2014 BMW I3 Recalls & Complaints

Incident: October 6, 2024 · Filed: October 7, 2024

The carbon fiber roof is delaminating and a portion of it came off and hit the front windshield of another car, causing them to partially lose control of their vehicle almost causing an accident. This is a known issue BMW has not taken an action to resolve it. I’m afraid that a larger chunk may hit somebody’s car and cause a severe accident.

Incident: August 15, 2024 · Filed: September 10, 2024

A large portion of the car's hood (carbon laminate?) has ripped off and is surely to continue to tear and fly off while driving.

Incident: January 13, 2024 · Filed: June 14, 2024

When the vehicle depletes it's battery and switches over to the range extender or the gas engine, the car will suddenly shut off and a drivetrain error appears. This seems to only happen when the car is traveling over 55 mph. This has happened on repeated occasions. If you then leave the car sit for several minutes and then turn it back on, it is driveable as long as it is driven under 55 mph. Since this only happens at higher speeds, it's been extremely dangerous because other cars are also traveling at high speeds and this has happened once on a freeway where the speed limit was 70 mph. If there's no shoulder to guide the car onto when this happens, the car would be disabled on the road because it will not drive again right away. I've taken it in to fix and the mechanic said it was a software update that was needed. However, the problem happened again a few months later. There was no warning before this happened both times it occurred.

Incident: February 23, 2024 · Filed: March 8, 2024

AC Compressor for the car battery system failed. There was a check engine light that was on steady, but not flashing. The electric range in the car reduced by 20 to 30% as a result of this fault. It was brought into the BMW dealership for inspection and they determined that was a short in the AC compressor and that the whole AC compressor system would need to be replaced; compressor, lines and radiatorx2 (battery radiator also needed). This was because this typical failure causes metal filings to enter the cooling system and it's not recommended to flush it out. There were no prior warnings or noise leading up to the problem. I'm concerned that there is a high risk that further driving the vehicle or charging it could cause a battery failure and cause it to catch on fire since there is no cooling. Normally a flashing engine light means to stop driving immediately, but there was no flashing light only a steady light. The BWM system check menu reported no issue with the car! The repair bill for this is about $8,400 and is rediculous. This seems to be a common problem when you start searching for it. Seems to also happen to the BMW i8 which shares the same compressor. Note that there are several revisions to the ac compressor part number which seems to suggest that they had to keep changing the part as production went on but did not notify affected cars that they could have a serious problem. This shouldn't be happening at 77k miles.

Incident: October 10, 2023 · Filed: December 28, 2023

I am writing to bring to your attention a persistent issue I have been facing with my 2014 BMW i3, VIN: [XXX] . Unfortunately, I have been experiencing an airbag and/or seatbelt alert problem identified as "Driver Restraint System Malfunction" with the error code 930904 displayed on the dashboard. I have attached supporting documentation, including images and information from the BMW Service Bulletin, which clearly outlines that the error code 930904 is a known and routine problem for my specific vehicle model, thus a Service Bulletin was issued by BMW, as you can see attached from BMW’s website. It has come to my attention, through online forums and discussions within the BMW i3 community, that others have successfully resolved this issue under the terms of the service bulletin, but for some reason I keep getting the runaround. Regrettably, despite my efforts to address this matter with BMW USA on three separate occasions since October 2023, I have not received a satisfactory resolution. Instead, I have been redirected to BMW Authorized Dealerships, where I am faced with unjustifiable diagnostic fees and repair costs. It is perplexing to me that other members of the BMW community have had their issues resolved under the service bulletin at no cost, while I am being subjected to unnecessary expenses. To provide you with a clear overview: 1. The error code 930904 is documented in the BMW Service Bulletin for my 2014 BMW i3 REX. 2. Other BMW i3 owners have successfully had this issue resolved under warranty through the service bulletin. 3. BMW USA and its authorized dealerships have been uncooperative in acknowledging and addressing this known issue. I visited my local BMW dealership in Rochester, NY, on 10-10-23, only to be informed that they could not locate the referenced code and insisted on charging me a diagnostic fee and an additional $1,800 for the repair. Are you kidding me? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 1, 2023 · Filed: October 25, 2023

I am writing regarding an ongoing issue I am having with BMW North America and their dealerships concerning a faulty airbag in my 2014 BMW i3 electric vehicle (VIN #: [XXX] ). On multiple occasions in October 2023, BMW North America informed me that the "Driver Restraint System Malfunction" alert in my vehicle could be repaired under a Service Action extension (code SIB010818/DC3234908400) that covers airbag issues in vehicles under 10 years old and 100,000 miles. See pictures of the issue/alert on dash attached. However, when I brought my vehicle to two local BMW dealerships (in Rochester and Syracuse, NY), they either claimed the Service Action code did not exist or that I would need to pay a diagnostic fee of $250 AND $1,800 to fix the airbag and seatbelt issue out of pocket, despite BMW North America saying this should be covered. As a disabled person on a fixed income, I cannot afford to gamble hundreds of dollars on diagnostic fees when BMW North America has already provided the Service Action code that should cover the necessary airbag repair. This is not only a financial burden but a safety concern, as I am being forced to drive a vehicle with a known airbag defect. I am reaching out to request your help resolving this issue with BMW as this issue with my BMW i3 is VERY routine and all over the internet and the BMW i3 forums as BMW clearly failed its very basic duties in protecting USA consumers with this vehicle and its numerous issues. Airbags and seatbelts are NOT issues consumers should have to gamble with due to the failures of BMW in properly producing a vehicle that would avoid such serious problems as clearly prevalent to a lot of owners of this make and model. I look forward to your assistance in this urgent matter. Please let me know if you need any additional information from me. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 1, 2023 · Filed: August 19, 2023

Car roof is delaminating.

Incident: August 1, 2022 · Filed: August 17, 2023

Roof is bubbling showing signs of delamination. Structural integrity is in question. I believe it is due to the carbon fiber epoxy material degrading due to sunlight exposure.

Incident: June 24, 2023 · Filed: June 25, 2023

While driving through a parking lot at slow speeds on 6/24/2023 around 6:30 pm in Phoenix AZ, I noticed the steering felt very heavy and the car pulled hard to the left. While driving slowly down a driveway, I checked the air pressure data and found all 4 tires at recommended levels. I drove 15 miles to my home below the speed limit while wrestling with the steering wheel, thinking that the power to the steering system had somehow failed. Some quick online research upon my return revealed that this problem is not unusual, but can be resolved by turning the car off and then back on again. Following this procedure solved the issue, but leaves me with uncertainty as to when it may happen again.

Incident: March 18, 2023 · Filed: March 29, 2023

Light shows on dash for airbag. I took to the dealership and they said there was a problem and needed to be replaced. The airbag was defective.