NHTSA vehicle safety data

2006 Yamaha YZFR6 Recalls & Complaints

The 2006 Yamaha YZFR6 has 3 NHTSA recall campaigns and 5 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Yamaha dealer.

Includes campaigns NHTSA files under the spelling "YZF-R6".

NHTSA recall and complaint data for the 2006 Yamaha YZFR6. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Yamaha YZFR6 owner complaints

Owners have filed 5 complaints with NHTSA about the 2006 Yamaha YZFR6, describing incidents dated September 14, 2006 to October 5, 2009.

Most-cited components

Unknown or Other 2 complaints
Vehicle Speed Control 2 complaints
Engine 1 complaint
Fuel/Propulsion System 1 complaint
Seats 1 complaint

Of the 5 complaints on file, 1 reports a crash and 1 a fire; across all 5 complaints, owners report 3 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10288709 · Filed October 16, 2009
YAMAHA 450 RHINO SIDE BY SIDE UTV, ACCIDENT INVOLVING LOW SPEED ON ROAD WITH TIP OVER. THE DRIVERS SEAT IS NOT STABLE AND CAME OUT OF BRACKETS. IT IS DESIGNED TO BE SLID OUT FOR STORAGE UNDER SEAT. I BELIEVE THAT I WOULD NOT HAVE BEEN INJURED HAD THE SEAT NOT COME OUT IN A LOW SPEED TIP OVER…
ODI #10193604 · Filed June 18, 2007
TL*THE CONTACT OWNS A 2007 WILDFIRE HY-BIRD SPORT QH200-GY (THE YEAR, MAKE, AND MODEL LISTED WERE UNAVAILABLE IN THE DROP DOWN MENU). THE CONTACT STATED THAT THE MOTOR MOUNT FAILED. THE FAILURE CAUSED THE CHAIN TO COME OUT THE BACK SPROCKET, WHICH THEN CAUSED THE SPROCKET TO BECOME SCRAPED AND…
ODI #10183150 · Filed February 21, 2007
TL*- THE CONTACT OWNS A 2006 YAMAHA R6 WITH AN ODOMETER READING OF 1,000 MILES. THE CONTACT STATED THAT WHILE GOING AROUND A CURVE AT 40 MPH AND SHIFTING INTO THIRD GEAR THE THROTTLE FROZE IN AND OPEN POSITION AND THE MOTORCYCLE STARTED TO RAISE UP. THE CONTACT PUSHED THE MOTORCYCLE TO THE SIDE…

Read all 5 complaints

FRONT SIDE REFLECTOR HEIGHT

NHTSA #10V365000 · Exterior Lighting · NHTSA notice

Reported August 5, 2010 · YAMAHA MOTOR CORPORATION, USA

Potentially affected: 53,449 vehicles

Owners notified August 12, 2010 · Vehicles built August 1, 2005 – March 31, 2010 (per NHTSA)

Defect description

YAMAHA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 YZF-R6 MOTORCYCLES MANUFACTURED FROM AUGUST 2005 THROUGH MARCH 2010. THE MOTORCYCLE'S FRONT SIDE REFLECTOR WAS NOT PLACED AT THE PROPER HEIGHT WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

VISIBILITY OF THE MOTORCYCLE WILL BE DECREASED, POSSIBLY INCREASING THE RISK OF A CRASH.

Manufacturer remedy

YAMAHA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE MOTORCYCLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 12, 2010. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AIR FILTER ELEMENT

NHTSA #06V442000 · Vehicle Speed Control · NHTSA notice

Reported November 2, 2006 · YAMAHA MOTOR CORPORATION, USA

Potentially affected: 13,000 vehicles

Yamaha campaign M2006-018R · Owners notified November 29, 2006 · Vehicles built May 1, 2005 – July 31, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, THE AIR FILTER MOUNTING SCREWS MAY COME LOOSE AND FALL OUT.

Safety consequence

IF THE SCREWS FALL OUT, THEY COULD GET CAUGHT IN THE THROTTLE VALVE WHICH COULD PREVENT THE OPERATOR FROM REDUCING ENGINE SPEED PROPERLY. THIS COULD RESULT IN A LOSS OF CONTROL AND A VEHICLE CRASH WITH INJURY OR DEATH.

Manufacturer remedy

DEALERS WILL REPLACE THE AIR FILTER ELEMENT WITH A NEW ONE THAT IS DESIGNED TO HOLD THE SCREWS SECURELY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 29, 2006. OWNERS MAY CONTACT YAMAHA AT 714-761-7842.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

MOTORCYCLE FRONT BRAKE LEVERS

NHTSA #06E035000 · Service Brakes, Hydraulic · NHTSA notice

Reported May 2, 2006 · CONSTRUCTORS RACING GROUP, LLC

Potentially affected: 1,611 vehicles

Owners notified May 22, 2006

Defect description

CERTAIN CRG FRONT BRAKE LEVERS, MODEL RB-511 DESIGNED FOR USE ON 2004-2006 YAMAHA YZF-R1 MOTORCYCLES, AND 2005-2006 YAMAHA YZF-R6 MOTORCYCLES. MODEL RB-512 IS DESIGNED FOR USE ON 2003-2006 DUCATI 749 AND 999 MOTORCYCLES, AND ON 2004-2006 APRILIA MILLE R MOTORCYCLES. DUE TO A MISALIGNMENT OF THE PIVOT BORE, THE BRAKE LEVER COULD BECOME SEIZED IN THE BRAKE ENGAGED POSITION, THEREBY PREVENTING THE FRONT BRAKE FROM DISENGAGING.

Safety consequence

A NON-RELEASE CONDITION COULD CAUSE DRAG ON THE FRONT BRAKE SYSTEM, WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

CRG WILL NOTIFY OWNERS AND REPLACE THE ROCKER FOR THE FRONT LEVER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2006. OWNERS MAY CONCACT CRG AT 831-763-7811.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CRG FRONT BRAKE LEVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON MOTORCYCLES MANUFACTURED BY YAMAHA, DUCATI, OR APRILIA.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Yamaha YZFR6. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

5 owner complaints have been filed with NHTSA for the 2006 Yamaha YZFR6.

Seats

ODI #10288709

1 injury

Incident: October 5, 2009 · Filed: October 16, 2009

YAMAHA 450 RHINO SIDE BY SIDE UTV, ACCIDENT INVOLVING LOW SPEED ON ROAD WITH TIP OVER. THE DRIVERS SEAT IS NOT STABLE AND CAME OUT OF BRACKETS. IT IS DESIGNED TO BE SLID OUT FOR STORAGE UNDER SEAT. I BELIEVE THAT I WOULD NOT HAVE BEEN INJURED HAD THE SEAT NOT COME OUT IN A LOW SPEED TIP OVER. YAHMAHA SHOULD HAVE DESIGNED SEAT TO BE STABLE AND SECURED TO THE FRAME AND BODY OF VEHICLE. *TR

Unknown or Other

ODI #10193604

Incident: May 12, 2007 · Filed: June 18, 2007

TL*THE CONTACT OWNS A 2007 WILDFIRE HY-BIRD SPORT QH200-GY (THE YEAR, MAKE, AND MODEL LISTED WERE UNAVAILABLE IN THE DROP DOWN MENU). THE CONTACT STATED THAT THE MOTOR MOUNT FAILED. THE FAILURE CAUSED THE CHAIN TO COME OUT THE BACK SPROCKET, WHICH THEN CAUSED THE SPROCKET TO BECOME SCRAPED AND SCRATCHED. THE DEALER STATED THAT NOTHING COULD BE DONE. THE ENGINE SIZE, POWERTRAIN, # OF CYLINDERS, AND A VALID VIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 69.

Vehicle Speed Control; Unknown or Other

ODI #10183150

Crash Fire 1 injury

Incident: September 21, 2006 · Filed: February 21, 2007

TL*- THE CONTACT OWNS A 2006 YAMAHA R6 WITH AN ODOMETER READING OF 1,000 MILES. THE CONTACT STATED THAT WHILE GOING AROUND A CURVE AT 40 MPH AND SHIFTING INTO THIRD GEAR THE THROTTLE FROZE IN AND OPEN POSITION AND THE MOTORCYCLE STARTED TO RAISE UP. THE CONTACT PUSHED THE MOTORCYCLE TO THE SIDE, CRASHED, AND THE MOTORCYCLE CAUGHT ON FIRE. THE CONTACT LATER RECEIVED THE RECALL 06V442000 WHICH WAS THE NOTED THE SAME FAILURE AS THE CONTACTS VEHICLE HAD RIGHT BEFORE THE CRASH. THE CONTACT CALLED THE MANUFACTURER, BUT SINCE THE MOTORCYCLE HAD BEEN DESTROYED DUE TO THE FIRE THEY TOLD THE CONTACT THAT THE BURDEN OF PROOF WAS ON HIM THAT THE CRASH WAS A RESULT OF THE RECALL . THE CONSUMER STATES THAT THE POLICE REPORT STATED HER SON POPPED A WHEELIE THAT WAS NOT A CORRECT STATEMENT HE GAVE. THE CONSUMER STATED HER SON SAID WHEN HE SHIFTED TO THIRD GEAR IT CAME UP ON THE BACK TIRE AND KEPT COMING BACK AND HE KICKED IT AWAY FROM HIM. THE CONSUMER STATES THAT IS WHY HE WOULD NOT SIGN THE POLICE REPORT, HOWEVER THE POLICE REPORT STATES VICTIM INJURED UNABLE TO SIGN. THE CONSUMER ALSO HAS PICTURES OF THE MOTORCYCLE AND THE POLICE REPORT. UPDATE 4/23/07 *TR

Vehicle Speed Control

ODI #10178125

1 injury

Incident: October 30, 2006 · Filed: January 8, 2007

MY THROTTLE GOT STUCK OR IT FELT AS IT DID , I WASN'T ABLE TO STOP I HELD THE BRAKES BUT COULDN'T STOP , AFTER THAT I STARTED GETTING SCARED I HIT THE KILL SWITCH NOTHING THE BIKE STAYED ON ,ALL I THOUGHT WAS JUMPING OFF SO I DID , IT REALLY SCARED ME , WHEN I JUMPED I GOT A KNEE INJURY. *NM

Engine and Engine Cooling; Fuel System, Gasoline

ODI #10177707

Incident: September 14, 2006 · Filed: January 3, 2007

2006 YAMAHA YZF-R6 ENGINE SHUTS OFF WITHOUT WARNING FOR NO APPARENT REASON. APPROXIMATELY 6000 MILES ON ODOMETER. FUEL PUMP AND TPS REPLACED. STILL SPORADICALLY SHUTS OFF. *JB

Other Yamaha YZFR6 model years

Check your 2006 Yamaha YZFR6 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Yamaha YZFR6 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Yamaha VIN