NHTSA vehicle safety data

2005 Chevrolet Uplander Recalls, Ratings & Complaints

The 2005 Chevrolet Uplander has 4 NHTSA recall campaigns and 196 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2005 Chevrolet Uplander, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Chevrolet Uplander owner complaints

Owners have filed 196 complaints with NHTSA about the 2005 Chevrolet Uplander, describing incidents dated December 23, 2004 to February 1, 2022.

Most-cited components

Electrical System 57 complaints
Latches/Locks/Linkages 45 complaints
Structure 45 complaints
Service Brakes 15 complaints
Engine 13 complaints
Exterior Lighting 13 complaints

Of the 196 complaints on file, 7 report a crash and 1 a fire; across all 196 complaints, owners report 31 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11506560 · Filed February 10, 2023
The contact owns a 2005 Chevrolet Uplander. The contact stated that while driving at undisclosed speeds, the vehicle was drifting and would not drive in a straight line. The vehicle was taken to the local mechanic who performed a wheel alignment and changed the tires, but the failure persisted. The…
ODI #11287856 · Filed December 9, 2019
MY VAN HESITATES BETWEEN 2 AND 3 RPM'S. ESPECIALLY GOING UP A HILL, THE ENGINE LIGHT WILL BLINK FOR A FEW SECONDS. THEN ENGINE LIGHT CONTINUES TO STAY ON..THE DRIVERS SIDE DOOR IS MALFUNCTIONING.. WHEEL BEARING IN THE REAR NEED REPLACEMENT.. AND THERE DOES APPEAR TO BE AN ELECTRICAL ISSUE.. RADIO…
ODI #11217694 · Filed June 4, 2019
THE DRIVER SIDE SEAT BELT DOES NOT BUCKLE INTO THE LATCH. THERE'S A METAL PIECE INSIDE THE LATCH BLOCKING IT FROM SLIDING IN AND SNAPPING IN. THIS STARTED HAPPENING A FEW DAYS AGO, PREVENTING ME FROM DRIVING THE VAN SINCE I CAN'T USE MY SEAT BELT.

Read all 196 complaints

Owner-reported

2005 Chevrolet Uplander mileage at failure

158 of the 196 complaints on file for the 2005 Chevrolet Uplander give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 45,000 miles	Middle half 12,000–100,000 miles	Based on 45 complaints
Latches/Locks/Linkages	Median 25,000 miles	Middle half 7,000–50,000 miles	Based on 37 complaints
Structure	Median 50,000 miles	Middle half 20,000–95,000 miles	Based on 35 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Chevrolet Uplander in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA07-019: POWER SLIDING DOOR
Closed February 23, 2009
Preliminary Evaluation PE07-044: POWER SLIDING DOOR OPENING
Closed December 11, 2007
Preliminary Evaluation PE05-063: ELECTRICAL HARNESS DAMAGE
Closed March 6, 2006

Open and recently closed NHTSA defect investigations

REAR SUSPENSION TRAILING ARM

NHTSA #10V110000 · Suspension — Rear · NHTSA notice

Reported March 19, 2010 · BRAUN CORPORATION

Potentially affected: 5,375 vehicles

Owners notified June 4, 2010 · Vehicles built July 1, 2004 – May 7, 2008 (per NHTSA)

Defect description

THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

Safety consequence

A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STEERING KNUCKLE BREAKING/LOSS OF STEERING CONTROL

NHTSA #09E005000 · Steering · NHTSA notice

Reported February 17, 2009 · DORMAN PRODUCTS, INC.

Potentially affected: 979 vehicles

Owners notified February 23, 2009

Defect description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Safety consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

PARKING BRAKE LEVER SLIP/FMVSS 135

NHTSA #05V287000 · Parking Brake · NHTSA notice

Reported June 20, 2005 · GENERAL MOTORS CORP.

Potentially affected: 14,600 vehicles

Manufacturer campaign 05059 · Owners notified November 14, 2005 · Vehicles built February 1, 2005 – March 31, 2005 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.

Safety consequence

WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.

Notes

GM RECALL NO. 05059. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REAR SEAT LATCHES

NHTSA #05V061000 · Seats — Mid/Rear Assembly · NHTSA notice

Reported February 18, 2005 · GENERAL MOTORS CORP.

Potentially affected: 18,850 vehicles

Manufacturer campaign 05015 · Owners notified April 5, 2005 · Vehicles built June 1, 2004 – January 31, 2005 (per NHTSA)

Defect description

ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.

Safety consequence

IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.

Manufacturer remedy

DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.

Notes

GM RECALL NO. 05015.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Chevrolet Uplander (Early Release)

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

2005 Chevrolet Uplander (Later Release)

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

196 owner complaints have been filed with NHTSA for the 2005 Chevrolet Uplander.

Wheels

ODI #11506560

Incident: February 1, 2022 · Filed: February 10, 2023

The contact owns a 2005 Chevrolet Uplander. The contact stated that while driving at undisclosed speeds, the vehicle was drifting and would not drive in a straight line. The vehicle was taken to the local mechanic who performed a wheel alignment and changed the tires, but the failure persisted. The mechanic later diagnosed that the surface of all four alloy wheels had begun to deteriorate and was out of round. The contact was advised not to drive the vehicle until the wheels were replaced. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The failure mileage was 80,000.

Exterior Lighting; Wheels; Engine

ODI #11287856

Incident: August 24, 2019 · Filed: December 9, 2019

MY VAN HESITATES BETWEEN 2 AND 3 RPM'S. ESPECIALLY GOING UP A HILL, THE ENGINE LIGHT WILL BLINK FOR A FEW SECONDS. THEN ENGINE LIGHT CONTINUES TO STAY ON..THE DRIVERS SIDE DOOR IS MALFUNCTIONING.. WHEEL BEARING IN THE REAR NEED REPLACEMENT.. AND THERE DOES APPEAR TO BE AN ELECTRICAL ISSUE.. RADIO SKIPS, INTERIOR LIGHTS DON'T WORK AT ALL.. THE DRIVERS SIDE SEAT DOESN'T HEAT. THERES BARELY ANY HEAT EVEN WHEN GAUGE READS THE ENGINE IS NORMALLY WARM..

Seat Belts

ODI #11217694

Incident: June 2, 2019 · Filed: June 4, 2019

THE DRIVER SIDE SEAT BELT DOES NOT BUCKLE INTO THE LATCH. THERE'S A METAL PIECE INSIDE THE LATCH BLOCKING IT FROM SLIDING IN AND SNAPPING IN. THIS STARTED HAPPENING A FEW DAYS AGO, PREVENTING ME FROM DRIVING THE VAN SINCE I CAN'T USE MY SEAT BELT.

Suspension; Structure

ODI #11184428

Incident: February 23, 2019 · Filed: March 5, 2019

WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WENT OUT AT 75MPH.

Electrical System

ODI #11152217

Incident: November 5, 2018 · Filed: November 17, 2018

DRIVING THE VEHICLE ALONG THE INTERSTATE AT 65 MPH AT NIGHT, THE IGNITION SWITCH RUN POSITION ROTATED TO OFF AND THE ENGINE AND ALL HEADLIGHTS, DASH, ETC, SHUTDOWN ALONG WITH THE POWER STEERING AND POWER BRAKES. THE INCIDENT HAS JUST STARTED HAPPENING AND 340,000 MILES ON IT. ONLY WAY TO GET ROLLING IS TO PUT THE AUTO TRANS LEVER TO NEUTRAL AND TWIST THE IGNITION KEY TO CRANK POSITION AND LET KEY SETTLE TO RUN POSITION. THE IGNITION SWITCH ITSELF HAS A SPRING DETENT AND IT SETS IN A POCKET AT RUN. SO THIS SWITCH HAS A SPRING THAT OVER TIME WEAKENS AND ALLOWS THE WHOLE KEY CYLINDER ANS SWITCH TO DROP OUT OF RUN AND SHUT OFF THE ELECTRICAL. SOLUTION WAS TO PUT IN A NEW SWITCH OR JUST USE A SINGLE KEY INSTEAD OF A FULL SET OF KEYS HANGING FROM THE KEY SLOT.. THE FULL REPLACEMENT OF THE SWITCH RUNS 350$, PRTS AND LABOR.

Visibility/Wiper

ODI #11149827

Incident: June 1, 2018 · Filed: November 7, 2018

I WAS HEARING ABOUT THE RECENT RECALL ACTIONS ABOUT CHEVY SUVS WITH WIPER BLADES. BUT, I HAVE HAD AN ISSUE WHERE MY WIPER WOULD STOP IN THE MIDDLE OF THE WINDSHIELD. MY VEHICLE WAS NOT IN THE RECALL, BUT, JUST MADE ME THINK, AND I WANTED TO SHARE. I PURCHASED A NEW ARM FROM GM AT MY LOCAL DEALER IN AUGUST OF 2018. SO, I THINK THAT I AM OK.

Structure

ODI #11118086

Incident: August 6, 2018 · Filed: August 6, 2018

THE BACK REAR HATCH WHEN I LIFTED DROPPED! I GOT MY HANDS UP FAST ENOUGH TO STOP IT AND WAS NOT INJURED THOUGH

Structure; Wheels; Electronic Stability Control (ESC)

ODI #11093431

2 injuries

Incident: July 1, 2017 · Filed: May 11, 2018

THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR QUIET A WHILE NOW.

Suspension; Structure

ODI #11080389

Incident: February 8, 2018 · Filed: March 20, 2018

2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACED NOR WELDED AS THIS CAN BE UNSAFE TO DRIVE. I HAVE IMAGES THAT CAN BE SENT VIA EMAIL.

Electrical System

ODI #11058184

Incident: November 16, 2017 · Filed: January 3, 2018

MY ELECTRICAL WILL GO OUT AS I AM DRIVING. THE CAR HAS STOPPED COMPLETELY AND THE ELECTRICAL AS I WAS DRIVING. MY CAR WILL TURN ON AND THEN OFF, AND I HAVE TO DO IT ABOUT 5 TIMES BEFORE I CAN EVEN GET IT TO STAY ON AND DRIVE. SOMETIMES THE ELECTRICAL WILL STOP AFTER THAT BUT I CAN STILL DRIVE. THIS IS NOT SAFE. IT HAS BEEN GOING ON FOR SOME TIME.

Other Chevrolet Uplander model years

Check your 2005 Chevrolet Uplander VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Uplander at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN