How many recalls does the 2009 Tiffin Allegro Bus have?

NHTSA lists 6 recall campaigns for the 2009 Tiffin Allegro Bus as of October 16, 2026. Each includes the defect description, safety consequence, and the remedy Tiffin will perform. New recalls can be issued at any time; this page is refreshed from NHTSA daily.

How do I tell if my 2009 Tiffin Allegro Bus is affected by a recall?

Enter your 17-character VIN — stamped at the base of the windshield on the driver side and on the door jamb sticker — at nhtsa.gov/recalls. NHTSA's VIN lookup shows whether your specific vehicle has an unrepaired recall; the list on this page covers every campaign for the 2009 Tiffin Allegro Bus.

Are recall repairs on a 2009 Tiffin Allegro Bus free?

Usually. Federal law requires Tiffin to remedy recalls on the 2009 Allegro Bus free of charge at an authorized Tiffin dealer, regardless of how many owners the vehicle has had or how many miles are on the odometer — unless it was first sold more than 15 years before the recall was issued (5 years for tires).

Does a recall on the 2009 Tiffin Allegro Bus affect resale value?

An open recall can reduce resale value; a recall that has been repaired (documented in the vehicle history report) generally does not. Before you buy or sell a used 2009 Tiffin Allegro Bus, check the VIN at nhtsa.gov/recalls to confirm every recall has been remedied.

How many owner complaints are on file for the 2009 Tiffin Allegro Bus?

No owner complaints have been filed with NHTSA on the 2009 Tiffin Allegro Bus.

NHTSA vehicle safety data

2009 Tiffin Allegro Bus Recalls, Ratings & Complaints

The 2009 Tiffin Allegro Bus has 6 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Tiffin dealer.

NHTSA recall and complaint data for the 2009 Tiffin Allegro Bus. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

VISIBILITY:WINDSHIELD WIPER/WASHER

NHTSA #16V532000

Reported July 13, 2016 · Tiffin Motorhomes, Inc.

Potentially affected: 10,351 vehicles

Defect description

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

Safety consequence

If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

Manufacturer remedy

Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

NHTSA #09V496000

Reported December 29, 2009 · TIFFIN MOTORHOMES, INC.

Potentially affected: 486 vehicles

Defect description

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALLEGRO BUS MODELS WITH POWERGLIDE CHASSIS EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.

Safety consequence

IF THE DRIVE PIN BECOMES DISENGAGED ON THE BRAKE PEDAL ASSEMBLY, IT COULD RESULT IN A LOSS OF VEHICLE BRAKING FUNCTION AND/OR CAUSE THE BRAKE PEDAL TO INTERFERE WITH THE THROTTLE PEDAL FUNCTION. EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TIFFIN IS WORKING WITH KONGSBERG TO REMEDY THESE MOTORHOMES. PLEASE SEE KONGSBERG'S DEFECT REPORT 09E-064. KONGSBERG WILL SUPPLY KITS TO TIFFIN. THE REMEDY WILL BE PERFORMED BY TIFFIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 19, 2010. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SERVICE BRAKES, AIR:ANTILOCK

NHTSA #09V127000

Reported April 16, 2009 · TIFFIN MOTORHOMES, INC.

Potentially affected: 329 vehicles

Defect description

TIFFIN IS RECALLING 329 MY 2008-2009 ALLEGRO BUSES. THE REAR AXLE ABS MODULATING VALVE HAVE THE POTENTIAL TO BE WIRED INCORRECTLY. THE RIGHT AND LEFT MODULATOR VALVE HARNESS PIN COULD POSSIBLY BE REVERSED AT THE ABS ELECTRONIC CONTROL UNIT (ECU) CONNECTOR.

Safety consequence

UNDER SLIPPERY ROAD CONDITIONS, WHEN IN THE ABS MODE, THIS WIRING PROBLEM HAS THE POTENTIAL TO CAUSE ONE SIDE OF THE REAR WHEELS TO LOCK WHILE CAUSING LITTLE OR NO BRAKING EFFORT ON THE OPPOSITE SIDE. THIS MAY RESULT IN A LOSS OF CONTROL AND A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REMOVE THE REVERSED PINS FROM THE ECU CONNECTOR AND INSERT THEM BACK INTO THEIR CORRECT POSITION FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT TIFFIN AT 256-356-8661.

Notes

TRAILER HITCHES

NHTSA #09V069000

Reported February 27, 2009 · TIFFIN MOTORHOMES, INC.

Potentially affected: 1,408 vehicles

Defect description

TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Safety consequence

SUSPECT HITCHES MAY DEVELOP FRACTURES AND SUBSEQUENT SEPARATION MAY OCCUR, RESULTING IN A VEHICLE CRASH, PROPERTY DAMAGE OR PEDESTRIAN HARM.

Manufacturer remedy

TIFFIN IS WORKING WITH SPARTAN AND SPARTAN IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08V-567). THE TRAILER HITCH WILL BE REPLACED FREE OF CHARGE. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR TIFFIN AT 256-356-8661.

Notes

POWER TRAIN:AXLE HUBS

NHTSA #09V045000

Reported February 5, 2009 · TIFFIN MOTORHOMES, INC.

Potentially affected: 23 vehicles

Defect description

TIFFIN IS RECALLING 23 MY 2009 ALLEGRO BUSES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES. THE WHEEL END STUDS MAY HAVE BEEN IMPROPERLY TEMPERED RENDERING THEM BRITTLE AND SUSCEPTIBLE TO FRACTURE. IF ONE WHEEL STUD FRACTURES, THE REMAINING WHEEL STUDS ARE REQUIRED TO CARRY MORE LOAD. IF LEFT IN THIS CONDITION, THE REMAINING WHEEL STUDS MAY ALSO FRACTURE EVEN IF THEY ARE PROPERLY MANUFACTURED.

Safety consequence

FRACTURED WHEEL STUDS COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TIFFIN IS WORKING WITH ARVINMERITOR WHO WILL REPLACE ANY AFTERMARKET REPLACEMENT STUD FREE OF CHARGE (PLEASE SEE 08E038). OWNERS MAY CONTACT ARVINMERITOR AT 1-248-435-8793 OR TIFFIN AT 256-356-8661.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SUSPENSION

NHTSA #08V269000

Reported June 17, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 2,506 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Safety consequence

IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Manufacturer remedy

DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.

Notes

DAIMLER TRUCKS RECALL NO. FL-530.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Tiffin Allegro Bus model years

Check your 2009 Tiffin Allegro Bus VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Tiffin Allegro Bus at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Tiffin VIN