2008 BMW R1200 GS Adventure Recalls & Complaints

Incident: February 11, 2016 · Filed: February 12, 2016

MY BMW MOTORCYCLE WAS STATIONARY AT THE TIME BUT WITH A BRAKE FAILURE WARNING LIGHT INDICATED ON THE DISPLAY PANEL ONCE THE IGNITION WAS TURNED ON AND THE MOTORCYCLE ENGAGED TO BE RIDDEN THE MOTORCYCLE HAS LESS THAN 5,000 MILES ON IT. AFTER DOING SOME INTERNET RESEARCH, THE ABS MODULE IS COMMONLY FAILING AT AN ALARMING RATE THROUGHOUT THE USA AND ABROAD. THE ESTIMATED VALUE OF THE REPAIR WITH PARTS ALONE IS OVER $2,000 NOT INCLUDING LABOR. THESE UNITS SHOULD HAVE BEEN RECALLED BY THE MFG., BMW YET THERE HAS BEEN NO SUCH RECALL. BMW HAS MADE NO ACCOMMODATION TO EXTEND THE WARRANTY OR PROVIDE A REPLACEMENT DESPITE BEING WELL AWARE OF THE FAILURE RATE OF THESE ABS UNITS. OBVIOUSLY, A FAILURE OF THIS MODULE COULD CAUSE SEVERE INJURY OR DEATH WHILE OPERATING THE MOTORCYCLE.

Incident: July 17, 2015 · Filed: July 31, 2015

TL* THE CONTACT OWNS A 2008 BMW R1200 GS ADVENTURE. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED AN ENGINE OIL LEAKAGE FROM THE REAR DISK THAT LEAKED ONTO THE REAR TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,591.

Incident: July 1, 2014 · Filed: July 23, 2015

IN HAVING THE BIKE SERVICE WAS INFORMED THAT THE ABS PUMP UNIT HAS FAILED AND DID SOME TIME AGO. THIS IS HAPPENING ON MANY BMW MOTORCYCLE FROM THE R AND K CLASS OF BIKES AND COULD CAUSE COMPLETE BRAKE FAILURE UNEXPECTEDLY WHICH WILL CREATE SERIOUS INJURIES

Incident: September 24, 2014 · Filed: October 2, 2014

I WAS RIDING ON THE CENTRAL FREEWAY ON THE BAY BRIDGE APPROACH WHEN I BEGAN TO FEEL HEAT ON MY LEFT INNER THIGH. I ALSO NOTICED A BURNING RUBBER OR PLASTIC SMELL. I IMMEDIATELY BEGAN MERGING TO THE RIGHT AS I WAS APPROACHING THE LAST SAN FRANCISCO EXIT BEFORE THE BAY BRIDGE. I FOUGHT MY WAY THROUGH THE HEAVY TRAFFIC ALL WHILE LOOKING DOWN TO SEE WHAT LOOKED LIKE EMBERS DROPPING OFF THE LEFT SIDE. I PULLED INTO A SHELL STATION, JUMPED OFF AND PULLED THE BURNING SEAT OFF OF THE MOTORCYCLE AND PATTED IT OUT. I FOUND THAT THE FRONT SEAT RAIL HAD BECOME DISLODGED (IT IS ONLY HELD IN PLACE BY A RUBBER STRAP THAT IS LOOSENED TO ADJUST THE SEAT HEIGHT) AND RUBBED THROUGH THE PROTECTIVE COVER OF THE POSITIVE BATTERY TERMINAL AND ARCED TO THE FRAME. THE SEAT AND THE SEAT BRACKETS WERE MELTED. I WAS ABLE TO COVER UP THE DAMAGED WIRING AND BATTERY ENOUGH TO ALLOW ME TO SAFELY RESTART THE MOTORCYCLE TO HAVE THE DAMAGE EVALUATED BY A SHOP (BAVARIAN CYCLE WORKS IN SAN FRANCISCO.) THE DAMAGE WAS PHOTOGRAPHED AND I AM AWAITING PARTS TO ARRIVE FROM GERMANY TO CARRY OUT THE REPAIRS. I HAVE LOCATED A MACHINE SHOP THAT SELLS A KIT TO MODIFY THE SEAT TO PREVENT THIS FROM OCCURRING AGAIN. THE KIT ELIMINATES THE SOLID METAL BAR THAT RUNS ACROSS THE WIDTH OF THE SEAT. IT USES TWO SHORTER RODS ONLY WHERE THEY ARE NEEDED TO LOCATE THE SEAT IN ITS FRONT HOLDER. NEEDLESS TO SAY, I ORDERED ONE RIGHT AWAY. *TR

Incident: September 17, 2008 · Filed: April 27, 2014

FUEL LEVEL SENSOR INDICATOR FAILED AND NEEDED REPLACEMENT. THIS HAPPENS ON ALL OF THESE MODELS BUT THERE HAS NOT BEEN A RECALL OR EVEN AN ACCEPTABLE FIX FROM BMW. WE ARE ADVISED TO USE OUR ODOMETER AND IGNORE WARNING LIGHTS ON OUR DASHBOARDS. *TR

Incident: April 11, 2014 · Filed: April 21, 2014

ABS SYSTEM FAILED- REQUIRED THE PURCHASE OF $2500 NEW ABS PUMP CONTROL MODULE. *TR

Incident: October 15, 2009 · Filed: January 15, 2014

FUEL LEVEL INDICATOR SHOWED EMPTY AFTER REFILLING. FLASHING LIGHTS INDICATING PROBLEM WITH VEHICLE. FILLED UP WITH 1/2 GALLON OF 91 OCTANE GASOLINE TO VISIBLE FULL IN TANK. THE TANK WAS NOT EMPTY, FAULTY FUEL LEVEL GAUGE/STRIP. THIS ITEM HAS BEEN REPLACED IN THE PAST WITH NO APPARENT PERMANENT FIX. *TR

Incident: June 2, 2013 · Filed: November 17, 2013

ARBITRARY FAILURE OF THE FUEL LEVEL SENSOR. IT OCCURRED AT 2,200 MILES. OPERATION OF THE MOTORCYCLE WAS UNINHIBITED EXCEPT FOR A FALSE READING ON THE FUEL GAUGE. AFTER THE FAILURE AND REPLACEMENT OF THE RECALLED FUEL PUMP CONTROLLER, THE FUEL GAUGE READS EMPTY REGARDLESS OF LEVEL. THIS RESULTS IN A CONSTANT WARNING LIGHT THAT CANNOT BE RESET OR TURNED OFF. THIS PROBLEM IS WELL DOCUMENTED AND A COMMON ISSUE WITH THIS TYPE OF FUEL SENSOR IN THESE MOTORCYCLES. *TR

Incident: October 7, 2013 · Filed: October 15, 2013

TL* THE CONTACT OWNS A 2008 BMW R1200 GS ADVENTURE MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL PUMP ELECTRONICS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 3,300.

Incident: January 12, 2013 · Filed: July 30, 2013

FIRST, MY MOTORCYCLE IS TITLED A 2009 BUT MANUFACTURED IN 2008. THE FLANGE WHERE THE FEMALE FUEL LINE QUICK-DISCONNECT CRACKED (ON THE LEFT AND RIGHT SIDES OF THE FUEL TANK) AND THERE WAS A SLIGHT SMELL OF FUEL. ONE OF THE MALE PLASTIC QUICK DISCONNECT BROKE WHEN I WAS MAKING THE REPAIR. I ORDERED, RECEIVED AND INSTALLED METAL QUICK-DISCONNECTS AND REPAIRED THE CRACKED FLANGE ITSELF WITH PARTS ORDERED FROM BEEMER BONEYARD. *TR