NHTSA vehicle safety data

2009 BMW R1200 R Recalls & Complaints

The 2009 BMW R1200 R has 4 NHTSA recall campaigns and 5 owner complaints on file as of October 21, 2026. Recall repairs are usually free at an authorized BMW dealer.

Includes campaigns NHTSA files under the spelling "R 1200 R".

NHTSA recall and complaint data for the 2009 BMW R1200 R. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2009 BMW R1200 R owner complaints

Owners have filed 5 complaints with NHTSA about the 2009 BMW R1200 R, describing incidents dated April 25, 2012 to July 28, 2024.

Most-cited components

Fuel/Propulsion System 4 complaints
Electrical System 1 complaint
Fuel System, Gasoline 1 complaint
Unknown or Other 1 complaint

Newest complaints

ODI #11621778 · Filed October 24, 2024
Fuel gauge stopped responding, leading to running out of fuel while moving. This is a common failure on many bike models from BMW from 2005-2013. I have had this happen 4 times so far, and each time the fuel level measuring strip in the fuel tank was replaced. This repair is costly, and has proven…
ODI #11433912 · Filed September 21, 2021
The fuel strip located inside the tank which sends an electronic signal to the dash gauge indicating the amount of fuel available until the low fuel warning light comes on malfunctions and eventually fails. The vehicle is available for inspection upon request. On three separate occasions (two on 55…
ODI #11267107 · Filed October 8, 2019
FUEL PUMP OUTPUT FLANGE CRACKED, RESULTING IN FUEL LEAKING DOWN THE SIDE OF THE BIKE AND ONTO HOT COMPONENTS WHILE RIDING. THIS ISSUE HAS ALREADY BEEN THE SUBJECT OF A BMW RECALL - BUT APPARENTLY THE "INSPECT AND REINFORCE" SOLUTION ISN'T REALLY ADEQUATE LONG-TERM. THIS PUMP HAD BEEN "INSPECTED AND…

Read all 5 complaints

Fuel Pump Flange may Leak

NHTSA #20V471000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 10, 2020 · BMW of North America, LLC

Potentially affected: 16,926 vehicles

Repair completion: 58.36% (latest rate the manufacturer reported to NHTSA; dataset updated October 21, 2026)

Owners notified January 18, 2021

Defect description

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Safety consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel Mounting Flange may Crack

NHTSA #15V141000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 11, 2015 · BMW of North America, LLC

Potentially affected: 43,426 vehicles

Repair completion: 60.91% (latest rate the manufacturer reported to NHTSA; dataset updated October 21, 2026)

Owners notified May 7, 2015 · Vehicles built August 30, 2006 – February 9, 2010 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Safety consequence

If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel Pump Flange may Leak

NHTSA #13V617000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported December 12, 2013 · BMW of North America, LLC

Potentially affected: 50,184 vehicles

Repair completion: 59.33% (latest rate the manufacturer reported to NHTSA; dataset updated October 21, 2026)

Owners notified April 16, 2014 · Vehicles built August 30, 2006 – April 11, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Safety consequence

A fuel leak in the presence of an ignition source may result in a fire.

Manufacturer remedy

BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FRONT BRAKE LINES

NHTSA #10V276000 · Service Brakes, Hydraulic · NHTSA notice

Reported June 18, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 15,532 vehicles

Owners notified September 20, 2010

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Safety consequence

IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2009 BMW R1200 R. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

5 owner complaints have been filed with NHTSA for the 2009 BMW R1200 R.

Fuel/Propulsion System

ODI #11621778

Incident: July 28, 2024 · Filed: October 24, 2024

Fuel gauge stopped responding, leading to running out of fuel while moving. This is a common failure on many bike models from BMW from 2005-2013. I have had this happen 4 times so far, and each time the fuel level measuring strip in the fuel tank was replaced. This repair is costly, and has proven it is at best a temporary solution. This is an unsafe condition since loss of engine power from running out of fuel can be quite dangerous on a motorcycle.

Electrical System; Unknown or Other; Fuel/Propulsion System

ODI #11433912

Incident: April 25, 2012 · Filed: September 21, 2021

The fuel strip located inside the tank which sends an electronic signal to the dash gauge indicating the amount of fuel available until the low fuel warning light comes on malfunctions and eventually fails. The vehicle is available for inspection upon request. On three separate occasions (two on 55 mph + roads with two + lanes of traffic and once on a local 35 mph one lane road) I was driving and the fuel level indicated a sufficient amount to travel to my destination when the tank abruptly ran dry with no warning and I had to coast to the side of the road stranded and had to call for roadside assistance. The problem occurred within two to three years of the vehicle being in service. The factory warranty covers 3 years/3600 miles. To the best of my knowledge, the problem first occurred in 2011 or 2012. I am not sure if the first occurrence was covered under the original manufacturers factory warranty but I would not pay out of pocket cost to have the fuel strip replaced. After many complaints and incidences from other owners the manufacturer notified owners by mail that the fuel strip warranty was extended to 12 years from original date of sale. By extending the warranty terms I would hope that the manufacturer planned to give its engineers time to come up with a permanent fix for this ongoing problem, but chose to only keep replacing the defective part with another sure to fail part continuing in a cycle of frustration and endangering rider safety. My vehicle is now in the 13th year of service and is no longer covered by the extended warranty. I voiced my concerns to the BMW Customer Service representatives and they acknowledge the warranty has now expired with no permanent fix or resolve to the original problem. This malfunction has been well documented at BMW motorcycle dealers both in the US and worldwide. My concerns have fallen on deaf ears. Check the service records at any BMW motorcycle dealer and you will find many replaced fuel strips under the warranty.

Fuel/Propulsion System

ODI #11267107

Incident: September 27, 2019 · Filed: October 8, 2019

FUEL PUMP OUTPUT FLANGE CRACKED, RESULTING IN FUEL LEAKING DOWN THE SIDE OF THE BIKE AND ONTO HOT COMPONENTS WHILE RIDING. THIS ISSUE HAS ALREADY BEEN THE SUBJECT OF A BMW RECALL - BUT APPARENTLY THE "INSPECT AND REINFORCE" SOLUTION ISN'T REALLY ADEQUATE LONG-TERM. THIS PUMP HAD BEEN "INSPECTED AND REINFORCED" - AND THE FLANGE STILL CRACKED AND CAUSED A DANGEROUS FUEL LEAK WITH THE POTENTIAL FOR BODILY INJURY OR WORSE.

Fuel/Propulsion System

ODI #10499882

Incident: December 8, 2012 · Filed: February 24, 2013

THE FUEL GAUGE DISPLAYED THAT I HAD 40 MILES LEFT AND WAS ON RESERVE AND THE LOW FUEL LIGHT ILLUMINATED. TWO MILES LATER, ON THE WAY TO STOP FOR GAS, THE ENGINE SUDDENLY SPUTTERED ON A BUSY INTERSTATE AND DIED. I HAD NO POWER AND MANAGED TO SAFELY COAST THROUGH TRAFFIC TO A STOP ON THE SHOULDER OF THE INTERSTATE. FORTUNATELY I WAS ABLE TO SLOSH THE TANK BACK AND FORTH AND START THE ENGINE AGAIN AND MADE IT SAFELY TO A GAS STATION 4 MILES DOWN THE ROAD WHERE I FILLED UP A BONE DRY TANK STILL TELLING ME I HAD 38 MILES LEFT ON THE TANK. THIS WAS THE FIRST STRIP TO MY KNOWLEDGE ON THIS BIKE THAT FAILED. I HAD IT REPLACED FOR $300 BY BMW. THE SECOND ONE FAILED IN A SIMILAR FASHION, EXCEPT THIS TIME BECAUSE OF THE SHOULDER I CRASHED INTO A RETAINING WALL. SEE ODI NUMBER : 10498389 FILED AFTER THAT EPISODE. *TR

Fuel System, Gasoline

ODI #10457663

Incident: May 4, 2012 · Filed: May 7, 2012

FUEL STRIP (FUEL LEVEL SENSOR) FAILS RENDERING A FALSE "EMPTY" READING ON MY FUEL GAUGE. THIS IS DUE TO A DEFECTIVE FUEL SENSOR STRIP THAT HAS BEEN USED IN VARIOUS BMW "R" MODELS. *TR

Other BMW R1200 R model years

Check your 2009 BMW R1200 R VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW R1200 R at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN