NHTSA vehicle safety data

2006 Aprilia Mille R Recalls & Complaints

The 2006 Aprilia Mille R has 1 NHTSA recall campaign and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Aprilia dealer.

NHTSA recall and complaint data for the 2006 Aprilia Mille R. Recall data is refreshed daily from NHTSA.

2006 Aprilia Mille R owner complaints

Owners have filed 1 complaint with NHTSA about the 2006 Aprilia Mille R, describing incidents dated July 28, 2006.

Most-cited components

Fuel/Propulsion System 1 complaint

Newest complaints

ODI #10164335 · Filed August 3, 2006
FUEL LINE DISCONNECTED SUDDENLY INSIDE OF FUEL TANK, CAUSING A LOSS OF FUEL PRESSURE IN THE FUEL INJECTION SYSTEM. ENGINE DIED IMMEDIATELY, WOULD NOT RESTART WITHOUT REPAIR. FACTORY HOSE CLAMPS INEFFECTIVE INSIDE OF FUEL TANK. HAVE DIGITAL PHOTOS OF PROBLEM VISIBLE THROUGH THE FILLER HOLE. VEHICLE…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Aprilia Mille R in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE08-019: MOTORCYCLE STALLING
Closed July 21, 2008
- Recall 08V-306

Open and recently closed NHTSA defect investigations

MOTORCYCLE FRONT BRAKE LEVERS

NHTSA #06E035000 · Service Brakes, Hydraulic · NHTSA notice

Reported May 2, 2006 · CONSTRUCTORS RACING GROUP, LLC

Potentially affected: 1,611 vehicles

Owners notified May 22, 2006

Defect description

CERTAIN CRG FRONT BRAKE LEVERS, MODEL RB-511 DESIGNED FOR USE ON 2004-2006 YAMAHA YZF-R1 MOTORCYCLES, AND 2005-2006 YAMAHA YZF-R6 MOTORCYCLES. MODEL RB-512 IS DESIGNED FOR USE ON 2003-2006 DUCATI 749 AND 999 MOTORCYCLES, AND ON 2004-2006 APRILIA MILLE R MOTORCYCLES. DUE TO A MISALIGNMENT OF THE PIVOT BORE, THE BRAKE LEVER COULD BECOME SEIZED IN THE BRAKE ENGAGED POSITION, THEREBY PREVENTING THE FRONT BRAKE FROM DISENGAGING.

Safety consequence

A NON-RELEASE CONDITION COULD CAUSE DRAG ON THE FRONT BRAKE SYSTEM, WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

CRG WILL NOTIFY OWNERS AND REPLACE THE ROCKER FOR THE FRONT LEVER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2006. OWNERS MAY CONCACT CRG AT 831-763-7811.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CRG FRONT BRAKE LEVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON MOTORCYCLES MANUFACTURED BY YAMAHA, DUCATI, OR APRILIA.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Aprilia Mille R. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2006 Aprilia Mille R.

Fuel System, Gasoline

ODI #10164335

Incident: July 28, 2006 · Filed: August 3, 2006

FUEL LINE DISCONNECTED SUDDENLY INSIDE OF FUEL TANK, CAUSING A LOSS OF FUEL PRESSURE IN THE FUEL INJECTION SYSTEM. ENGINE DIED IMMEDIATELY, WOULD NOT RESTART WITHOUT REPAIR. FACTORY HOSE CLAMPS INEFFECTIVE INSIDE OF FUEL TANK. HAVE DIGITAL PHOTOS OF PROBLEM VISIBLE THROUGH THE FILLER HOLE. VEHICLE BOUGHT NEW IN JUNE 2006, PRESENTLY UNDER 1500 MILES DRIVEN. RESOLUTION WAS TO DRAIN AND REMOVE THE FUEL TANK, UN-BOLT BOTTOM FLANGE FROM THE TANK, REPLACE ALL FACTORY FUEL SYSTEM CLAMPS WITH SCREW-TYPE HOSE CLAMPS, REINSTALL THE FLANGE, REINSTALL AND REFILL THE FUEL TANK. *JB

Other Aprilia Mille R model years

Check your 2006 Aprilia Mille R VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Aprilia Mille R at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Aprilia VIN