try.vin
Log in

NHTSA vehicle safety data

2006 Suzuki SV650S Recalls & Complaints

The 2006 Suzuki SV650S has 2 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Suzuki dealer.

NHTSA recall and complaint data for the 2006 Suzuki SV650S. Recall data is refreshed daily from NHTSA.

2006 Suzuki SV650S owner complaints

Owners have filed 1 complaint with NHTSA about the 2006 Suzuki SV650S, describing incidents dated April 18, 2006.

Most-cited components

  • Electrical System 1 complaint

Newest complaints

  • ODI #10189080 · Filed

    THE SCREW HOLDING ON THE HORN ASSEMBLY FOR THE 2006 SV650S IS NOT A CORRECT LENGTH TO HOLD UP TO THE AMOUNT OF VIBRATION IT IS EXPOSED TO. MY SCREW FELL OUT AFTER THE LAST MAINTENANCE SERVICE AND SWUNG BACK UP ENOUGH TO POKE A HOLE THROUGH MY RADIATOR. THE SCREW ASSEMBLY ITSELF IS TIGHTENED INTO A…

Read the full complaint

AFTERMARKET BRAKE LEVERS

NHTSA #08E052000 · Equipment · NHTSA notice

Reported August 15, 2008 · MOTION PRO, INC.

Potentially affected: 10,000 vehicles

Owners notified September 11, 2008

Defect description

MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE WHEN THE DRIVER RELEASES THE BRAKE LEVER. THE LEVER CAN BE IDENTIFIED BY THE MARKING "JY 378" AT THE BASE OF THE LEVER NEAR THE PIVOT BUSHING.

Safety consequence

IF THIS OCCURS, THE STOP LAMP WILL REMAIN ON WHICH COULD POSSIBLY RESULT IN A CRASH.

Manufacturer remedy

MOTION PRO WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT MOTION PRO AT 1-877-438-7831.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET MOTION PRO BRAKE LEVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON SUZUKI OR YAMAHA MOTORCYCLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL TANK REPLACEMENT/MOTORCYCLES

NHTSA #06V013000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported January 18, 2006 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 4,841 vehicles

Manufacturer campaign 2086 · Owners notified February 3, 2006 · Vehicles built July 1, 2005 – October 30, 2005 (per NHTSA)

Defect description

ON CERTAIN CALIFORNIA-SPECIFICATION MODEL MOTORCYCLES, REPEATED STRESS FROM VIBRATION CAN CAUSE A CRACK TO FORM IN THE AREA WHERE THE LIQUID/VAPOR SEPARATOR BRACKET IS WELDED INSIDE THE FUEL TANK. THIS CAN ALLOW FUEL LEAKAGE TO OCCUR.

Safety consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 3, 2006. CUSTOMERS MAY CONTACT AMERICAN SUZUKI AT 714-572-1490.

Notes

SUZUKI RECALL NO. 2086.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Suzuki SV650S model years

Check your 2006 Suzuki SV650S VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Suzuki SV650S at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Suzuki VIN