating this is a recall and my vin number indicates all recalls have been addressed on this vehicle. Is there a solution for this issue, is it being repaired by Chrysler or what is being done? Please let me know, as this is a safety issue for anyone fueling up , anyone in the vehicle or around the vehicle. I noticed it asks for an approximate date of when this occured, there has been several dates so I will provide the date of the most recent issue.

Fuel/Propulsion System

ODI #11632737

Incident: December 18, 2024 · Filed: December 27, 2024

When filling the gas tank up using the "fill lock" feature on nearly all modern fuel pump nozzles, when the tank gets full the fill nozzle clicks off and about a half a pint of raw fuel is "purged" back out of the tank filler neck. At first I thought this was a problem at a specific fuel station. I have since learned that it can do it anywhere, at any time of day, and at any temperature.

Fuel/Propulsion System

ODI #11459417

Incident: April 3, 2022 · Filed: April 3, 2022

My 07 Chrysler aspen has a huge fuel problem and as I have read it’s happening to a lot of people! When I fill my car up with fuel no matter what store I am at the gas starts spewing back out of the tank. I do not over fill my car the moment the gas pump clicks that it’s done, a lot of gas starts spewing out onto the ground! I believe this is a potential hazardous ? situation for all involved especially my family! For one I am stressed out about if there were to be an accidental rollover the gas would go everywhere, and 2 when it pours out onto the ground or could even splash out onto my skin I could end up with chemical burns or the bio hazard issue we are having with the gas just being powered onto the ground without me being able to control it! Chrysler doesn’t seem to think this is a problem or that it’s hazardous! But when people go to have the problem fixed they are telling everyone it’s a faulty gas tank and you have to replace the entire tank!! Please help us get our cars fixed for something that Chrysler messed up on they should be responsible for the repairs!!

Suspension; Electrical System; Unknown or Other

ODI #11373649

Incident: June 1, 2020 · Filed: November 8, 2020

SUSPENSION: EVERY TIME YOU HIT A BUMP OR POT HOLE THE VEHICLE THROWS YOU ACROSS THE LANE. FUEL TANK: EVERY TIME YOU FILL THE GAS TANK UP AND WHEN THE PUMP CLICKS OFF THE GAS SPITS OUT OF THE TANK AND LANDS ALL OVER YOU AND THE VEHICLE. ELECTRICAL: THE DASHBOARD WILL LIGHT UP WITH THE OIL SYMBOL FLASHING ON AND OFF. AIR CONDITIONING: THE COMPRESSOR BLOWS HOT AIR AND NOW THE ENGINE SPEEDS UP LIKE IT'S GOING TO EXPLODE.

Engine

ODI #11363635

Incident: August 10, 2020 · Filed: October 9, 2020

AFTER FILLING UP THE GAS TANK THE VEHICLE SHUTS OFF WHILE DRIVING CAUSING IT TO LOSE BRAKING AND POWER STEERING. THE VEHICLE ALSO SHUTS OFF WHILE AT A STAND STILL. THIS ONLY HAPPENS AFTER FILLING UP THE GAS TANK AND SEEMED TO BE CAUSED BY A FAULTY FUEL TANK ROLLOVER VALVE THAT IS BUILT INTO THE GAS TANK SO IT CANT BE CHANGED. THE WHOLE FUEL TANK HAS TO BE CHANGED AND THE FUEL TANK IS NO LONGER AVAILABLE ANYWHERE. I'M FORCED TO DRIVE A TICKING TIME BOMB BECAUSE THERE IS NO WAY TO FIX THIS PROBLEM THAT SHOULD BE A RECALL.

Seat Belts

ODI #11361377

Incident: September 27, 2020 · Filed: September 27, 2020

A WARNING INDICATER WILL SOUND SOMETIMES WHEN THE DRIVER SIDE SEATBELT WHEN HAS BEEN LOCKES INTO PLACE (FASTENED). I HAVE TO LOCK AND UNLOCK THE SEATBELT TO SHUTDOWN THE INDICATER. ALSO THE PASSANGER SEATBELT WILL NOT RELEASE ONCE LOCKED, HOWEVER IT TAKES SEVERAL MINUETS TO GET IT TO RELEASE.

Electrical System; Air Bags; Electronic Stability Control (ESC)

ODI #11353386

Incident: September 3, 2020 · Filed: September 6, 2020

THE AIRBAG LIGHT KEEPS COMING ON AND THERE'S NOTHING GOING ON WITH MY CAR IGNITION MESSED UP MY ALTERNATOR BATTERY AND STARTER. THERE'S A FAILURE IN IGNITION THAT IS MESSING UP A LOT OF THINGS IN THE CAR. THE IGNITION HAD ME IN THE MIDDLE OF THE ROAD SUCH AS SAFETY ISSUE. WHEN I USE MY FOUR-WHEEL-DRIVE A LOT OF COMPLICATIONS STARTED HAPPENING WITH MY LYCIAN ALTERNATOR STARTER AND BATTERY

Suspension; Unknown or Other

ODI #11340034

Incident: June 2, 2020 · Filed: July 17, 2020

THE STEERING JERKS AND CAR SHIFTS WHEN I HIT A POT HOLE OF BUMP IN THE ROAD ON MY 2007 CHRYSLER ASPEN AND IT HAS ALMOST CAUSED US TO LOSS CONTROL OF THE VEHICLE A FEW TIMES, YOU NEVER KNOW WHEN IT'S GOING TO HAPPEN OR I WOULD DODGE THE HOLE. VERY SCARY WHEN IT DOES HAPPEN. WE HAVE HAD THE FRONT END CHECKED AND THEN TELL US THERE'S NO PROBLEM. IT DOESN'T HAPPEN UNLESS YOUR DRIVING OVER 40 MPH AND WHEN YOUR DRIVING 65 ON THE HIGHWAY, IT'S GOING TO GET SOMEONE KILLED ONE DAY. THERE'S NOT A SPECIFIC DAY, SINCE IT HAPPENS EVERY TIME YOU DRIVE IT AND HIT A HOLE OR BUMP IN THE ROAD. WE HAVE OWNED IT SINCE IT WAS NEW AND ALWAYS HAD THE PROBLEM. WE ARE ALSO HAVING A PROBLEM WITH THE AIR CONDITIONING, WE HAVE INSTALLED 3 COMPRESSES, DRYERS IT WILL NOT COOL THIS LAST TIME IT WAS IN THE SHOP 8 DAYS. THEY MUST HAVE INSTALLED AND REMOVED EVERY PART THAT WOULD CAUSE IT NOT TO COOL, STILL BLOWS HOT AIR AND IT'S ALREADY 95+ DEGREES OUTSIDE. MY ELDERLY MOTHER DRIVES THIS ASPEN AND IT USE TO BE A GREAT CAR, BUT ONCE THEY BREAK YOU MIGHT AS WELL BUY SOMETHING NEW. IT'S NO WONDER THEY ONLY MAKE THE ASPEN 3 YEARS. WORST AND MOST DANGEROUS VEHICLE EVER.

Fuel/Propulsion System

ODI #11337455

Incident: December 19, 2019 · Filed: July 4, 2020

MY VEHICLE WAS STATIONED AT A GAS STATION PUMP AS I WAS PUMPING FUEL AND I WANTED TO FILL UP THE TANK, AND SO I DID. BUT, RIGHT BEFORE THE PUMP STOPPED, THE GAS SPIT AND SPILLED OUT OF THE TANK, RAN DOWN THE SIDE OF MY VEHICLE AND ON TO THE FLOOR.

Fuel/Propulsion System

ODI #11323595

Incident: May 6, 2020 · Filed: May 6, 2020

WHEN PUTTING GAS IN AFTER REMOVING THE PUMP GAS COMES SPRAYING OUT ALL OVER WHOEVER IS FILLING UP THE VEHICLE ON THE SIDE OF MY VEHICLE AND ON THE GROUND THIS IS A SAFELY ISSUE FOR EVERYONE IN THE CAR THE VEHICLE ITSELF AND HOWEVER IS FILLING THE CAR UP AS WELL AS THE GAS STATION THAT YOU ARE FILLING UP AT. IT HAPPENED TODAY AND 1 TIME BEFORE THAT I HAVE HAD THE VEHICLE LESS THEN A MONTH BUT SEE ITS A COMMON ISSUE AND SPOKEN ABOUT ALOT ONLINE. *TR

Other Chrysler Aspen model years

Check your 2007 Chrysler Aspen VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chrysler Aspen at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chrysler VIN