NHTSA vehicle safety data

2000 Volvo Volvo Truck Recalls & Complaints

The 2000 Volvo Volvo Truck has 2 NHTSA recall campaigns and 7 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 2000 Volvo Volvo Truck. Recall data is refreshed daily from NHTSA.

2000 Volvo Volvo Truck owner complaints

Owners have filed 7 complaints with NHTSA about the 2000 Volvo Volvo Truck, describing incidents dated October 20, 1999 to June 9, 2011.

Most-cited components

Steering 2 complaints
Tires 2 complaints
Latches/Locks/Linkages 1 complaint
Power Train 1 complaint
Suspension 1 complaint
Vehicle Speed Control 1 complaint

Of the 7 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10415938 · Filed July 26, 2011
2000 VOLVO CONVENTIONAL. UNIT #1 WAS EASTBOUND IN FAR RIGHT LANE. UNIT #1 EXPERIENCED BLOW-OUT ON THE FORWARD DRIVE AXLE, TANDEM, ON PASSENGER SIDE OF CAB, CAUSING DAMAGE TO FUEL TANK, FIBERGLASS BODY, AND MUD FLAP ASSEMBLY. *LN (OHIO TRAFFIC CRASH REPORT # 10-0401-90)*JB
ODI #765222 · Filed August 5, 2002
SAME COMPONENT FAILED AT 17291 MILES. BOTH UNITS WERE REPLACE UNDER WARRANTY BUT WHEN THEY FAIL THE GAS PEDAL IS INOPERATIVE AND THE SPEED DIMINISHES TO LESS THAN 10 MPH. THIS IS HAZARDOUS ON A BUSY HIGHWAY. BESIDES THE SAFETY CONCERNS, I AM CONCERNED ABOUT REPLACEMENT OF AN EXPENSIVE PART EVERY…
ODI #735107 · Filed November 17, 2000
CONSUMER STATES THAT THE HOOD WAS NOT ADJUSTED PROPERLY AT THE TIME OF PURCHASE, CAUSING IT TO POP OPEN WHILE DRIVING DOWN THE ROAD, CONSUMER ALSO STATES THAT THERE HAS BEEN A PROBLEM WITH OPENING THE HOOD, MODEL IS A VN64T610. *SLC

Read all 7 complaints

VOLVO TRUCKS/FMVSS 121/ELECTRICAL POWER TO ABS

NHTSA #02V110000 · Service Brakes, Air — Antilock · NHTSA notice

Reported April 11, 2002 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 208 vehicles

Owners notified April 29, 2002 · Vehicles built October 20, 1997 – November 1, 2001 (per NHTSA)

Defect description

CERTAIN HEAVY DUTY CLASS 8 VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", S5.1.6.3, "ANTILOCK POWER FOR TOWED VEHICLES." ELECTRICAL POWER FOR THE TRAILER ANTI-LOCK BRAKING SYSTEM (ABS) CAN BE DISRUPTED WHEN A SWITCH LOCATED ON THE VEHICLE INSTRUMENT PANEL IS ACTIVATED TO CONTROL LIGHTING WITHIN THE TRAILER.

Safety consequence

IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE OF THE TOWED VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A WIRING HARNESS WHICH WILL PROVIDE CONTINUOUS ELECTRICAL POWER TO THE TRAILER ABS WHENEVER THE IGNITION SWITCH IS IN THE ON OR RUN POSITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO TRUCKS/EATON TRANSMISSION

NHTSA #00V131003 · Power Train — Automatic Transmission · NHTSA notice

Reported May 30, 2000 · VOLVO TRUCKS NORTH AMERICA INC

Potentially affected: 3 vehicles

Vehicles built March 20, 2000 – April 5, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH EATON AUTOSHIFT GEN II TRANSMISSION ASSEMBLIES. DUE TO A SOFTWARE PROBLEM IN THE TRANSMISSION ASSEMBLIES, THE TRANSMISSION WILL SELECT THE WRONG GEAR.

Safety consequence

IF AN INAPPROPRIATE GEAR IS SELECTED WITHOUT THE DRIVER'S KNOWLEDGE, THE VEHICLE WILL REACT DIFFERENTLY THAN EXPECTED, POSSIBLY RESULTING IN INJURY OR CRASH.

Manufacturer remedy

EATON IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS RECALL. DEALERS WILL REPLACE THE AUTOSHIFT TRANSMISSIONS.

Notes

OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING JUNE 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT EATON AT 1-888-880-0970 OR VOLVO TRUCKS AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2000 Volvo Volvo Truck. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

7 owner complaints have been filed with NHTSA for the 2000 Volvo Volvo Truck.

Tires

ODI #10415938

Incident: June 9, 2011 · Filed: July 26, 2011

2000 VOLVO CONVENTIONAL. UNIT #1 WAS EASTBOUND IN FAR RIGHT LANE. UNIT #1 EXPERIENCED BLOW-OUT ON THE FORWARD DRIVE AXLE, TANDEM, ON PASSENGER SIDE OF CAB, CAUSING DAMAGE TO FUEL TANK, FIBERGLASS BODY, AND MUD FLAP ASSEMBLY. *LN (OHIO TRAFFIC CRASH REPORT # 10-0401-90)*JB

Vehicle Speed Control

ODI #765222

Incident: July 31, 2002 · Filed: August 5, 2002

SAME COMPONENT FAILED AT 17291 MILES. BOTH UNITS WERE REPLACE UNDER WARRANTY BUT WHEN THEY FAIL THE GAS PEDAL IS INOPERATIVE AND THE SPEED DIMINISHES TO LESS THAN 10 MPH. THIS IS HAZARDOUS ON A BUSY HIGHWAY. BESIDES THE SAFETY CONCERNS, I AM CONCERNED ABOUT REPLACEMENT OF AN EXPENSIVE PART EVERY YEAR.*AK

Latches/Locks/Linkages

ODI #735107

Incident: October 20, 1999 · Filed: November 17, 2000

CONSUMER STATES THAT THE HOOD WAS NOT ADJUSTED PROPERLY AT THE TIME OF PURCHASE, CAUSING IT TO POP OPEN WHILE DRIVING DOWN THE ROAD, CONSUMER ALSO STATES THAT THERE HAS BEEN A PROBLEM WITH OPENING THE HOOD, MODEL IS A VN64T610. *SLC

Suspension

ODI #565623

Filed: May 9, 2002

CONSUMER OWNS FOUR OF THESE TRUCKS, THEY ARE EXPERIENCING STEER TIRE WEAR AND PROBLEMS WITH ALIGNMENT, ON ONE OF THE VEHICLES THE LEFT TIRE BROKE CAUSING A FUEL SPILL, TWO OF THE VEHICLES HAD TIRE BLOWOUTS, CONSUMER ALSO STATED EVERYTHING INSIDE TIRE BROKE, CONSUMER ALSO STATES THERE WERE ACCIDENTS, HOWEVER DID NOT SPECIFY AS TO WHICH VEHICLES. *YD

Steering

ODI #564518

Filed: February 28, 2002

THE VEHICLE BEGAN TO VIBRATE 9 MONTHS AFTER PURCHASE. VIBRATION WAS FELT THROUGH STEERING WHEEL, BUT THE CAUSE WAS UNKNOWN. THE DEALER REPLACED NEW TIRES AND PERFORMED WHEEL ALIGNMENT, BUT THE PROBLEM WAS NOT SOLVED. *YH

Power Train; Tires

ODI #560382

Fire

Incident: January 17, 2001 · Filed: March 19, 2001

THE RIGHT DRIVE AXLE TIRE BLEW OUT AND BEGAN TO SPARK, THE DRIVER PULLED OFF THE ROAD AND THE ENTIRE VEHICLE BECAME ENGULFED IN FLAMES (OHIO TRAFFIC CRASH REPORT). NLM

Steering

ODI #553102

Incident: May 5, 2000 · Filed: July 19, 2000

DRIVER EXPERIENCED PROBLEMS WITH THE STEERING AXLE AND THE TIRE BLEW OUT CAUSING LOSS OF CONTROL AND COLLISION INTO DITCH AND GUARDRAIL, POSSIBLE STEERING DEFECT (OHIO TRAFFIC CRASH REPORT). *MJS

Other Volvo Volvo Truck model years

Check your 2000 Volvo Volvo Truck VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo Volvo Truck at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN