NHTSA vehicle safety data

2005 Airstream Classic Recalls & Complaints

The 2005 Airstream Classic has 3 NHTSA recall campaigns and 6 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Airstream dealer.

NHTSA recall and complaint data for the 2005 Airstream Classic. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Airstream Classic owner complaints

Owners have filed 6 complaints with NHTSA about the 2005 Airstream Classic, describing incidents dated April 18, 2005 to April 19, 2006.

Most-cited components

Tires 3 complaints
Air Bags 1 complaint
Engine 1 complaint
Equipment 1 complaint
Power Train 1 complaint
Service Brakes 1 complaint

Newest complaints

ODI #10156368 · Filed April 28, 2006
DT*: THE CONTACT STATED UPON INSPECTION OF THE TIRES BLISTERS WERE NOTICED ON THE SIDEWALLS OF ALL FOUR TIRES. THE DEALER HAS BEEN ALERTED
ODI #10132333 · Filed August 11, 2005
I HAVE SOME COMPLAINTS THAT THE DEALER IS INVESTIGATING. MY MAIN COMPLAINT IS THAT THERE ARE THOUSANDS OF COMPLAINTS LISTED FOR THIS MODEL AND POSSIBLY THIS YEAR ON ANOTHER WEBSITE THAT I ONLY FOUND OUT ABOUT AFTER RECENTLY BUYING MY VEHICLE. I HAVE POSTED A MESSAGE THERE ABOUT THIS SITE SO THAT…
ODI #10130370 · Filed July 27, 2005
DT: THE CONSUMER STATES THAT THERE ARE MECHANICAL DIFFICULTIES WITH THE RV. DEALERSHIP TOLD CONSUMER TO CUT OUT THE CO2 DETECTION. CONSUMER STATES THERE IS A DEFECT IN THE UNIT. THERE IS NO GAS OR CO2 DETECTION IN IT. THE SENSORS HAVE BEEN DISCONNECTED BECAUSE THE ALARMS GO OFF, AND THEY WON'T FIX…

Read all 6 complaints

FAULTY HYDRAULIC BRAKE CONTROLLER

NHTSA #10V344000 · Service Brakes, Hydraulic · NHTSA notice

Reported July 22, 2010 · AIRSTREAM, INC.

Potentially affected: 737 vehicles

Owners notified August 11, 2010 · Vehicles built March 1, 2005 – April 30, 2009 (per NHTSA)

Defect description

AIRSTREAM IS RECALLING CERTAIN MODEL YEAR 2005-2009 CLASSIC TRAVEL TRAILERS MANUFACTURED FROM MARCH 2005 THROUGH APRIL 2009 AND EQUIPPED WITH HYDRAULIC BRAKE CONTROLLER BY ACTIVE TECHNOLOGIES. IT IS POSSIBLE THAT THE BRAKE CONTROLLER CAN FAIL UNEXPECTEDLY CAUSING THE BRAKES ON THE TRAILER TO LOCK UP OR TO FAIL COMPLETELY.

Safety consequence

THE LOCKING OF THE BRAKES OR BRAKE FAILURE COULD RESULT IN A LOSS OF VEHICLE CONTROL THAT COULD RESULT IN A CRASH AND POSSIBLE SERIOUS INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE BRAKE CONTROLLER AND IF FOUND TO BE DEFECTIVE IT WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT AIRSTREAM AT 937-596-6111.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR/DOMETIC

NHTSA #08V367000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 21, 2008 · AIRSTREAM, INC.

Potentially affected: 4,450 vehicles

Owners notified October 21, 2008 · Vehicles built June 1, 2003 – September 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

AIRSTREAM IS RECALLING 4,450 MY 2004-2007 SAFARI, INTERNATIONAL, INTERSTATE, LAND YACHT, CLASSIC, MY 2004-2006 SKYDECK, AND MY 2006 PARKWAY TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

AIRSTREAM IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR AIRSTREAM AT 1-937-596-6111.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIRSTREAM/ WHEEL BEARING FAILURE

NHTSA #04V506000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported October 25, 2004 · AIRSTREAM, INC.

Potentially affected: 929 vehicles

Owners notified November 4, 2004 · Vehicles built June 1, 2003 – October 31, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT INADEQUATELY LUBRICATES THE OUTER BEARING. INADEQUATE LUBRICATION OF THE OUTER BEARING CAN BEGIN A CHAIN OF EVENTS THAT COULD LEAD TO WHEEL SEPARATION.

Safety consequence

SEPARATION OF ONE OR MORE WHEELS FROM THE TRAILER COULD CAUSE THE TRAILER TO HANDLE ERRATICALLY OR GO OUT OF CONTROL. A LOST WHEEL COULD ALSO STRIKE AN ONCOMING OR FOLLOWING VEHICLE CAUSING A CRASH, RESULTING IN SERIOUS INJURY OF DEATH TO THOSE INVOLVED.

Manufacturer remedy

DEALERS WILL REPAIR THE UNIT AND REMOVE THE WHEELS, INSPECT THE HUBS, INNER AND OUTER BEARINGS, RACES AND GREASE SEALS. IF NECESSARY, REPLACE PARTS AND REPACK THE WHEEL BEARING WITH HIGH TEMPERATURE GREASE AND REINSTALL THE HUB AND WHEELS. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT AIRSTREAM AT 1-877-596-6505.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2005 Airstream Classic. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

6 owner complaints have been filed with NHTSA for the 2005 Airstream Classic.

Tires

ODI #10156368

Incident: April 19, 2006 · Filed: April 28, 2006

DT*: THE CONTACT STATED UPON INSPECTION OF THE TIRES BLISTERS WERE NOTICED ON THE SIDEWALLS OF ALL FOUR TIRES. THE DEALER HAS BEEN ALERTED

Air Bags

ODI #10132333

Incident: August 11, 2005 · Filed: August 11, 2005

I HAVE SOME COMPLAINTS THAT THE DEALER IS INVESTIGATING. MY MAIN COMPLAINT IS THAT THERE ARE THOUSANDS OF COMPLAINTS LISTED FOR THIS MODEL AND POSSIBLY THIS YEAR ON ANOTHER WEBSITE THAT I ONLY FOUND OUT ABOUT AFTER RECENTLY BUYING MY VEHICLE. I HAVE POSTED A MESSAGE THERE ABOUT THIS SITE SO THAT PEOPLE KNOW ABOUT IT. IT IS: HTTP://FORUMS.CLUBRSX.COM/FORUMDISPLAY.PHP?F=55 ALSO, YOUR SECURE WEBFORM IS BROKEN. YOU CANNOT REPORT AUTOMOBILE COMPLAINTS. *JB

Engine and Engine Cooling; Equipment

ODI #10130370

Incident: April 28, 2005 · Filed: July 27, 2005

DT: THE CONSUMER STATES THAT THERE ARE MECHANICAL DIFFICULTIES WITH THE RV. DEALERSHIP TOLD CONSUMER TO CUT OUT THE CO2 DETECTION. CONSUMER STATES THERE IS A DEFECT IN THE UNIT. THERE IS NO GAS OR CO2 DETECTION IN IT. THE SENSORS HAVE BEEN DISCONNECTED BECAUSE THE ALARMS GO OFF, AND THEY WON'T FIX THE PROBLEM. CONSUMER STATES IN THE MIDDLE OF THE NIGHT THE ALARMS WOULD GO OFF AND THEY COULD NOT SLEEP. HE CONTACTED ALPHA AND THE DEALERSHIP, THEY WILL NOT HELP. THIS STARTED IN APRIL ,AND THEN OCCURRED AGAIN IN JUNE. ABOUT TWO WEEKS AGO, THE PROBLEM BECAME PERSISTENT. IT IS A 2005 ALPHA SEE-YA MOTOR HOME.*AK

Service Brakes, Electric

ODI #10128348

Incident: May 2, 2005 · Filed: July 11, 2005

DT: CONSUMER STATES THAT DUTCHMEN THOR PRODUCES A CAMPER, TAB, AND THEY HAVE AN ALCO BRAKE SYSTEM THAT THEY HAVE MODIFIED. THEY STATE IT HAS NOT BEEN MODIFIED. ACCORDING TO ALCO IN UNITED KINGDOM, THE COMPANY IS SETTING UP THE SYSTEM WRONG ON THE VEHICLE. WHEN HE TRIES TO GET INFORMATION FROM DUTCHMEN THOR THEY SEND HIM THE MANUAL FOR THE GERMAN BRAKE SYSTEM. ON THE TOE SHAFT, THE DAMPENING UNIT, IT IS SUPPOSE TO SLIDE BACK AND HIT AN OVERRUN LEVER THAT IS HOW IT IS BEING SET UP IN THE US. ON THE MANUAL, THERE IS NO CLEARANCE BETWEEN THE TOE SHAFT AND THE OVERRUN LEVER. ON THE UNITS THEY ARE PRODUCING THERE IS 1 5/8 INCH CLEARANCE. THE COMPANY IS NO LONGER CORRESPONDING WITH THE CONSUMER AND THEY ARE NOT OFFERING ANY INFORMATION TO THE DEALERS. THERE IS NO INFORMATION ON HOW MUCH THE CLEARANCE SHOULD BE. THE COMPANY CONTINUES TO REFER HIM TO THE WEBSITE WITH THE GERMAN MANUAL IN IT. *NM

Power Train; Tires

ODI #10127444

Incident: July 5, 2005 · Filed: July 5, 2005

DT: WHILE DRIVING ON INTERSTATE TWO RIGHT TIRES BLEW OUT. THERE WAS NO WARNING, NO BULGE OR NOISE FROM THE TIRES. THE TIRES WERE REPLACED WITH THE SAME TYPE OF TIRES. THEN THE OWNER WAS TOLD BY DEALER THAT THERE WAS A STICKER ON FRONT OF TRAILER WHICH STATED THE TRAILER SHOULD HAVE 225 TIRES ON IT AND THE TRAILER WAS SOLD WITH 205 TIRES ON IT. ALSO, DEALER CLAIMED THAT THE STICKER WAS WRONG. THE MANUFACTURER DID RECOGNIZE THE CONCERN AND SENT THE OWNER BACK TO DEALER. OWNER DID NOT KNOW WHAT TO DO WITH THE TRAILER SINCE THE AXLES WERE BENT, AND WERE DAMAGING THE NEW TIRES. DEALER SAID THE PLY WAS TOO THIN ON THE TIRES. THE OWNER STILL HAD THE OLD TIRES WHICH ONLY HAD 80 MILES ON THEM AT THE TIME OF THE BLOW OUT. *AK

Structure; Tires

ODI #10121418

Incident: April 18, 2005 · Filed: May 19, 2005

DT: TWO CAR HAULER, MID AMERICA MFG., INC. ROUTE 1 BOX 875 BERTRAND, MO. 63823 CUSTOM BUILT TRAILER WHICH HAD VARIOUS SAFETY PROBLEMS SINCE DATE OF PURCHASE. POOR WELDING, TIRES, INAPPROPRIATE LIGHTING, HAND JACK WAS NOT EQUIPPED TO HANDLE WEIGHT LOAD. NO LICENCE PLATE HOLDER. UNDERSIZED WHEEL WELLS. NO SAFETY REFLECTOR. SUSPENSION NOT EQUIPPED FOR WEIGHT LOAD. MANUFACTURER WILL NOT ACKNOWLEDGE THERE IS A PROBLEM. THE TRAILER WAS PURCHASED FROM THE INTERNET. IT WAS PAID FOR IT WITHOUT SEEING IT IN PERSON. ALL PROBLEMS WERE NOTICED AFTER PURCHSASE. MANUFACTURER IS NOT COOPERATIVE IN REPAIRING ANY OF THE PROBLEMS.

Other Airstream Classic model years

Check your 2005 Airstream Classic VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Airstream Classic at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Airstream VIN