NHTSA vehicle safety data

2025 Thor Motor Coach Geneva Recalls & Complaints

The 2025 Thor Motor Coach Geneva has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Thor Motor Coach dealer.

NHTSA recall and complaint data for the 2025 Thor Motor Coach Geneva. Recall data is refreshed daily from NHTSA.

2025 Thor Motor Coach Geneva owner complaints

Owners have filed 2 complaints with NHTSA about the 2025 Thor Motor Coach Geneva, describing incidents dated April 4, 2025 to May 2, 2025.

Most-cited components

Electrical System 1 complaint
Equipment 1 complaint
Exterior Lighting 1 complaint
Unknown or Other 1 complaint

Together, the 2 complaints on file report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11706199 · Filed December 19, 2025
I brought a 2025 THOR RV Geneva VS24, VIN: [XXX] . THOR and Blue Compass RV drove this RV for 2046 miles with the headlights not working, a bad headlight relay was found by Ford, the part is a THOR relay. This is a road safely issue driving roads without headlights. Second issue; I have to…
ODI #11660344 · Filed May 12, 2025
Fumes inside motorhome when running Motorcoach overhead air conditioner on Generator power with vehicle engine off. I became irritable, felt ill and my eyes were swollen. It required a day to feel normal again. Due to this problem, I did not run both devices together again for the remainder of my 11…

Read all 2 complaints

Slide-Out Room May Extend While Driving

NHTSA #25V171000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 20, 2025 · Thor Motor Coach

Potentially affected: 4,251 vehicles

Repair completion: 55.07% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Thor Motor Coach campaign RC000325 · Owners notified April 28, 2025

Defect description

Thor Motor Company (TMC) is recalling certain 2023-2026 Axis, Chateau, Four Winds, 2023-2025 Coleman, Echelon, Freedom Elite, Geneva, Outlaw, Quantum, Vegas, 2025 Eddie Bauer, Freedom Traveler, Pasadena, and 2024-2025 Magnitude motorhomes. The slide-Out room can be deployed without the parking brake engaged, allowing the room to extend while the vehicle is in motion.

Safety consequence

A slide-Out room that extends unexpectedly increases the risk of a crash.

Manufacturer remedy

Dealers will replace the park brake harness, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000325.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.

try.vin has no NCAP crash-test rating on file for the 2025 Thor Motor Coach Geneva. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2025 Thor Motor Coach Geneva.

Exterior Lighting; Unknown or Other

ODI #11706199

Incident: April 4, 2025 · Filed: December 19, 2025

I brought a 2025 THOR RV Geneva VS24, VIN: [XXX] . THOR and Blue Compass RV drove this RV for 2046 miles with the headlights not working, a bad headlight relay was found by Ford, the part is a THOR relay. This is a road safely issue driving roads without headlights. Second issue; I have to disconnect the smoke alarm to use the stove top, THOR didn't install a exhaust fan/vent to get rid of smoke when cooking. Third issue; The engine cover seal was not in place allowing heat and engine fumes to enter the driver cab area. Fourth issue: Windshield not installed correctly at factory, it was leaking water through the upper part of the windshield, the windshield could fall off the RV while driving down the road, a bracket was not installed correctly per Blue Compass RV shop. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Electrical System; Equipment

ODI #11660344

1 injury

Incident: May 2, 2025 · Filed: May 12, 2025

Fumes inside motorhome when running Motorcoach overhead air conditioner on Generator power with vehicle engine off. I became irritable, felt ill and my eyes were swollen. It required a day to feel normal again. Due to this problem, I did not run both devices together again for the remainder of my 11 day trip. I will take it into the dealer this week for analysis.

Other Thor Motor Coach Geneva model years

Check your 2025 Thor Motor Coach Geneva VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thor Motor Coach Geneva at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thor Motor Coach VIN