2006 Yamaha FJR1300A Recalls & Complaints

Incident: August 12, 2016 · Filed: August 19, 2016

BIKE LOST HEADLIGHTS (AGAIN). I'VE HAD ELECTRICAL FIXES UNDER RECALL AND THIS CONTINUES. HAD IGNITION REPLACED, GROUND FAULT WORK DONE, ENTIRE WIRING HARNESS REPLACED AND NOW IT HAS LEFT ME STRANDED AGAIN WITHOUT LIGHTS. THIS IS A DANGEROUS SITUATION TO LOSE YOUR HEADLIGHTS. ITS A KNOWN RECURRENT PROBLEM WITH THIS BIKE. HIGH BEAM INDICATOR STAYS ON, STRANGE FLASHING TURN SIGNAL INDICATORS REMAIN ON, NO WINDSHIELD MOTOR CONTROL, NO HEADLIGHTS, NO HIGH OR LOW BEAM. YAMAHA NEEDS TO COME UP WITH PROPER FIX FOR THIS DANGEROUS SITUATION. A QUICK READ ON THE FJR1300 FORUM SHOWS THIS RECURRENT PROBLEM IS HITTING MANY.

Incident: February 17, 2016 · Filed: March 2, 2016

I COMMUTE ON MY MOTORCYCLE NEARLY EVERY DAY THROUGHOUT THE YEAR. THIS IS THE REASON I HAVE A MOTORCYCLE. MY WORK START TIME IS AT 5:30AM SO I COMMUTE TO WORK IN THE DARK YEAR ROUND. I ALSO TRAVEL A SECTION OF ROAD THAT TAKES ME THROUGH A 6 MILE CANYON THAT HAS NO STREET LIGHTING SO THE ROAD IS COMPLETELY DARK AND HAS MANY TURNS WHILE TRAVELING AT NEAR THE 65MPH SPEED LIMIT. TWO WEEKS AGO WHILE TRAVELING THIS SECTION I FLIPPED THE HEADLIGHT BRIGHTS SWITCH WHICH CAUSED MY HEADLIGHTS TO GO COMPLETELY OUT. FLIPPING THE SWITCH BACK TO NORMAL LIGHTS DID NOT TURN THEM BACK ON. AFTER A FEW SECONDS THE LIGHTS CAME BACK ON. THIS HAPPENED THREE TIMES DURING DOWN THE CANYON AND TWICE MORE UNTIL I GOT TO WORK. I WAS VERY LUCKY I DIDN'T CRASH OR GET INJURED. LUCKILY, A CAR WAS POSITIONED A LITTLE AHEAD OF ME WHICH ALLOWED ME TO KNOW WHERE THE ROAD WAS DUE TO THE CAR'S TAIL LIGHTS. I WAS ABLE TO RIDE HOME IN THE DAYLIGHT. I TESTED THE HEADLIGHTS AT HOME AND FOUND THAT A RELAY WAS BUZZING SO I THOUGHT THAT WAS THE CAUSE. UNFORTUNATELY, SWAPPING FOR A DIFFERENT RELAY DID NOT FIX THE ISSUE. I EVENTUALLY LOCATED A CONNECTOR WITH A SPIDER GROUNDING POLE THAT HAD A BURNT MARK. TAKING IT APART SHOWED THE CAUSED. ONE OF THE WIRES NO LONGER HAD GOOD CONTACT DUE TO AN OVERLOAD OF THE CONNECTOR. I'M ATTACHING A PICTURE. THERE'S A RECALL DUE TO ANOTHER ONE OF THESE CONNECTORS AND IT WAS COMPLETED A WHILE AGO. MY RECENT ISSUE IS NOT ADDRESSED BY NHTSA CAMPAIGN NUMBER: 11V-338. MY FAULTY CONNECTOR IS S6 NOT THE S4 FROM THE RECALL. I'VE READ THAT MANY OTHERS HAVE HAD ISSUES WITH THE SAME CONNECTOR AND IF FUTURE RIDERS HAVE A SIMILAR PROBLEM AS MINE WE ARE CERTAINLY LOOKING AT A MAJOR SAFETY ISSUE.

Incident: February 19, 2014 · Filed: February 23, 2014

HEADLIGHTS FAILED WITHOUT WARNING. POTENTIALLY LIFE THREATENING AS THIS OCCURRED WHILE UNDERWAY AT NIGHT. THE DEFECT OCCURRED IN WHAT IS KNOWN AS THE S6 SPIDER - A SPIDER BEING A GROUND WIRE COLLECTOR CIRCUIT ON THE VEHICLE. THE VEHICLE HAS ALREADY BEEN RECALLED FOR OTHER SPIDER FAILURES, BUT THE SPIDER AFFECTED BY THIS PROBLEM WAS NOT AMONG THE ONES DEALT WITH. *TR

Incident: October 16, 2012 · Filed: November 11, 2013

HAD THE RECALL DONE ON THIS BIKE PER THE RECALL LETTER. ON OCT 18 2012 LOST ALL LIGHTS...WHEN I WAS ABLE TO GET BIKE HOME FOUND A GROUND CONNECTOR HAD MELTED. THE FIX BY YAMAHA DO NOT (THE BIKE NEEDS A NEW WIRE HARNESS NOT A JUMPER. *TR

Incident: May 26, 2012 · Filed: May 30, 2012

RIDING IN WESTERN VIRGINIA, ON A WARM SATURDAY AFTERNOON, I NOTICED MY TURN SIGNAL INDICATOR LIGHTS WERE BOTH ON, AND FLASHED WEIRDLY WHEN I USED THEM. I ALSO LOST THE ELECTRIC ADJUSTABLE WINDSHIELD, AND DISCOVERED WHEN I STOPPED THAT I HAD NO HEADLIGHTS. THIS WAS PAINFUL BECAUSE THE RIDE I WAS ON INVOLVED A LOT OF NIGHT TIME RIDING. LUCKILY THIS HAPPENED DURING THE DAY AND I WAS ABLE TO USE MY AUXILIARY LIGHTS THAT NIGHT. UPON DIS-ASSEMBLY, A GROUND SPIDER (S6) UNDER THE NOSE OF THE BIKE, NOT COVERED OR INSPECTED BY THE CURRENT RECALL WAS BURNED TO A CRISP. THIS WOULD HAVE BEEN REALLY BAD HAD I LOST MY LIGHTS AT SPEED, AT NIGHT ON A TWISTY MOUNTAIN ROAD. *TR

Incident: August 3, 2010 · Filed: June 5, 2011

AUG. 3RD 2010 WHILE DRIVING NORTH ON CA 101 AT ABOUT 4:00 PM IN HEAVY RUSH HOUR TRAFFIC , THE ENGINE STOPPED DEAD. IT WOULD NOT RESTART. IT WAS TOWED TO THE NEAREST YAMAHA SHOP WHERE IT WAS DIAGNOSED AND REPAIRED. THE PROBLEM WAS FOUND TO BE A BAD GROUND CONNECTION(SPYDER). THE CONNECTOR WAS REMOVED AND THE WIRES WERE SOLDERED TOGETHER AT THE YAMAHA DEALERSHIP . I HAVE THE CONNECTOR AND GAVE IT TO MY LOCAL DEALERSHIP . THEY WERE NOT AWARE OF THE PROBLEM AND WERE NOT CONCERNED ABOUT THE SAFETY FACTOR ( DRIVING IN RUSH HOUR TRAFFIC AT SPEED AND TO HAVE THE ENGINE JUST STOP ). *TR

Incident: April 3, 2011 · Filed: April 24, 2011

TOTAL LOSS OF POWER AND CONTROL WITH FAILURE OF THE MOTORCYCLE GROUNDING HARNESS SYSTEM. *TR

Incident: March 4, 2011 · Filed: April 3, 2011

MY MOTORCYCLE STOPPED RUNNING TWICE WHILE RIDING DOWN A LOCAL HIGHWAY. THE ENGINE BRIEFLY SHUT OFF FOR A FEW SECONDS BEFORE STARTING BACK UP AND RUNNING NORMALLY. WHEN IT DID SO A NUMBER OF LIGHTS CAME ON THE DASH WHILE THE ENGINE WAS OFF, INCLUDING HIGH-BEAM INDICATOR, EMERGENCY FLASHERS, AND THE SPEEDO AND TACH STOPPED WORKING. LATER THE SAME DAY I STOPPED TO FUEL UP AND THE BIKE WOULD NOT START, AND ALL THE SAME DASH LIGHTS WERE ON (EVEN THOUGH THE EMERGENCY FLASHERS WERE NOT FLASHING AND HIGH-BEAMS WERE NOT ON. THE MOTORCYCLE WAS TOWED HOME. I LATER REPAIRED IT. THE CAUSE OF THE FAILURE WAS A MELTED GROUND CIRCUIT CONNECTOR, CAUSED BY AN OVERLOAD ON THE CIRCUIT. I REPAIRED IT BY RUNNING AN ADDITIONAL GROUND WIRE TO THE FRAME TO OFFLOAD PART OF THE CURRENT. *TR

Incident: October 20, 2010 · Filed: October 30, 2010

ELECTRICAL POWER CUTOUT. NO POWER TO STARTER, MULTIPLE DASH LIGHTS ON, FLASHING FUEL METER INDICATOR, TURN SIGNAL INDICATORS, ETC. NOT A BURNED OUT FUSE BUT RATHER A FRIED GROUND POINT ON THE WIRING HARNESS. THIS IS BEING REPORTED VERY OFTEN ON THE FJR FORUM. MY SHOP TOOK PIX AND SENT TO YAMAHA TO SEE WHAT THEY WILL DO ABOUT IT. GROUND POINT CONNECTOR GETS CORRODED, LOSES GROUND, OVERHEATS AND FRIES CIRCUITS. IF THIS HAPPENS WHEN YOU ARE RIDING, YOU WILL LOSE ALL POWER AND THE ENGINE WILL DIE. *TR

Incident: September 25, 2010 · Filed: September 28, 2010

AFTER STARTING MY MOTORCYCLE FOR THE FIRST TIME THAT DAY, MY WIFE AND I RODE IT .9 MILES WHEN THE ENGINE QUIT RUNNING. I WAS MIDWAY THROUGH A STEEP, DOWNHILL LEFT TURN WHEN I LOST POWER. I STOPPED THE BIKE USING A COMBINATION OF FRONT AND REAR BRAKES, STOPPING AT THE STOP SIGN AT THE BOTTOM OF THE HILL. SEVERAL OF THE LIGHTS ON THE INSTRUMENT CLUSTER WERE ILLUMINATED. BOTH TURN SIGNAL INDICATOR LIGHTS WERE LIT WITHOUT FLASHING. THE LCD FUEL GAUGE WAS FLASHING. THE HIGH BEAM INDICATOR LIGHT WAS ILLUMINATED. THE BIKE'S HEADLIGHTS WERE NOT ILLUMINATED. THE HORN DID NOT WORK. THESE SYMPTOMS HAVE BEEN REPORTED BEFORE ON FJRFORUM.COM AS I WAS 150 MILES FROM HOME, I MADE A PHONE CALL TO A FRIEND AND ASKED HIM TO GO ON FJRFORUM.COM AND FIND THE CAUSE OF THE PROBLEM. FOLLOWING THE DESCRIPTIONS AND PHOTOS OFFERED ON THE FORUM, I WAS ABLE TO LOCATE A MELTED CONNECTOR. IT IS KNOWN AS A "GROUND SPIDER". AFTER REMOVING THE GROUND SPIDER, CLEANING IT AND REINSTALLING IT, I WAS ABLE TO GET THE BIKE RUNNING. THE BIKE RAN NORMALLY FOR 4 OR 5 MILES BEFORE THE SAME PROBLEM RETURNED. KNOWING WHAT TO LOOK FOR, I AGAIN PARTIALLY DISASSEMBLED THE BIKE TO AGAIN HAVE ACCESS TO THE GROUND SPIDER. THIS TIME, I CUT THE MELTED PLASTIC OFF THE LUGS, EXPOSING THEM AND USED UTILITY WIRE TO BIND THEM TOGETHER. THE BIKE RAN NORMALLY AFTER THAT. I WAS ABLE TO RIDE THE BIKE HOME. I WOULD LIKE YAMAHA TO CORRECT THIS DESIGN FLAW. THE PROBLEM IS WELL DOCUMENTED. SOME VERY INTELLIGENT FJR OWNERS HAVE TRIED TO MAKE THE BEST OF THIS SITUATION. YAMAHA COULD EASILY USE THE INFORMATION GENEROUSLY SHARED ON FJRFORUM.COM TO CORRECT THEIR PROBLEMATIC WIRING HARNESS. *TR