NHTSA vehicle safety data

2007 BMW R 1200 RT Recalls & Complaints

The 2007 BMW R 1200 RT has 5 NHTSA recall campaigns and 52 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

Includes campaigns NHTSA files under the spelling "R1200 RT".

NHTSA recall and complaint data for the 2007 BMW R 1200 RT. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 BMW R 1200 RT owner complaints

Owners have filed 52 complaints with NHTSA about the 2007 BMW R 1200 RT, describing incidents dated June 25, 2008 to September 1, 2020.

Most-cited components

Fuel/Propulsion System 37 complaints
Service Brakes 9 complaints
Power Train 7 complaints
Electrical System 3 complaints
Wheels 2 complaints
Engine 1 complaint

Together, the 52 complaints on file report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11420714 · Filed June 12, 2021
A fuel leak around at the fuel pump flange. Leaking around the support ring installed by the previous remedy. I contacted a dealer several times, but they have been unable to remedy due to no parts since April 2021. I also contacted [email protected] and they said "at this time the remedy…
ODI #10915030 · Filed October 10, 2016
FUEL GAUGE STOPPED RESPONDING, LEADING TO RUNNING OUT OF FUEL WHILE MOVING. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013.THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED BY THE DEALER04. THIS IS AN UNSAFE CONDITION SINCE LOSS OF ENGINE POWER FROM RUNNING OUT OF…
ODI #10913696 · Filed October 4, 2016
FUEL GAUGE STOPPED RESPONDING, LEADING TO THE POSSIBILITY OF RUNNING OUT OF FUEL WHILE MOVING. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013. I HAVE HAD THIS HAPPEN 3 TIMES SO FAR, AND EACH TIME THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED. THIS IS AN UNSAFE…

Read all 52 complaints

Owner-reported

2007 BMW R 1200 RT mileage at failure

49 of the 52 complaints on file for the 2007 BMW R 1200 RT give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 25,000 miles	Middle half 15,000–50,000 miles	Based on 35 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2007 BMW R 1200 RT in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA13-006: Fuel Leak - Motorycle
Closed January 31, 2014
- Recall 13V-617
Preliminary Evaluation PE12-036: Fuel Leak - Motorcycle
Closed July 22, 2013

Open and recently closed NHTSA defect investigations

Fuel Pump Flange may Leak

NHTSA #20V471000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 10, 2020 · BMW of North America, LLC

Potentially affected: 16,926 vehicles

Repair completion: 58.36% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 18, 2021

Defect description

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Safety consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel Mounting Flange may Crack

NHTSA #15V141000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 11, 2015 · BMW of North America, LLC

Potentially affected: 43,426 vehicles

Repair completion: 60.91% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 7, 2015 · Vehicles built January 27, 2005 – March 29, 2010 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Safety consequence

If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel Pump Flange may Leak

NHTSA #13V617000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported December 12, 2013 · BMW of North America, LLC

Potentially affected: 50,184 vehicles

Repair completion: 59.33% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 16, 2014 · Vehicles built January 7, 2005 – April 13, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Safety consequence

A fuel leak in the presence of an ignition source may result in a fire.

Manufacturer remedy

BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FRONT BRAKE LINES

NHTSA #10V276000 · Service Brakes, Hydraulic · NHTSA notice

Reported June 18, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 15,532 vehicles

Owners notified September 20, 2010

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Safety consequence

IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT BRAKE LINES

NHTSA #09V256000 · Service Brakes, Hydraulic · NHTSA notice

Reported July 8, 2009 · BMW OF NORTH AMERICA, LLC

Potentially affected: 1,535 vehicles

BMW campaign R1200 RT · Owners notified October 5, 2009

Defect description

BMW IS RECALLING 1,535 MY 2007-2009 R1200RT MOTORCYCLES. DUE TO ROUTING AND ASSEMBLY TOLERANCES OF THE FRONT BRAKE LINES, IT IS POSSIBLE FOR THE LINES TO BE UNDER STRAIN. IN COMBINATION WITH VIBRATION DURING RIDING, THE BRAKE LINES COULD DEVELOP A LEAK. THE LEVEL OF FLUID IN THE FRONT BRAKE FLUID RESERVOIR COULD DROP RENDERING THE FRONT BRAKES INOPERATIVE.

Safety consequence

IN THE EVENT THAT ONLY THE REAR BRAKES WERE OPERATIONAL, SEVERE LOSS OF CONTROL DURING HARD BRAKING COULD RESULT. THIS COULD RESULT IN A SERIOUS CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND REPAIR THE MOTORCYCLES WITH NEW FRONT BRAKE LINES, WITH MODIFIED ROUTING FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 5, 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

BMW'S RECALL CAMPAIGN NO. R1200 RT.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2007 BMW R 1200 RT. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

52 owner complaints have been filed with NHTSA for the 2007 BMW R 1200 RT.

Fuel/Propulsion System

ODI #11420714

Incident: September 1, 2020 · Filed: June 12, 2021

A fuel leak around at the fuel pump flange. Leaking around the support ring installed by the previous remedy. I contacted a dealer several times, but they have been unable to remedy due to no parts since April 2021. I also contacted [email protected] and they said "at this time the remedy for the recall: 20V-471 is available; however, the parts are on backorder for all models. We currently don't have an eta we can provide." BMW has failed to prepare sufficient replacement parts and they are unable to remedy for 20V-471 in a timely manner.

Fuel/Propulsion System

ODI #10915030

Incident: April 19, 2015 · Filed: October 10, 2016

FUEL GAUGE STOPPED RESPONDING, LEADING TO RUNNING OUT OF FUEL WHILE MOVING. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013.THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED BY THE DEALER04. THIS IS AN UNSAFE CONDITION SINCE LOSS OF ENGINE POWER FROM RUNNING OUT OF FUEL CAN BE QUITE DANGEROUS ON A MOTORCYCLE

Fuel/Propulsion System

ODI #10913696

Incident: August 27, 2016 · Filed: October 4, 2016

FUEL GAUGE STOPPED RESPONDING, LEADING TO THE POSSIBILITY OF RUNNING OUT OF FUEL WHILE MOVING. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013. I HAVE HAD THIS HAPPEN 3 TIMES SO FAR, AND EACH TIME THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED. THIS IS AN UNSAFE CONDITION SINCE LOSS OF ENGINE POWER FROM RUNNING OUT OF FUEL CAN BE QUITE DANGEROUS ON A MOTORCYCLE.

Fuel/Propulsion System

ODI #10913693

Incident: March 12, 2016 · Filed: October 4, 2016

FUEL GAUGE STOPPED RESPONDING, LEADING TO THE POSSIBILITY OF RUNNING OUT OF FUEL WHILE MOVING. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013. I HAVE HAD THIS HAPPEN 2 TIMES SO FAR, AND EACH TIME THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED. THIS IS AN UNSAFE CONDITION SINCE LOSS OF ENGINE POWER FROM RUNNING OUT OF FUEL CAN BE QUITE DANGEROUS ON A MOTORCYCLE.

Fuel/Propulsion System

ODI #10913689

Incident: April 18, 2015 · Filed: October 4, 2016

FUEL GAUGE STOPPED RESPONDING, LEADING TO RUNNING OUT OF FUEL WHILE MOVING ON A CITY STREET. THIS IS A COMMON FAILURE ON MANY BIKE MODELS FROM BMW FROM 2005-2013. I HAVE HAD THIS HAPPEN 1 TIME SO FAR, AND EACH TIME THE FUEL LEVEL MEASURING STRIP IN THE FUEL TANK WAS REPLACED. THIS IS AN UNSAFE CONDITION SINCE LOSS OF ENGINE POWER FROM RUNNING OUT OF FUEL CAN BE QUITE DANGEROUS ON A MOTORCYCLE.

Power Train

ODI #10781385

Incident: October 10, 2015 · Filed: October 12, 2015

FINAL DRIVE BEARING SUDDENLY DEVELOPED PLAY (WHEEL CAN BE MOVED LATERALLY BY HAND). VERY UNSTABLE HANDLING AND WOBBLE UPON DECELERATION DUE TO WHEEL MOVEMENT. VEHICLE WILL "SHIMMY" CONSIDERABLY FROM SIDE-TO-SIDE UPON ENGINE BRAKING.

Service Brakes

ODI #10767426

Incident: July 23, 2015 · Filed: September 22, 2015

WHEN I BEGAN A RIDE THE RED ABS BRAKE FAILURE WARNING LIGHT CAME ON AND REMAINED ON. A SHOP READ THE CODE TO DETERMINE THE CAUSE AS ABS PUMP MOTOR FAILURE. I LEARNED THROUGH ON-LINE RESEARCH THAT IT IS A COMMON PROBLEM RELATING TO POOR DESIGN OF THE ABS PUMP MOTOR BRUSHES THAT FAIL TO MAKE GOOD CONTACT RESULTING IN A LOW VOLTAGE SITUATION AND PUMP FAILURE. THE RESULT - THE ABS SYSTEM DOES NOT WORK. THE ESTIMATED COST OF REPLACING THE UNIT IS APPROX. $2200. THE MECHANIC TAPPED ON THE MOTOR HOUSING AND FREED UP THE BRUSHES BUT IT WAS A TEMPORARY FIX THAT LASTED ABOUT 200 MILES. IT THEN BECAME AN INTERMITTENT PROBLEM FOR ABOUT 400 MILES BEFORE IT WENT BACK TO BEING THE CONSTANT PROBLEM THAT I AM NOW FORCED TO FIX OR RIDE WITHOUT ABS BRAKES. THIS IS A WELL KNOWN AND DOCUMENTED PROBLEM BUT BMW HAS NOT ADMITTED ANY PROBLEMS RELATED TO DESIGN OF THE UNIT. THE PROBLEM APPEARS TO BE IN THE WAY THE BRUSHES SLIDE IN A GROOVED GUIDE OR KEY WAY . APPARENTLY THE GROOVES GET DIRTY AND THE BRUSHES HANG UP AND DON'T REACH THE PROPER POSITION FOR GOOD CONTACT WITH THE MOTOR ARMATURE IF I UNDERSTAND IT CORRECTLY. MODULEMASTER IN MOSCOW, IDAHO, REBUILDS THE UNITS AND PROVIDES A 5 YR GUARANTEE. THEY SEEM TO BE QUITE BUSY WITH THESE UNITS. MY MECHANIC ACTUALLY SENT IN 2 OF THEM AT THE SAME TIME. THE SECOND UNIT WAS FROM A GS MODEL. AND THERE ARE OTHER MODELS EXPERIENCING THE SAME ISSUE. IT IS MY OPINION THAT NHTSA NEEDS TO TAKE A LOOK AT THIS ISSUE AND CAUSE BMW TO FIX THE POOR DESIGN AND ELIMINATE THE PROBLEM OF ABS FAILURE. DOCUMENTED EVIDENCE OF THE SCOPE OF THE PROBLEM CAN BE FOUND THROUGH SITES SUCH AS FORUMS.BMWMOA.ORG, WWW.XS-ADVENTURE.COM, WWW.I-BMW.COM.

Unknown or Other

ODI #10758488

Incident: October 15, 2014 · Filed: August 21, 2015

THE MOTORCYCLE STARTED STALLING AFTER I WOULD DISENGAGE THE CLUTCH TO SLOW DOWN OR STOP. IT WOULD NOT START BACK UP UNLESS I TURNED THE THROTTLE AND HELD THE RPM'S ABOVE 1500. THE BIKE WOULD NOT IDLE UNLESS I KEPT THE THROTTLE PARTIALLY OPEN. I BROUGHT THE BIKE TO THE DEALER AND THEY RE-FLASHED THE COMPUTER AND UP-GRADED THE SOFTWARE. THAT LASTED 2 WEEKS AND THE STALLING STARTED BACK AGAIN. ALL RE-CALLS FOR THIS BIKE WERE PERFORMED BY BMW. NO TROUBLE CODES WERE SHOWN TO EXIST ON THE BIKES ECU WHEN TESTED BY THE DEALERS SCAN EQUIPMENT. I HAVE SINCE REPLACED: SPARK PLUGS, IDLE ACTUATORS (2), CAM POSITION SENSOR, FUEL PUMP CONTROLLER, FUEL PUMP, AND BATTERY. THE MOTORCYCLE HAS A LITTLE OVER 32,000 MILES ON IT NOW. SOME OF THE PARTS REPLACED DID CURE THE STALLING PROBLEM TEMPORARILY, BUT IT ALWAYS CAME BACK. I HAVE SINCE PARKED THE MOTORCYCLE BECAUSE THE STALLING SCARES ME AND MY GIRLFRIEND WHEN IT UNEXPECTEDLY HAPPENS IN TRAFFIC. IT IS ABSOLUTELY DANGEROUS! I KNOW FROM READING POSTS ONLINE FROM FELLOW BMW MOTORCYCLE OWNERS THAT MANY OTHERS WHO OWN THE R 1200RT MADE FROM 2005-2009 HAVE THIS SAME STALLING PROBLEM. AS FAR AS I KNOW BMW HAS NOT RE-CALLED MY YEAR AND MODEL BIKE TO FORCE THE DEALERS TO FIX THIS PROBLEM.

Power Train; Service Brakes

ODI #10704833

Incident: April 8, 2015 · Filed: April 9, 2015

REAR DRIVE ASSEMBLY OIL LEAKING AFFECTING TIRES TRACTION AND BRAKING - LOSS OF REAR BRAKES FROM OIL AND NO ABS ACTIVE. *TR

Service Brakes

ODI #10683489

Incident: January 20, 2014 · Filed: February 14, 2015

ABOUT 1 YEAR AGO, THE 'BRAKE FAILURE" LIGHT CAME ON THE DASHBOARD OF MY BMW R1200RT MOTORCYCLE. EVEN THOUGH THE BRAKES SEEM TO WORK FINE, I PRETTY MUCH STOPPED USING THE MOTORCYCLE BECAUSE I WAS AFRAID OF IT. BECAUSE OF INACTIVITY, THE ENGINE WOULDN'T START SO I RENTED A U-HAUL TRAILER AND BROUGHT THE BIKE TO A BMW DEALER SO THEY COULD GET IT RUNNING AGAIN. BECAUSE I HADN'T USED THE BIKE FOR AWHILE, I FORGOT TO TELL THEM ABOUT THE BRAKE FAILURE LIGHT. WHEN THEY TEST RODE MY BIKE, THEY SAW THE LIGHT AND TRIED TO RESET (CLEAR) A CODE TO SEE IF IT WOULD FIX IT. THE CODE WOULD NOT RESET OR CLEAR. THEY THEN TOLD ME THAT THIS BRAKE FAILURE LIGHT INDICATES THAT THE ABS SYSTEM IS NO LONGER WORKING. I WAS TOLD THE PART TO FIX IT COST ABOUT $2,500. I FEEL THIS SHOULD BE SOMETHING THAT BMW SHOULD REPAIR AS IT IS A SAFETY ISSUE OUT OF MY CONTROL. IS BMW RESPONSIBLE TO REPAIR THIS PROBLEM? *TR

Other BMW R 1200 RT model years

Check your 2007 BMW R 1200 RT VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW R 1200 RT at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN