2020 Buick Encore Recalls, Ratings & Complaints

Incident: May 25, 2026 · Filed: June 25, 2026

The contact owns a 2020 Buick Encore. The contact stated that while driving at an undisclosed speed, the brake pedal and accelerator pedal became extremely hot to the touch. The contact became aware that the silver heat shield was missing. Additionally, the contact stated that there was electrical activity or electricity coming from the area. No warning lights were illuminated. The vehicle was taken to a local dealer; however, the dealer was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 77,213.

Incident: April 13, 2026 · Filed: April 28, 2026

I took my 2020 Buick Encore to an independent auto repair shop to have a brake inspection after I had contacted GM multiple times about the loss of acceleration, check engine light and stabilitrak light would come on with brake pedal stiffness and then almost needing to push it to the floor to stop. When I took it to the independent auto repair shop for the brake inspection they informed me of a PO161 code recall so I contacted my local recall service center, only to get a phone call from one of their salesman to come in and see about getting a new car. I've had other issues with this car since buying it in September of 2022 but now it's a serious safety situation and all they can either say is it doesn't match my vin so I'll have to pay out of pocket or go in debt for a new one. I don't know what to do at this point I feel at a loss.

Incident: February 20, 2026 · Filed: February 25, 2026

Defective "TURBO CHARGER" at 38,091 miles. The defective worn-out or damaged turbocharger was removed from the engine and a new one was installed at a cost of $1816.00. This part should not wear out at 38,000 miles. My mechanic informed me that this is common in the Buick Encore vehicles to experience a defective "TURBO CHARGER" at low vehicle mileage.

Incident: August 1, 2025 · Filed: October 3, 2025

I've been dealing with a frustrating car issue lately where my vehicle keeps stalling and hesitating during acceleration - whether I'm pulling away from a stop or trying to pick up speed on the road. After getting it checked out, my mechanic determined that the high pressure fuel pump control module is the culprit and needs replacement. The problem is, we're stuck waiting for the part because Buick has it on backorder indefinitely. What's particularly concerning is that GM recently issued a recall for this exact same fuel pump issue on certain models, but somehow my VIN number didn't make the cut. I strongly believe it should have been included, especially considering the safety implications here. When this fuel pump control module fails, it can completely cut off fuel flow to the engine, which creates a serious traffic safety hazard. Nobody wants their car suddenly losing power while merging onto a highway or navigating through an intersection. This isn't just an inconvenience - it's a legitimate safety concern that affects real people on real roads every day.

Incident: May 11, 2025 · Filed: May 11, 2025

I am co-owner of the vehicle. My daughter was driving the SUV when the Check engine light came on. There was no warning whatsoever, and the turbocharger has gone bad . Prior to the light eliminating there was nothing wrong with the suv. I was driving the suv when the check engine light came on. I also own another 2020 Buick encore where this also happened. I was driving the vehicle when the check engine light came on with no prior warning and it was a failed turbocharger. There is something wrong with these vehicles .

Incident: April 24, 2025 · Filed: April 25, 2025

On 4/24/25 I noticed a pungent odor (like rotten eggs). The odor is worse today. I did research and it appears there may be a problem and or leak with the catalytic converter. The emissions are making me and my kids feel sick, nauseous, headache, irritated eyes, etc.

Incident: January 20, 2025 · Filed: January 24, 2025

Unknown issues w/ sensors and wiring lead to turbocharger failure. This led to spontaneous acceleration issues on the highway. Less than a year after the warranty covered the replacement of the turbocharger (less than 60k miles on the car) the turbocharger again failed (64k miles on car).

Incident: February 13, 2024 · Filed: May 29, 2024

The contact owns a 2020 Buick Encore. The contact stated while driving at an undisclosed speed, the contact heard an abnormal sound coming from the vehicle. The contact was able to veer over to the shoulder and discovered that the sunroof had exploded. The vehicle was taken to a dealer and the contact was advised to report the failure to the NHTSA Hotline. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

Incident: April 5, 2024 · Filed: May 10, 2024

Imthe original owner and purchased the car new 4 years ago. At 89,000 miles, the check engine light came on indicating codes for emission controls not working efficiently. Later additional codes indicated problems with the fuel evaporator. The car started having problems every time I filled up the gas tank it would stall, hesitate and have problems starting shortly after the fill up. Problem also occurred if I let the fuel level run down to 1 gallon when the reserve indicator light came on the fuel tank. So now I fill up when I reach a quarter tank. Steady driving for at least 10 minutes would clear the problem temporarily. Car hesitates, stalls and misfires when going uphill, steep hills and also when coming to full stop Such as a red light. Later additional problem of car hesitating and misfiring during acceleration. I have replaced the spark plugs and ignition coil. No change noticed. Awaiting mechanic diagnosis. This problem seems very similar to another complaint filed under NHTSA ID 11548946 in October 2023

Incident: April 2, 2024 · Filed: April 23, 2024

Engine light is on and vehicle is sluggish on hills and keeping up in traffic. Rpms run high if I try. Error code p0299 shows on scanning device- turbo under boost. I have 112,000 miles and need turbo replaced already. this vehicle is very well maintained. I did see a special notice for the GX version of this vehicle. But dealer says my vin does not qualify