NHTSA vehicle safety data

2004 Winnebago Itasca Spirit Recalls & Complaints

The 2004 Winnebago Itasca Spirit has 1 NHTSA recall campaign and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Winnebago dealer.

NHTSA recall and complaint data for the 2004 Winnebago Itasca Spirit. Recall data is refreshed daily from NHTSA.

2004 Winnebago Itasca Spirit owner complaints

Owners have filed 1 complaint with NHTSA about the 2004 Winnebago Itasca Spirit, describing incidents dated July 11, 2008.

Most-cited components

Service Brakes 1 complaint

Newest complaints

ODI #10246028 · Filed October 19, 2008
REAR BRAKES FAILED AFTER DRIVING 31 MILES FROM HOME. TOLD IT WAS A COMMON OCCURRENCE ON WORKHORSE CHASSIS. REAR BRAKES WERE REPLACED, AND FRONT BRAKES SERVICED. DROVE ANOTHER 30 MILES AND THEN THE FRONT BRAKES FAILED. AM CONCERNED THAT IF I CONTINUE DRIVING THIS UNIT I MAY HAVE FURTHER PROBLEMS…

Read the full complaint

FUEL TANK STRAPS

NHTSA #05V475000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported October 13, 2005 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 3,613 vehicles

Owners notified October 14, 2005 · Vehicles built April 12, 2004 – July 17, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.

Safety consequence

IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2004 Winnebago Itasca Spirit. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2004 Winnebago Itasca Spirit.

Service Brakes, Hydraulic

ODI #10246028

Incident: July 11, 2008 · Filed: October 19, 2008

REAR BRAKES FAILED AFTER DRIVING 31 MILES FROM HOME. TOLD IT WAS A COMMON OCCURRENCE ON WORKHORSE CHASSIS. REAR BRAKES WERE REPLACED, AND FRONT BRAKES SERVICED. DROVE ANOTHER 30 MILES AND THEN THE FRONT BRAKES FAILED. AM CONCERNED THAT IF I CONTINUE DRIVING THIS UNIT I MAY HAVE FURTHER PROBLEMS. THIS SOUNDS LIKE A MANUFACTURING PROBLEM.

Other Winnebago Itasca Spirit model years

Check your 2004 Winnebago Itasca Spirit VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Winnebago Itasca Spirit at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Winnebago VIN