2012 Volvo XC70 Recalls & Complaints

Incident: June 27, 2022 · Filed: June 27, 2022

Windshield leaking for about 2 tears got worse and was found to be "loose windshield and mobile" and "hazardous" by technician.

Incident: November 20, 2021 · Filed: December 5, 2021

Windshield seal leaking at top. This started a few weeks ago, I noticed water drips run down the inside of the windshield in front of the driver. I took a 4-hour trip last week and it rained for 30 minutes, the leak became worst causing me to need to wipe the inside of the windshield. Yesterday, I went through the car wash and water pour down onto the dashboard, instrument cluster, steering wheel, and airbag. I have to get paper towels and dry things before I could drive. Today, I drove to the grocery in light rain, not a big problem when driving at speed however when going slower or braking water runs down the inside of the windshield. I now carry a small towel to wipe and dry the windshield. This is affecting the visibility and safety of driving the car.

Incident: June 1, 2016 · Filed: December 10, 2020

THE SEAL FOR THE WINDSHIELD HAS FAILED ALONG THE TOP PASSENGER SIDE. FROM THE INSIDE OF THE VEHICLE, ONE CAN PUSH THE WINDSHIELD ENOUGH TO SEE A GAP. WATER ENTERS WHEN RAINING; I BELIEVE THIS IS ALSO A SAFETY ISSUE IS THE SEAL COMPLETELY FAILS. IT STARTED AT ABOUT 55 MONTHS AFTER DELIVERY AND 24,000 MILES.

Incident: October 2, 2020 · Filed: October 3, 2020

WHILE DRIVING, THE FRONT PASSENGER DOOR HAS UNLATCHED AND THE DOOR OPENS SLIGHTLY ON AT LEAST 5 OCCASIONS. THIS HAS OCCURRED ONCE WHEN DRIVING ON THE HIGHWAY AND 4 OCCASIONS WHILE DRIVING ON CITY STREETS. THE AUTOMATIC LOCKING SYSTEM TRIES TO LOCK ALL DOOR AND THE SYSTEM SIGNALS THE DOOR IS OPEN. I STOP THE CAR AS SOON A POSSIBLE, PARK AND WALK AROUND TO THE PASSENGER DOOR TO FIND THE DOOR HANDLE LOCKED. THE LOCKING SYSTEM SEEMS TO BE WORKING BUT THE LATCH IS FAILING. I TOOK THE CAR TO THE DEALERSHIP AND THEY HAD ME ORDER A PART # 31253662-LOCK. THE DEALER STATED THIS WAS NOT COVERED BY WARRANTY OR RECALL. I CONSIDER THIS A SAFETY ISSUE AND INSIST THIS IS A RESPONSIBILITY OF THE MANUFACTURER. I FOUND A RECALL FOR OTHER VOLVO MODELS WITH THE SAME ISSUE BUT THIS DOES NOT COVER MY VEHICLE.

Incident: March 16, 2020 · Filed: March 16, 2020

THE STEERING WHEEL STICKS AND HESITATES AND WON'T TURN. THEN IT FINALLY DOES. SOMETIMES IT SEEMS WORSE WHEN COLD. IT HAS HAPPENED MANY TIMES. I HAVE TAKEN IT TO MANY DEALERS AND MECHANICS AND THEY CAN'T FIGURE IT OUT. JUST RECENTLY PULLING OUT OF MY DRIVEWAY, I WAS USING THE GAS, AND IT WOULD NOT TURN AND I THOUGHT I WAS GOING TO HIT A TREE. ANOTHER TIME WHILE DRIVING N A ROTARY IT FROZE. MANY TIMES WHILE TURNIING INTO A PARKING PLACE IT LOCKS UP.

Incident: December 25, 2019 · Filed: December 27, 2019

TL* THE CONTACT OWNS A 2012 VOLVO XC70. WHILE THE CONTACT WAS DRIVING IN THE RAIN, WATER WAS ENTERING THE VEHICLE. THE CONTACT DISCOVERED THE WINDSCREEN FAILED AND CAUSED THE FRONT WINDSHIELD TO BECOME UNSECURED. THE VEHICLE WAS TAKEN TO VOLVO OF MONTEREY IN SEASIDE, CA WHERE IT WAS DIAGNOSED THAT THE WINDOW SEAL WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

Incident: May 23, 2019 · Filed: May 30, 2019

TL* THE CONTACT OWNS A 2012 VOLVO XC70. WHILE DRIVING 30 MPH AND APPROACHING A STOP LIGHT, THE CONTACT HEARD A LOUD ABNORMAL NOISE BEFORE SHE DEPRESSED THE BRAKE PEDAL AND THE VEHICLE FAILED TO STOP. THE CONTACT STATED THAT THE VEHICLE SLOWED DOWN A BIT, BUT CONTINUED TO MOVE FORWARD. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL TO THE FLOORBOARD TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO VOLVO CARS SILVER SPRING (LOCATED AT 3121 AUTOMOBILE BLVD, SILVER SPRING, MD 20904, (301) 890-6200) WHERE IT WAS DIAGNOSED THAT BOTH REAR BRAKE ROTORS AND BOTH REAR CALIPERS WERE NOT THE CORRECT PARTS FOR THE VEHICLE. IN FEBRUARY OF 2019, THE VEHICLE WAS TAKEN TO NATIONAL TIRE AND BATTERY TO HAVE THE PARTS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 131,898.

Incident: November 27, 2017 · Filed: December 10, 2017

I NOTICED WATER INTRUSION WHILE VIA THE TOP DRIVER SIDE EDGE OF THE WINDSHIELD DURING A HEAVY RAIN. AT STOP AND UPON INVESTIGATION I NOTICED WHEN APPLYING PRESSURE TO THE UNDERSIDE OF THE WINDSHIELD THE WINDSHIELD WAS SEPARATING FROM THE FRAME ALONG THE TOP OF THE WINDSHIELD. IN DISCUSSING THIS PROBLEM WITH A AUTO GLASS REPLACEMENT SPECIALIST (GLASSDOCTORS) THEY INFORMED ME THAT THEY BEEN FIXING MANY OF THESE ISSUES FOR THE LOCAL VOLVO DEALERSHIP. THE CONCERN FROM A SAFETY STANDPOINT IS THE INTEGRITY OF THE WINDSHIELD IN THE EVENT OF A FRONT END COLLISION. IT SEEMS THAT VOLVO IS NOT INDICATING A RECALL FOR THIS PROBLEM. I QUICK INVESTIGATION OF THE INTERNET INDICATES THAT IT IS A GROWING PROBLEM.

Incident: January 15, 2017 · Filed: March 29, 2017

WATER STREAKING WAS NOTICED ON THE INSIDE OF THE WINDSHIELD IN FRONT OF THE DRIVER'S SEAT. WE CLEANED THE WINDOW IN CASE THE STREAK WAS LEFT FROM A PREVIOUS CLEANING. DURING A RAINSTORM A FRESH DRIP OF WATER WAS MOVING DOWN THE INSIDE OF THE WINDSHIELD. I RESEARCHED THE PROBLEM AND SAW THAT THERE ARE ISSUES WITH THE BONDING OF WINDSHIELDS ON VOLVO CARS SO I PUSHED ON THE WINDOW LIGHTLY FROM THE INSIDE AND SAW THE WINDSHIELD MOVE ABOUT 1/16 INCH ON BOTH SIDES. THERE WAS LITTLE RESISTANCE TO MOVEMENT. THE CAR IS EQUIPPED WITH SENSORS MOUNTED TO THE WINDSHIELD WHICH SERVE TO MAINTAIN FOLLOWING DISTANCE TO OTHER VEHICLES AND ALSO ACT AS SAFETY DEVICES TO AVOID COLLISIONS WITH VEHICLES AND PEDESTRIANS. THIS IS A SAFETY ISSUE SINCE THE AIRBAG PUSHES AGAINST THE INSIDE OF THE WINDSHIELD WHEN DEPLOYED AND AN UNBONDED WINDSHIELD WILL NOT SERVE TO HOLD PASSENGER IN PLACE. IF THE WINDSHIELD IS SEVERELY UNATTACHED IT COULD COME OUT OF THE VEHICLE DURING OPERATION.

Incident: March 14, 2017 · Filed: March 24, 2017

RECENTLY, MY HUSBAND'S VOLVO XC70 BEGAN LEAKING WATER. WE TOOK IT TO OVERLAND PARK VOLVO FOR A DIAGNOSTIC CHECK. THEY STATE THE WINDSHIELD SEAL HAS BROKEN AND THAT IS WHY IT IS LEAKING WATER. IT IS A FACTORY INSTALLED WINDSHIELD. THEY STATED IT IS NOT COVERED UNDER WARRANTY AND THAT A GLASS REPAIR COMPANY WOULD NEED TO FIX IT. SO, WE TOOK IF TO SAFELITE. ALTHOUGH OUT INSURANCE IS COVERING REPLACING THE WINDSHIELD, BECAUSE THEY CANNOT SIMPLY RESEAL IT, SAFELITE STATES THEY DO NOT UNDERSTAND WHY VOLVO DIDN'T COVER IT UNDER THEIR WARRANTY DUE TO DEFECTIVE INSTALLATION. IN ADDITION, THE SERVICE ADVISOR AT THE VOLVO DEALERSHIP ADVISED US AND SAFELITE THAT THE SEALS ROUTINELY BREAK ON VOLVOS AND CAUSE WATER TO LEAK IN THE VEHICLE. THERE IS NO REASON WHY THE SEAL SHOULD NOT LAST THE LIFETIME OF THE WINDSHIELD OR LIFESPAN OF THE VEHICLE, BECAUSE THERE ARE PRODUCTS ON THE MARKET THAT GUARANTEE THIS WILL NOT HAPPEN. WHILE WE ARE FORTUNATE TO HAVE A $0 GLASS DEDUCTIBLE, OTHER VOLVO CUSTOMERS THAT DO NOT HAVE THIS DEDUCTIBLE WILL HAVE TO PAY OUT-OF-POCKET TO REPAIR VOLVO'S DEFECTIVE WORKMANSHIP. IN ADDITION, WATER LEAKING INTO A VEHICLE CAN CAUSE ALL TYPES OF CORROSIVE DAMAGE. IN OUR VEHICLE ALONE, THE WATER LEAKED ALL OVER THE FLOORBOARD, ALL OVER THE LEATHER SEATS, ALL OF THE GEAR SHIFTING MECHANISM, ETC. IF THE WATER WERE TO GO INTO THE GEAR SHIFTING MECHANISM, IT COULD COST THOUSANDS OF DOLLARS IN DAMAGES. SAME GOES FOR COMPONENTS THAT ARE LOCATED UNDER THE FLOOR BOARD. IT COULD ALSO POSE AS A SAFETY HAZARD ON THE HIGHWAY IF THE SEAL IS BROKEN OR IF THE VEHICLE MECHANICALLY FAILS DUE TO CORROSIVE PARTS.