try.vin
Log in

NHTSA vehicle safety data

2004 Airstream International CCD Recalls & Complaints

The 2004 Airstream International CCD has 2 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Airstream dealer.

NHTSA recall and complaint data for the 2004 Airstream International CCD. Recall data is refreshed daily from NHTSA.

2004 Airstream International CCD owner complaints

Owners have filed 3 complaints with NHTSA about the 2004 Airstream International CCD, describing incidents dated July 21, 2004 to July 4, 2011.

Most-cited components

  • Air Bags 1 complaint
  • Child Seat 1 complaint
  • Equipment 1 complaint
  • Service Brakes 1 complaint
  • Structure 1 complaint
  • Tires 1 complaint

Newest complaints

  • ODI #10413356 · Filed

    TL* THE CONTACT OWNS A 2004 AIRSTREAM INTERNATIONAL CCD TRAILER. THE CONTACT STATED THAT THE OUT RIGGERS WERE PUTTING PRESSURE ON THE FRAME AND CAUSING IT TO CRACK. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT…

  • ODI #10208482 · Filed

    H *TR

  • ODI #10087503 · Filed

    WHILE PULLING A TRAILER AND DRIVING AT 55 MPH UP A HILL CONSUMER WAS INFORMED THAT HE HAD A FLAT TIRE ON THE TRAILER. CONSUMER EXAMINED THE FLAT TIRE, AND SAW NO DAMAGE, BUT DID NOTICE THAT THE HUB OF THE WHEEL WAS BURNT. CONSUMER FELT THE BURNT SPOT AND IT WAS HOT TO TOUCH. DEALER EXAMINED THE…

Read all 3 complaints

AIRSTREAM/ WHEEL BEARING FAILURE

NHTSA #04V506000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported October 25, 2004 · AIRSTREAM, INC.

Potentially affected: 929 vehicles

Owners notified November 4, 2004 · Vehicles built June 1, 2003 – October 31, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT INADEQUATELY LUBRICATES THE OUTER BEARING. INADEQUATE LUBRICATION OF THE OUTER BEARING CAN BEGIN A CHAIN OF EVENTS THAT COULD LEAD TO WHEEL SEPARATION.

Safety consequence

SEPARATION OF ONE OR MORE WHEELS FROM THE TRAILER COULD CAUSE THE TRAILER TO HANDLE ERRATICALLY OR GO OUT OF CONTROL. A LOST WHEEL COULD ALSO STRIKE AN ONCOMING OR FOLLOWING VEHICLE CAUSING A CRASH, RESULTING IN SERIOUS INJURY OF DEATH TO THOSE INVOLVED.

Manufacturer remedy

DEALERS WILL REPAIR THE UNIT AND REMOVE THE WHEELS, INSPECT THE HUBS, INNER AND OUTER BEARINGS, RACES AND GREASE SEALS. IF NECESSARY, REPLACE PARTS AND REPACK THE WHEEL BEARING WITH HIGH TEMPERATURE GREASE AND REINSTALL THE HUB AND WHEELS. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT AIRSTREAM AT 1-877-596-6505.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

AIRSTREAM/SAMSUNG/MICROWAVE

NHTSA #03V464000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 12, 2003 · AIRSTREAM, INC.

Potentially affected: 3,340 vehicles

Vehicles built April 1, 2002 – October 31, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR AIRSTREAM AT 937-596-6111.

Notes

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Other Airstream International CCD model years

Check your 2004 Airstream International CCD VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Airstream International CCD at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Airstream VIN