NHTSA vehicle safety data

1997 Volvo WAH Recalls & Complaints

The 1997 Volvo WAH has 5 NHTSA recall campaigns on file as of October 23, 2026. try.vin has no NHTSA owner complaints on file for the 1997 Volvo WAH. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 1997 Volvo WAH. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

VOLVO TRUCKS/ABS ECU

NHTSA #00V232003 · Service Brakes, Air — Antilock · NHTSA notice

Reported August 22, 2000 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 18,362 vehicles

Owners notified December 11, 2000 · Vehicles built November 6, 1997 – August 7, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.

Safety consequence

THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ABS ECU.

Notes

OWNER NOTIFICATION WAS PHASED.FIRST MAILING TO CRITICAL CATEGORY "A" OWNERS BEGAN DECEMBER 11, 2000.ALL OTHER OWNER NOTIFICATION BEGAN FEBRUARY 12, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO TRUCKS/HALDEX/FMVSS 121

NHTSA #00V002002 · Parking Brake · NHTSA notice

Reported February 24, 2000 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 13,516 vehicles

Volvo campaign RVXX0002 · Owners notified March 28, 2000 · Vehicles built June 4, 1997 – February 28, 1998 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HALDEX MANIFOLD DASH VALVES (MDV) USED IN TRACTOR AND TRAILER PARKING BRAKES. THESE VALVES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." A LOSS OF THE ISOLATION OF THE TWO BRAKE SYSTEM CIRCUITS CAN RESULT IN THE LOSS OF SERVICE BRAKES WHEN THERE IS ANOTHER FAILURE OF ONE OF THE TWO BRAKE CIRCUITS.

Safety consequence

THE LOSS OF SERVICE BRAKES CAN OCCUR, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SUSPECT VALVES.

Notes

VOLVO TRUCK RECALL NO. RVXX0002.OWNER NOTIFICATION BEGAN MARCH 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO TRUCKS/AIR SUSPENSION

NHTSA #98V255000 · Suspension — Front — Springs — Air Suspension — Lines and Fittings · NHTSA notice

Reported October 14, 1998 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 95,013 vehicles

Owners notified November 27, 1998 · Vehicles built October 1, 1986 – July 13, 1998 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.

Safety consequence

THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.

Manufacturer remedy

DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.

Notes

OWNER NOTIFICATION BEGAN DURING NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO TRUCK/ACCURIDE/ALUMINUM DUAL WHEELS

NHTSA #98V120001 · Wheels — Rim · NHTSA notice

Reported May 19, 1998 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 3,065 vehicles

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.

Safety consequence

THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.

Manufacturer remedy

ACCURIDE/AKW WILL REPLACE THESE WHEELS.

Notes

ACCURIDE/AKW WILL CONDUCT THE OWNER NOTIFICATION AND REMEDY CAMPAIGN FOR THIS RECALL.OWNER NOTIFICATION BEGAN JULY 27, 1998. OWNERS WHO DO NOT HAVE THEIR WHEELS REPLACED FREE WITHIN A REASONABLE TIME SHOULD CONTACT ACCURIDE/KAISER AT 1-888-665-9189 OR VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO TRUCK/FRONT AXLE WHEEL

NHTSA #97V212000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported November 17, 1997 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 923 vehicles

Owners notified December 17, 1997 · Vehicles built October 1, 1997 – October 20, 1997 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE STEER AXLE WHEEL BEARING JAM NUT LOCK WASHER MAY NOT HAVE BEEN BENT OVER THE JAM NUT AFTER THE WHEEL BEARINGS WERE ADJUSTED.

Safety consequence

IF THIS CONDITION EXISTS, THE JAM NUT AND WHEEL BEARING ADJUSTING NUT CAN BACK OFF THE SPINDLE ALLOWING THE WHEEL AND THE BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE STEERING AXLE WHEEL BEARING JAM NUT LOCK WASHER TO DETERMINE IF IT IS BENT OVER THE JAM NUT, AND IF NOT, REPAIR AS REQUIRED.

try.vin has no NCAP crash-test rating on file for the 1997 Volvo WAH. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

try.vin has no NHTSA owner complaints on file for the 1997 Volvo WAH.

Other Volvo WAH model years

Check your 1997 Volvo WAH VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo WAH at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN