NHTSA vehicle safety data
2000 Thomas Transit Liner ER Recalls, Ratings & Complaints
The 2000 Thomas Transit Liner ER has 3 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Thomas dealer.
NHTSA recall and complaint data for the 2000 Thomas Transit Liner ER. Recall data is refreshed daily from NHTSA.
SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR
NHTSA #01V111004Reported July 16, 2001 · FREIGHTLINER CORPORATION
Potentially affected: 194 vehicles
Defect description
VEHICLE DESCRIPTION: TRANSIT AND SHUTTLE BUSES EQUIPPED WITH CUMMINS ISC AND ISL DIESEL ENGINES. THE INTERNAL FRONT BUSHING CAN SPIN, CAUSING DAMAGE TO THE AIR COMPRESSOR, AND POSSIBLY TO THE SPINDLE DRIVE AT THE REAR FACE OF THE AIR COMPRESSOR WHICH IS USED TO PROVIDE POWER TO THE VEHICLE HYDRAULIC PUMP. FAILURE OF THE AIR COMPRESSOR'S SPINDLE DRIVE COULD LEAD TO LOSS OF POWER ASSIST IF THE HYDRAULIC PUMP CEASES TO OPERATE.
Safety consequence
WITHOUT POWER ASSIST, THE VEHICLE BECOMES VERY DIFFICULT TO TURN AND COULD POSSIBLY RESULT IN A VEHICLE CRASH.
Manufacturer remedy
CUMMINS IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPLACE THE AIR COMPRESSOR. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COMMINS AT 1-800-343-7357 OR THOMAS BUILT AT 1-336-841-5924.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
STRUCTURE:BODY
NHTSA #01V104000Reported March 27, 2001 · FREIGHTLINER CORPORATION
Potentially affected: 145 vehicles
Defect description
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES BUILT WITH COMPOSITE FRONT ROOF CAPS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." THE ROOF CAP DOES NOT MEET THE REQUIREMENTS DUE TO THE OMISSION OF THE ADHESIVE THAT JOINS THE ROOF TO THE BUS BODY.
Safety consequence
IN THE EVENT OF A CRASH, THE ROOF OF THE VEHICLE MAY CRUSH, NOT PROPERLY PROTECTING THE VEHICLE OCCUPANTS.
Manufacturer remedy
DEALERS WILL RE-BOND THE ROOF CAP TO THE ROOF SHEET METAL. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
NHTSA #01V103000Reported March 27, 2001 · FREIGHTLINER CORPORATION
Potentially affected: 146 vehicles
Defect description
VEHICLE DESCRIPTION: SCHOOL BUSES. THE ACCELERATOR PEDAL CAN POSSIBLY HANG UP ON THE FLOOR RUBBER.
Safety consequence
THE DRIVER WOULD BE EXPECTING THE VEHICLE'S SPEED TO DECREASE, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSTALL A STAINLESS STEEL PLATE UNDER THE ACCELERATOR PEDAL. OWNER NOTIFICATION BEGAN JUNE 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Thomas Transit Liner ER model years
Check your 2000 Thomas Transit Liner ER VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Transit Liner ER at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Thomas VIN