NHTSA vehicle safety data

2022 Thor Motor Coach A.C.E. Recalls & Complaints

The 2022 Thor Motor Coach A.C.E. has 1 NHTSA recall campaign and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Thor Motor Coach dealer.

NHTSA recall and complaint data for the 2022 Thor Motor Coach A.C.E.. Recall data is refreshed daily from NHTSA.

2022 Thor Motor Coach A.C.E. owner complaints

Owners have filed 3 complaints with NHTSA about the 2022 Thor Motor Coach A.C.E., describing incidents dated April 11, 2022 to April 21, 2024.

Most-cited components

Service Brakes 1 complaint
Suspension 1 complaint
Unknown or Other 1 complaint

Newest complaints

ODI #11594819 · Filed June 17, 2024
I purchased the motorhome from Fraserway RV in Kamloops, BC. The vehicle was sold to me as a new unused unit in November 2023. While turning into a strip mall parking lot from a small service road, we were travelling at around 5-10 KPH. My wife and I heard a very odd low "thud" type of noise coming…
ODI #11515368 · Filed April 4, 2023
The initial brake pedal press is soft and travels nearly to the floorboard. A quick subsequent press of the brake pedal, or "pumping the brakes," changes the pedal travel and sensitivity. This condition has eluded repeated repair attempts by the service center and the chassis manufacturer's team of…
ODI #11460377 · Filed April 11, 2022
Rear Sway Bar Bracket manufactured from weak cast iron. Known problem and FORD will do nothing to fix it except to replace with same faulty part.

Read all 3 complaints

Ladder Installed on Wrong Side of Motorhome

NHTSA #22V076000 · Structure — Body — Step/Ladder · NHTSA notice

Reported February 10, 2022 · Thor Motor Coach

Potentially affected: 148 vehicles

Repair completion: 87.84% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Thor Motor Coach campaign RC000255 · Owners notified March 24, 2022

Defect description

Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.

Safety consequence

An incorrectly installed ladder may break while in use, increasing the risk of injury.

Manufacturer remedy

Dealers will inspect the location of the rear ladder, and reinforce or relocate the ladder as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000255.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

try.vin has no NCAP crash-test rating on file for the 2022 Thor Motor Coach A.C.E.. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2022 Thor Motor Coach A.C.E..

Unknown or Other

ODI #11594819

Incident: April 21, 2024 · Filed: June 17, 2024

I purchased the motorhome from Fraserway RV in Kamloops, BC. The vehicle was sold to me as a new unused unit in November 2023. While turning into a strip mall parking lot from a small service road, we were travelling at around 5-10 KPH. My wife and I heard a very odd low "thud" type of noise coming from somewhere in the motorhome. We parked in the mall parking lot and began to look for the source of the noise. We were unable to find anything so we assumed perhaps something in a cupboard had shifted. We purchased some groceries and my wife decided to move some frying pans from under the cupboard sink to the oven drawer. The oven drawer is covered in a glass type material. When my wife opened the drawer the glass panel on the oven drawer, literally exploded in her face sending glass shrapnel throughout the motorhome. I reported the incident to the Manufacturer and they did not even reply. It seems evident that the drawer glass panel experienced some sort of stress which caused the thud. NOTE: I am located in Kamloops, BC, Canada but your system doesn't allow me to make this information known.

Service Brakes

ODI #11515368

Incident: September 29, 2022 · Filed: April 4, 2023

The initial brake pedal press is soft and travels nearly to the floorboard. A quick subsequent press of the brake pedal, or "pumping the brakes," changes the pedal travel and sensitivity. This condition has eluded repeated repair attempts by the service center and the chassis manufacturer's team of engineers. The chassis manufacturer has sent its engineers to the service location for hands-on evaluation and repair attempts, to no avail. Parts replaced during the service center's repair attempts include the calipers, pads & rotors, brake lines, brake master cylinder, brake booster, ABS unit, and many quarts of brake fluid. Safety is at risk for the driver as well as others due to inconsistent brake pedal feel and performance on an 18,000lb GVWR vehicle traveling on public roadways. There were no warning lamps or other messages displayed. The service center has indicated their network of shops has had at least 15 similar complaints on similar year & model RVs as of approximately the 2nd of March, 2023.

Suspension

ODI #11460377

Incident: April 11, 2022 · Filed: April 11, 2022

Rear Sway Bar Bracket manufactured from weak cast iron. Known problem and FORD will do nothing to fix it except to replace with same faulty part.

Other Thor Motor Coach A.C.E. model years

Check your 2022 Thor Motor Coach A.C.E. VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thor Motor Coach A.C.E. at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thor Motor Coach VIN