NHTSA vehicle safety data

2004 Volvo V70XC Recalls & Complaints

We couldn't confirm the NHTSA recall list for the 2004 Volvo V70XC right now, so this page doesn't state a recall count — check the VIN at nhtsa.gov/recalls for current campaigns. 5 owner complaints are on file.

NHTSA recall and complaint data for the 2004 Volvo V70XC.

2004 Volvo V70XC owner complaints

Owners have filed 5 complaints with NHTSA about the 2004 Volvo V70XC, describing incidents dated August 25, 2009 to April 29, 2017.

Most-cited components

Fuel/Propulsion System 3 complaints
Seats 1 complaint
Suspension 1 complaint

Of the 5 complaints on file, 1 reports a fire; across all 5 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10990697 · Filed May 20, 2017
I WAS DEPARTING MY HOME VILLAGE ABOUT A BLOCK FROM MY HOME AND I HEARD A LOUD BANG IN THE FRONT DRIVER SIDE AT ABOUT 15 MPH!! NO BUMP.. NOTHING! I LOOKED UNDER THE CAR AND THERE WAS NO OBVIOUS ISSUE AT THE INITIAL LOOK AND I DROVE ANOTHER QUARTER MILE AND HEARD A SLIGHT GRIND OR NOISE ON SMALL…
ODI #10767267 · Filed September 21, 2015
ENTERING MY VEHICLE I SMELLED A STRONG ODOR OF GASOLINE. UPON INVESTIGATION, I FOUND THIS WAS DUE TO A CRACKED FUEL PUMP. BECAUSE OF THIS VERY PROBLEM, THIS MAKE AND MODEL OF VEHICLE WAS OFFICIALLY RECALLED BY VOLVO IN 2009 AS PART OF NHTSA ACTION NUMBER : PE09039 NHTSA RECALL CAMPAIGN NUMBER…
ODI #10695258 · Filed March 19, 2015
THE DRIVER SIDE SEAT WARMER CAUGHT FIRE. IT BURNED A HOLE THROUGH THE SIDE OF THE SEAT COVER AND ALSO CAUSED A MILD BURN TO MY LEG. I STOPPED THE CAR, SHUT OF THE SEAT WARMER, AND WAS ABLE TO EXTINGUISH THE FIRE WHILE IT WAS STILL SMALL. A SEARCH ON THE INTERNET REVEALED THAT OTHER OWNERS HAVE…

Read all 5 complaints

We couldn't confirm the NHTSA recall list for the 2004 Volvo V70XC right now — this is not a confirmed "no recalls". Check the VIN at NHTSA.gov/recalls for the official status.

try.vin has no NCAP crash-test rating on file for the 2004 Volvo V70XC. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

5 owner complaints have been filed with NHTSA for the 2004 Volvo V70XC.

Suspension

ODI #10990697

Incident: April 29, 2017 · Filed: May 20, 2017

I WAS DEPARTING MY HOME VILLAGE ABOUT A BLOCK FROM MY HOME AND I HEARD A LOUD BANG IN THE FRONT DRIVER SIDE AT ABOUT 15 MPH!! NO BUMP.. NOTHING! I LOOKED UNDER THE CAR AND THERE WAS NO OBVIOUS ISSUE AT THE INITIAL LOOK AND I DROVE ANOTHER QUARTER MILE AND HEARD A SLIGHT GRIND OR NOISE ON SMALL BUMPS... THEN A CLANK. I BACKED UP AND THERE WAS A PIECE OF THE COIL SPRING ON THE ROAD!!!! THE FRONT LEFT - DRIVERS SIDE - COIL SPRING SNAPPED IN TWO. AT 101,000 MILES. THE CLEAN BREAK AND NO RUST OR UNUSUAL CORROSION INDICATES A FAULTY METAL. HOW CAN I TRUST THE VOLVO XC AGAIN!! SAFETY AND VOLVO ARE NO LONGER WORDS THAT SHOULD BE USED TOGETHER. MY COMPLAINTS TO VOLVO AMERICA WERE RESPONDED TO WITH NO CONSIDERATION TO THE MAGNITUDE OF THE ISSUE. VOLVO DID NOT STAND BEHIND THE OBVIOUS FLAW IN THE CONSTRUCTION OF THE VEHICLE. MANY OTHER COMPLAINTS ON NHTSA AND ONLINE FORUMS INDICATE A COMMON ISSUE WITH VOLVO XC SUSPENSION COIL SPRINGS. SO DANGEROUS!

Fuel/Propulsion System

ODI #10767267

Incident: September 1, 2015 · Filed: September 21, 2015

ENTERING MY VEHICLE I SMELLED A STRONG ODOR OF GASOLINE. UPON INVESTIGATION, I FOUND THIS WAS DUE TO A CRACKED FUEL PUMP. BECAUSE OF THIS VERY PROBLEM, THIS MAKE AND MODEL OF VEHICLE WAS OFFICIALLY RECALLED BY VOLVO IN 2009 AS PART OF NHTSA ACTION NUMBER : PE09039 NHTSA RECALL CAMPAIGN NUMBER : 09V483000 . HOWEVER THE RECALL ONLY APPLIES TO VEHICLES SOLD IN AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES. THE PROBLEM CAN HAPPEN TO ANY OF THESE CARS REGARDLESS OF WHERE THEY WERE SOLD. THE TEMPERATURE FLUCTUATIONS THAT MAY BE RESPONSIBLE FOR THE SAFETY HAZARD OCCUR IN NEW ENGLAND AS WELL AS THE SOUTH AND WEST. THE DEFECTIVE PART AND SAFETY ISSUE EXISTS FOR ALL OWNERS OF THESE CARS AND EVERY ONE OF THEM SHOULD BE RECALLED.

Seats

ODI #10695258

Fire 1 injury

Incident: March 14, 2015 · Filed: March 19, 2015

THE DRIVER SIDE SEAT WARMER CAUGHT FIRE. IT BURNED A HOLE THROUGH THE SIDE OF THE SEAT COVER AND ALSO CAUSED A MILD BURN TO MY LEG. I STOPPED THE CAR, SHUT OF THE SEAT WARMER, AND WAS ABLE TO EXTINGUISH THE FIRE WHILE IT WAS STILL SMALL. A SEARCH ON THE INTERNET REVEALED THAT OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR

Fuel/Propulsion System

ODI #10488917

Incident: December 13, 2012 · Filed: December 16, 2012

FUEL SMELL COMING FROM TRUNK. POSSIBLE COMBUSTION. PREVIOUS RECALL WAS NOT EXTENDED TO COLORADO, BUT AS THE FRONT RANGE SUMMER TEMPERATURES AND DRYNESS ARE AN INDICATOR OF FAILURE, I WORRY THAT THIS RECALL SHOULD BE EXTENDED TO COLORADO OWNERS. *TR

Fuel System, Gasoline

ODI #10284748

Incident: August 25, 2009 · Filed: September 21, 2009

THE FUEL PUMP IN MY 2004 VOLVO XC70 FAILED, CAUSING GAS TO LEAK FROM THE VEHICLE. I UNDERSTAND FROM A NYT ARTICLE THAT THERE ARE SEVERAL COMPLAINTS INTO NHTSA REGARDING A SIMILAR CONDITION IN THE 2004 XC90. THE LEAKING PUMP WAS REPAIRED BY A VOLVO DEALER AT CONSIDERABLE ($1300) COST. *TR

Other Volvo V70XC model years

Check your 2004 Volvo V70XC VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo V70XC at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN