NHTSA vehicle safety data

2001 Winnebago Journey DL Recalls & Complaints

The 2001 Winnebago Journey DL has 2 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Winnebago dealer.

NHTSA recall and complaint data for the 2001 Winnebago Journey DL. Recall data is refreshed daily from NHTSA.

2001 Winnebago Journey DL owner complaints

Owners have filed 4 complaints with NHTSA about the 2001 Winnebago Journey DL, describing incidents dated May 12, 2003 to July 17, 2004.

Most-cited components

Tires 3 complaints
Service Brakes 1 complaint

Newest complaints

ODI #10118997 · Filed April 18, 2005
TIRE SEPARATION ON 2001 WINNEBAGO JOURNEY DL.***NO ANSWER REQUIRED***.*MR THE CONSUMER HAD THREE INCIDENTS OF TIRE BLOWOUTS. IN EACH CASE THE TIRE BLEWOUT THOUGH THE SIDEWALL. THESE FAILURES OCCURRED AT 28520, 34321 AND 37012. ( TWO TIRES HAD DOT NUMBER B6BJBVJX3001 AND ONE HAD B6BJBVJX2000). *NM
ODI #10093445 · Filed October 1, 2004
THREE OF FOUR REAR TIRES ON MY MOTOR HOME HAVE BLOWN OUT IN THE PAST YEAR. THE MOTOR HOME IS A 2001 WINNEBAGO ON A FREIGHTLINE CHASSIS WITH MICHELIN TIRES. ALL OF THE BLOWOUTS HAVE BEEN IN THE SAME FASHION. THIS HAPPENED WITH MILEAGE OF 25,000-27,000 ON UNIT.*AK
ODI #10083009 · Filed July 30, 2004
TOTAL LOSS OF AIR PRESSURE ON OUR 2001 WINNEBAGO JOURNEY DL DUE TO THE BLOW-OUT OF TWO SMALL AIR TUBES ON THE ENGINE AIR COMPRESSOR. THESE TUBES ARE 3 TO 31/2 IN. LONG X 1/4 IN. IN DIAMETER. THESE TUBES ARE MADE OF PLASTIC AND SHOULD NOT BE USED TO CONTROL BRAKING SYSTEMS FOR A 26,000LB VEHICLE. *AK

Read all 4 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

WINNEBAGO/LP LINE FASTENERS

NHTSA #01V260000 · Fuel System, Other — Storage — Tank Assembly — Mounting · NHTSA notice

Reported August 15, 2001 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,292 vehicles

Owners notified August 24, 2001 · Vehicles built April 28, 1999 – May 11, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: MOTOR HOMES (MODELS WKP36L, WKP36LD, AND IKP36LD). FOUR NUTS MAY HAVE LOOSENED FROM THE FOUR BOLTS THAT CONNECT THE LIQUID PROPANE (LP) TANK TO THE MOTOR HOME. IF THE ATTACHMENT HARDWARE IS LOOSENED, THE ROAD VIBRATION COULD PRODUCE UNDUE STRESS ON THE WELD JOINTS OF THE BRACKETS AND THEY COULD BREAK.

Safety consequence

IF THIS HAPPENS, THE TANK COULD FALL OFF, RESULTING IN A ROAD HAZARD OR A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE LP TANK ATTACHMENT AND RE-TIGHTENED THE FASTENERS IN ADDITION TO ADDING LOCK NUTS. OWNER NOTIFICATION BEGAN AUGUST 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2001 Winnebago Journey DL. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2001 Winnebago Journey DL.

Tires

ODI #10118997

Incident: July 17, 2003 · Filed: April 18, 2005

TIRE SEPARATION ON 2001 WINNEBAGO JOURNEY DL.***NO ANSWER REQUIRED***.*MR THE CONSUMER HAD THREE INCIDENTS OF TIRE BLOWOUTS. IN EACH CASE THE TIRE BLEWOUT THOUGH THE SIDEWALL. THESE FAILURES OCCURRED AT 28520, 34321 AND 37012. ( TWO TIRES HAD DOT NUMBER B6BJBVJX3001 AND ONE HAD B6BJBVJX2000). *NM

Tires

ODI #10093445

Incident: January 24, 2004 · Filed: October 1, 2004

THREE OF FOUR REAR TIRES ON MY MOTOR HOME HAVE BLOWN OUT IN THE PAST YEAR. THE MOTOR HOME IS A 2001 WINNEBAGO ON A FREIGHTLINE CHASSIS WITH MICHELIN TIRES. ALL OF THE BLOWOUTS HAVE BEEN IN THE SAME FASHION. THIS HAPPENED WITH MILEAGE OF 25,000-27,000 ON UNIT.*AK

Service Brakes, Air

ODI #10083009

Incident: July 17, 2004 · Filed: July 30, 2004

TOTAL LOSS OF AIR PRESSURE ON OUR 2001 WINNEBAGO JOURNEY DL DUE TO THE BLOW-OUT OF TWO SMALL AIR TUBES ON THE ENGINE AIR COMPRESSOR. THESE TUBES ARE 3 TO 31/2 IN. LONG X 1/4 IN. IN DIAMETER. THESE TUBES ARE MADE OF PLASTIC AND SHOULD NOT BE USED TO CONTROL BRAKING SYSTEMS FOR A 26,000LB VEHICLE. *AK

Tires

ODI #10019152

Incident: May 12, 2003 · Filed: May 23, 2003

(2) SEPERATE BLOW OUTS.LEFT REAR INNER DUAL, AND THE RIGHT REAR OUTER DUAL TIRE. THE FIRST BLOW OUT WAS LAST NOVEMBER APPROX. 6,000 MILES TIRE,SECOND BLOW OUT WAS ON MAY 12, 2003 APPROX.9,000 MILES ON TIRE.TIRES ARE DATED 2000, ALSO MH. WAS NOT OVERWEIGHT AT ANY TIME. T IRE PRESSURE WAS 90LBS. FRONT,100LBS REARS. TIRE BRAND: MICHELIN XRV 235/80 22.5 RIMS IT APPEARS THESE TIRES DEFECTIVE AND UNSAFE. ALTHOUGH THE TIRES HAVE LOW MILAGE ON THEM I AM GOING TO REPLACE WITH ANOTHER BRAND. WE WERE LUCKY THE BLOW OUTS WERE NOT ON THE FRONT TIRES. I HAVE THE CERTIFIED SCALE WEIGHTS OF EACH AXLE AND TOTAL WIEGHT, I CAN FORWARD THEM TO YOU IF NEEDED .

Other Winnebago Journey DL model years

Check your 2001 Winnebago Journey DL VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Winnebago Journey DL at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Winnebago VIN