2013 BMW 640I Recalls & Complaints

Incident: January 5, 2021 · Filed: February 17, 2021

WARNING LIGHT THAT THE FRONT PASSENGER AIRBAG WAS NOT WORKING

Incident: September 27, 2019 · Filed: October 24, 2019

ON 9/27/19 I LEFT THE GAS STATION WITH FULL TANK OF GAS AND STOPPED AT A RED LIGHT ON A BUSY ROAD IN RUSH HOUR TRAFFIC. THE LIGHT CHANGED GREEN MY VEHICLE SHUT OFF AND WOULD NOT RESTART CREATING A SAFETY HAZARD. I PUT THE GEAR IN NEUTRAL AND PUSHED OUT OF THE ROAD. A LIGHT CAME ON "AUTO START/STOP DISENGAGED." EVERYTHING ELSE POWERED (WINDOWS, RADIO, REAR SHADES, SCREEN, PHONE AND NAVIGATION, ETC.) AND WORKED SO THERE WAS NO PROBLEM WITH THE BATTERY. THE TOW TRUCK ARRIVED 1 HOUR LATER, THE CAR WOULDN'T START, LOCKED UP COMPLETELY AND THE GEAR WOULDN'T SHIFT. THE DEALERSHIP HAD MY CAR FROM 9/27-10/10/19. DIAGNOSED CAUSE: BATTERY OLD/WORN, REAR BRAKES AND OIL LEAKING. THE CAR WAS SERVICED. ON 10/13/19 THREE DAYS LATER MY CAR CUT OFF AGAIN IN THE MIDDLE OF THE ROAD AFTER BACKING OUT OF A PARKING SPACE, LOCKED UP IMMEDIATELY AND WOULD NOT START JUST AS BEFORE. THIS TIME THE CAR WOULD NOT SHIFT INTO NEUTRAL AND COULD NOT BE PUSHED OUT OF THE ROAD. I BLOCKED TRAFFIC AND HAD TO WAIT ONE HOUR AGAIN FOR ANOTHER TOW TRUCK TO TOW MY VEHICLE BACK TO THE BMW DEALERSHIP. JUST LIKE BEFORE EVERYTHING ELSE WORKED (A/C, WINDOWS, LIGHTS, RADIO, BLINKERS, POWER SEATS, DISPLAY PANEL, ETC.), SO ONCE AGAIN IT WAS NOT THE BATTERY. AGAIN A SAFETY HAZARD WAS CREATED WITH ONCOMING TRAFFIC TRYING TO AVOID HITTING ME. IT WAS DARK, I WAS ALONE AND STOOD OUTSIDE THE CAR TO WAVE VEHICLES TO GO AROUND PUTTING MY PERSONAL SAFETY IN JEOPARDY. ON 10/22/19 I HAD TO CALL THE DEALERSHIP AND ASK FOR AN UPDATE ON MY CAR BECAUSE I RECEIVED NO COMMUNICATION AT ALL. THE DIAGNOSED CAUSE: FUEL PUMP REPLACEMENT AND THE FUEL PUMP CONTROL UNIT: EKPS FAILED BY EXCESSIVE AMPERAGE DRAW FROM THE FAILED FUEL PUMP. SAME PROBLEM, BUT TO REPAIR THIS TIME THE COST IS OVER $1500.

Incident: September 28, 2019 · Filed: October 23, 2019

TL* THE CONTACT OWNS A 2013 BMW 640I. WHILE THE VEHICLE WAS STOPPED AT A RED LIGHT, THE ENGINE WOULD NOT AUTO ECONO RESTART AND HAD TO BE PUSHED OFF THE ROAD. THE VEHICLE WAS TOWED TO TOM BUSH BMW JACKSONVILLE (9875 ATLANTIC BLVD, JACKSONVILLE, FL 32225, (904) 371-4790) WHERE THE BATTERY AND BRAKES WERE REPLACED. THE DEALER ALSO STATED THAT THE OIL FILTER GASKET WAS LEAKING. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED THREE DAYS LATER. THE CONTACT RESEARCHED THE FAILURE AND FOUND THAT THERE WAS AN INTAKE FUEL FAILURE CAUSED BY UNDER VOLTAGE AND THE FUEL PUMP CONTROL UNIT FAILED FROM INSUFFICIENT AMP ELECTRICAL POWER. THE CONTACT CALLED THE SAME DEALER AND WAS INFORMED THAT THERE WAS NO RECALL COVERAGE; THEREFORE, THE CONTACT WOULD HAVE TO PAY OVER $3,600 FOR THE REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 71,519.

Incident: October 4, 2019 · Filed: October 10, 2019

CAN NOT LOCK OR UNLOCK CAR FROM WITHIN OR OUT. REPLACED DOOR ACTUATOR ON A DRIVER SIDE WHICH DID NOT SOLVE A PROBLEM.

Incident: September 30, 2016 · Filed: September 30, 2016

AFTER WORK (~ 5:30 PM, PST) WHILE DRIVING, I FLIPPED MY SUN VISOR TO PROTECT MYSELF FROM THE SUN. AS THE VISOR WAS BEING FLIPPED, THE VISOR FELL OUT OF ITS HINGE AND LOST ALL VISIBILITY. LOST ALL VISIBILITY. PANICKED AND SLAMMED ON THE BREAKS. ALMOST REAR ENDED AS I COULD HEAR THE CAR SLAMMING ON THE BREAKS. IF THIS HAPPENED ON THE FREEWAY, THIS COULD'VE BEEN A MAJOR ISSUE. THE VISOR WAS PROPPED BACK INTO ITS SPACE BUT POPS OUT VERY EASILY. THERE SEEMS TO BE A DESIGN FLAW WITH THE WAY THE VISOR IS BEING SECURED IN THE HINGE. I AM WORRIED THAT ALL BMW SHARING IN THIS DESIGN MAY POTENTIALLY EXPERIENCE THIS ISSUE WHILE DRIVING. I CONSIDER MYSELF TO BE PRETTY NIMBLE AND REACTIVE. I'M GENUINELY WORRIED ABOUT THE SAFETY OF OTHER DRIVES WITH THIS ISSUE.

Incident: December 19, 2015 · Filed: December 26, 2015

WHILE ACCELERATING FROM AN ON-RAMP TO A HIGHWAY, AN ALERT POPPED UP: DRIVETRAIN MALFUNCTION: DRIVE MODERATELY..." THE CAR LOST POWER AND I WAS NEARLY REAR-ENDED AND NEARLY CAUSED A MULTIPLE CAR ACCIDENT ON THE FREEWAY. I WAS ABLE TO GET THE CAR TO THE SIDE OF THE ROAD DURING HEAVY TRAFFIC. I TURNED THE CAR OFF, OPENED THE HOOD AND LOOKED INSIDE. NOTHING SEEMED AMISS. RESTARTED THE CAR AND THE YELLOW ALERT WAS GONE. PROCEEDED TO GET BACK ON THE HIGHWAY AND ACCELERATED AGAIN AND AGAIN THE ALERT POPPED UP AND I LOST POWER AND AGAIN NEARLY CAUSED AN ACCIDENT. THIS IS A VERY DANGEROUS MALFUNCTION THAT SEEMS TO BE OCCURRING WITH HIGH FREQUENCY. PLEASE LOOK INTO THIS AS GOVERNMENT INTERVENTION MAY SAVE LIVES.