NHTSA vehicle safety data

2004 Chevrolet Tahoe Recalls, Ratings & Complaints

The 2004 Chevrolet Tahoe has 5 NHTSA recall campaigns and 466 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2004 Chevrolet Tahoe, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Chevrolet Tahoe owner complaints

Owners have filed 466 complaints with NHTSA about the 2004 Chevrolet Tahoe, describing incidents dated September 15, 2003 to September 1, 2026.

Most-cited components

Electrical System 214 complaints
Service Brakes 84 complaints
Engine 46 complaints
Steering 29 complaints
Vehicle Speed Control 27 complaints
Power Train 26 complaints

Of the 466 complaints on file, 24 report a crash and 7 a fire; across all 466 complaints, owners report 21 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11764617 · Filed September 16, 2026
My brakes locked up with steering wheel and cause me to go off the road it’s very unsafe and there should be recall immediately
ODI #11676048 · Filed July 24, 2025
UNKNOWN
ODI #11534962 · Filed July 28, 2023
My Tahoe has the New Process 246GM transfer case. They have a known issue called pump rub where the pump is to close to the magnesium shell, and rubs pin holes in the shell which causes fluid to dissipate over time causing the transfer case to run dry burning it up. I've had a mechanic check it out…

Read all 466 complaints

Owner-reported

2004 Chevrolet Tahoe mileage at failure

385 of the 466 complaints on file for the 2004 Chevrolet Tahoe give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 70,000 miles	Middle half 45,000–85,000 miles	Based on 178 complaints
Service Brakes	Median 105,000 miles	Middle half 65,000–140,000 miles	Based on 78 complaints
Engine	Median 95,000 miles	Middle half 60,000–125,000 miles	Based on 41 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Most complaints NHTSA received since May 17, 2021 give no mileage. So that they aren't undercounted, each one received since then that gives a mileage also stands in for those that gave none, which can put a component's median above most of the mileages it is based on.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

REPLACEMENT WHEEL HUB ASSEMBLIES

NHTSA #07E106000 · Wheels — Hub · NHTSA notice

Reported December 17, 2007 · FEDERAL-MOGUL CORPORATION

Potentially affected: 130,000 vehicles

Owners notified February 7, 2008

Defect description

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Safety consequence

WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SEAT BELT ROUTING

NHTSA #05V163000 · Seat Belts — Rear/Other · NHTSA notice

Reported April 22, 2005 · GENERAL MOTORS CORP.

Potentially affected: 1,359,824 vehicles

Manufacturer campaign 05037 · Owners notified July 21, 2005 · Vehicles built April 8, 2003 – August 4, 2004 (per NHTSA)

Defect description

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.

Safety consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Manufacturer remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.

Notes

GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 135/BRAKE VALVE

NHTSA #04V045000 · Service Brakes, Hydraulic · NHTSA notice

Reported February 4, 2004 · GENERAL MOTORS CORP.

Potentially affected: 68,875 vehicles

Manufacturer campaign 04004 · Owners notified June 18, 2004 · Vehicles built May 1, 2003 – June 30, 2003 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Safety consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Manufacturer remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Notes

GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 Chevrolet Tahoe 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

26% rollover risk

Safety Technology

466 owner complaints have been filed with NHTSA for the 2004 Chevrolet Tahoe.

Steering; Electrical System; Service Brakes

ODI #11764617

Incident: September 1, 2026 · Filed: September 16, 2026

My brakes locked up with steering wheel and cause me to go off the road it’s very unsafe and there should be recall immediately

Seat Belts

ODI #11676048

Incident: April 22, 2005 · Filed: July 24, 2025

UNKNOWN

Power Train

ODI #11534962

Incident: July 15, 2023 · Filed: July 28, 2023

My Tahoe has the New Process 246GM transfer case. They have a known issue called pump rub where the pump is to close to the magnesium shell, and rubs pin holes in the shell which causes fluid to dissipate over time causing the transfer case to run dry burning it up. I've had a mechanic check it out and there was no fluid in the case, and now I have a transfer case that's burned up. I've called a transmission shop, and they told me it was a common issue. I would like for general motors to correct this issue

Service Brakes, Hydraulic

ODI #11518661

Incident: March 23, 2023 · Filed: April 24, 2023

The contact's spouse owns a 2004 Chevrolet Tahoe. The contact stated while driving approximately 35 MPH, the brake pedal was depressed and remained extended to the floorboard. The contact engaged the parking brake to bring the vehicle to a complete stop. The vehicle was driven to the residence and parked. Additionally, the contact stated that while parked, the brake pedal was depressed, and brake fluid was squirting onto the ground from underneath the front of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 190,000.

Service Brakes, Hydraulic

ODI #11482582

Incident: September 2, 2022 · Filed: September 2, 2022

The contact owns a 2004 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the brakes failed to stop the vehicle immediately while the brake pedal was being depressed. The vehicle was taken to the dealer where it was diagnosed that the failure was related to NHTSA Campaign Number: 04V045000 (Service Brakes, Hydraulic) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 150,000.

Service Brakes, Hydraulic

ODI #11459100

Incident: March 28, 2022 · Filed: March 31, 2022

The contact owns a 2004 Chevrolet Tahoe. The contact stated that while inspecting the coils under the hood, he noticed that the master cylinder brake lines were leaking. The vehicle was taken to an independent mechanic who diagnosed that the master cylinder brake lines needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 183,500. The VIN was unavailable.

Unknown or Other; Engine

ODI #11341775

Incident: July 28, 2020 · Filed: July 28, 2020

MY2004 CHEVY TAHOE LT WAS MOVING WHEN THE REAR VIEW MIRROR FELL OFF THE WINDSHIELD. ALSO THE EXHAUST MANIFOLD BOLTS HAVE BROKEN OFF WHICH CAUSE BAD GAS MILEAGE AND SLOW TAKE OFFS.

Steering; Vehicle Speed Control; Service Brakes

ODI #11327461

Incident: August 19, 2019 · Filed: June 5, 2020

THIS IS IN REFERENCE TO COMPLAINT # 11327456 THE ADDRESS AND THE MPH ARE INCORRECT. PLEASE SEE FORM ATTACHED TO THIS COMPLAINT # AFFECTED PARTS: STEERING, BRAKES, ELECTRICAL, ELEC, STABILITY CONTROL AND SPEED CONTROL THIS SITE WOULDN'T LET ME CHECK MORE THAN 3. *TR

Steering; Electrical System; Service Brakes

ODI #11327456

Incident: August 19, 2019 · Filed: June 5, 2020

THERE IS A RECALL #04004. "BRAKE HYDRO-BOOST RELIEF VALVE" BUT MY VIN# IS NOT ON THE LIST. OVER 64,000 VEHICLES WERE AFFECTED AND THERE IS A "#1" ON THE MOUNTING SURFACE. ALL OF THE UNITS DETECTED A MACHINING ERROR IN THE RELIEF BORE CAVITY FOR MODULES PRODUCED FROM A MACHINE IDENTIFIED AS "FADAL #1" THIS CAN AND HAS CAUSED MY 2004 CHEVROLET TAHOE TO HAVE NO POWER ASSIST WITH MY STEERING AND NO POWER BRAKES. I HAVE FOUND MYSELF HOLDING TWO FEET ON THE BRAKE PEDAL AT A RED LIGHT. AND CAN NOT OPERATE IN SMALL SPACES SUCH AS PARKING GARAGES AND CERTAIN PARKING STALLS. I WANTED TO KNOW IF THERE IS SOMETHING MORE THAT I CAN DO IN REGARDS TO THIS PARTICULAR RECALL AND FIND OUT IF THERE IS SOME MISTAKE AS FAR AS MY VIN# NOT BEING RECOGNIZED BUT YET EXPERIENCING THE SAME PROBLEMS. MY VEHICLE HAS BECOME INOPERABLE FOR THAT IT IS UNSAFE TO DRIVE WITH THE NO POWER ASSIST AND COULD CAUSE A MAJOR ACCIDENT...I WANT TO SEE ABOUT RECEIVING SOME AID IN ALL THIS. THIS HAS BEEN A ISSUE SINCE AUGUST OF 2019. IT HAS CAUSED ME TO LOSE WORK FOR A LACK OF TRANSPORTATION. MY CREDIT HAS FALLEN BEHIND BECAUSE OF NOT BEING ABLE TO MAKE IT TO WORK AND SPENDING MY SAVINGS ON TRYING TO GUESS AT WHAT IS WRONG WITH IT. FOR IT IS MY ONLY VEHICLE. NOW THAT THE COVID-19 IS HERE IS A DOUBLE WHAMY! IN DIRE STRAITS - CALI LOVIN MY 4X4 - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Service Brakes

ODI #11319447

Crash

Incident: March 18, 2020 · Filed: March 27, 2020

BRAKES NOT WORKING WHEN PRESSED CAUSED AN ACCIDENT

Other Chevrolet Tahoe model years

Check your 2004 Chevrolet Tahoe VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Tahoe at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN