NHTSA vehicle safety data

2022 Thomas Built Buses SAF-T-Liner HDX Recalls, Ratings & Complaints

The 2022 Thomas Built Buses SAF-T-Liner HDX has 11 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Thomas Built Buses dealer.

NHTSA recall and complaint data for the 2022 Thomas Built Buses SAF-T-Liner HDX. Recall data is refreshed daily from NHTSA.

EQUIPMENT:OTHER:LABELS

NHTSA #24V555000

Reported July 24, 2024 · Daimler Trucks North America, LLC

Potentially affected: 27,494 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2019-2022 Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, Minotour DRW, 2020-2022 Saf-T-Liner C2 Jouley, and Minotour SRW school buses. The Emergency Exit Label lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window Retention and Release."

Safety consequence

Emergency exit labels that are difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Manufacturer remedy

Dealers will correct the lettering, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL918.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

STRUCTURE:BODY:ROOF AND PILLARS

NHTSA #22V762000

Reported October 12, 2022 · Daimler Trucks North America, LLC

Potentially affected: 17,613 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Safety consequence

A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Manufacturer remedy

Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

STRUCTURE:BODY

NHTSA #22V688000

Reported September 14, 2022 · Daimler Trucks North America, LLC

Potentially affected: 1,259 vehicles

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2023 Thomas Built Saf-T-Liner HDX school buses. The rear exterior side-body panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Safety consequence

A school bus panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Manufacturer remedy

Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall FL953.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

SEATS

NHTSA #22V510000

Reported July 19, 2022 · Daimler Trucks North America, LLC

Potentially affected: 1,806 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.

Safety consequence

Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.

Manufacturer remedy

Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

NHTSA #22V272000

Reported April 22, 2022 · Daimler Trucks North America, LLC

Potentially affected: 138 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX commercial buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.

Safety consequence

An electrical short circuit can increase the risk of a fire.

Manufacturer remedy

Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL929.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

NHTSA #22V271000

Reported April 22, 2022 · Daimler Trucks North America, LLC

Potentially affected: 2,943 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX school buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.

Safety consequence

An electrical short circuit can increase the risk of a fire.

Manufacturer remedy

Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL928.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

NHTSA #21V850000

Reported November 2, 2021 · Daimler Trucks North America, LLC

Potentially affected: 1,434 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2022 Thomas Built EFX and HDX school buses. The nut for the power cable stud on the alternator may not have been tightened properly, which can cause a loose cable connection.

Safety consequence

A loose power cable connection may cause electrical arcing, which can increase the risk of a fire.

Manufacturer remedy

Dealers will inspect the alternator power cable connection and tighten it if necessary, free of charge. Owner notification letters were mailed on December 17, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL904.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

NHTSA #21V714000

Reported September 15, 2021 · Daimler Trucks North America, LLC

Potentially affected: 50 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 Thomas Built Buses Saf-T-Liner HDX school buses. The fan drive pulley assembly bolts may be incorrect or improperly installed. Incorrect or improperly installed bolts may lead to a loose fan belt, resulting in a disabled bus.

Safety consequence

A disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury.

Manufacturer remedy

DTNA will inspect and repair the fan drive pulley assembly mounting bolts as necessary, free of charge. Owner notification letters were mailed on November 12, 2021. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL-902.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

SEATS

NHTSA #21V462000

Reported June 17, 2021 · Daimler Trucks North America, LLC

Potentially affected: 9 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2018-2022 Thomas Built Saf-T-Liner HDX School Buses. These school buses may have been manufactured with an incorrect passenger seat configuration that does not provide the proper amount of seat back protection. As such, these school buses fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 222, "School Bus Passenger Seating and Crash Protection."

Safety consequence

In the event of a crash, the seats may not adequately protect the occupants, increasing the risk of injury.

Manufacturer remedy

Dealers will replace the rear passenger seats, free of charge. No owner notification will be distributed, all units were repaired on August 12, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-892.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

STEERING:LINKAGES:TIE ROD ASSEMBLY

NHTSA #21V370000

Reported May 19, 2021 · Daimler Trucks North America, LLC

Potentially affected: 479 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Thomas Built Saf-T-Liner HDX School Buses and Saf-T-Liner C2 School Buses. The tie rod clamps may be loose, which could result in loose tie rod ends that could break or detach.

Safety consequence

Detached or broken tie rod ends can result in steering loss, increasing the risk of a crash.

Manufacturer remedy

Dealers will replace the tie rod clamp bolts and nuts, free of charge. Owner notification letters were mailed December 23, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-888.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

STEERING:LINKAGES:TIE ROD ASSEMBLY

NHTSA #21V255000

Reported April 12, 2021 · Daimler Trucks North America, LLC

Potentially affected: 1,252 vehicles

Defect description

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner EFX, and Saf-T-Liner HDX school buses. The steering arm and tie rod bolts may have a defective seam that can fracture.

Safety consequence

A fractured bolt may cause a loss of steering, increasing the risk of a crash.

Manufacturer remedy

DTNA will notify owners, and dealers will replace the tie rod arm bolts and steering arm, free of charge. The recall began on June 10, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-884.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Other Thomas Built Buses SAF-T-Liner HDX model years

Check your 2022 Thomas Built Buses SAF-T-Liner HDX VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Built Buses SAF-T-Liner HDX at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thomas Built Buses VIN