NHTSA vehicle safety data

1999 Suzuki Grand Vitara Recalls & Complaints

The 1999 Suzuki Grand Vitara has 5 NHTSA recall campaigns and 108 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Suzuki dealer.

NHTSA recall and complaint data for the 1999 Suzuki Grand Vitara. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1999 Suzuki Grand Vitara owner complaints

Owners have filed 108 complaints with NHTSA about the 1999 Suzuki Grand Vitara, describing incidents dated December 12, 1998 to September 5, 2017.

Most-cited components

Fuel/Propulsion System 24 complaints
Engine 20 complaints
Service Brakes 16 complaints
Air Bags 12 complaints
Power Train 11 complaints
Vehicle Speed Control 10 complaints

Of the 108 complaints on file, 16 report a crash and 2 a fire; across all 108 complaints, owners report 12 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11030588 · Filed September 29, 2017
BRAKE LINE ROTTED AWAY ALL BRAKES AND FLUID LOST
ODI #10764563 · Filed September 17, 2015
TL* THE CONTACT OWNS A 1999 SUZUKI GRAND VITARA. WHILE DRIVING APPROXIMATELY 5 MPH, A FUEL ODOR EMITTED INSIDE THE VEHICLE. WHEN THE VEHICLE WAS PARKED, THE CONTACT DISCOVERED FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS INCLUDED…
ODI #10496399 · Filed February 4, 2013
THE VEHICLE AT HIGHWAY SPEEDS FROM 45 TO 55 MILES PER HOUR WILL LOSE COMPLETE POWER DROPPING FROM 45 OR 55 TO 10 OR 15 MPH VERY RAPIDLY WHEN THIS HAPPENS YOU HAVE NO CONTROL OF ACCELERATION OR VEHICLE TILL IT REACHES THE 10 TO 15 MPH RANGE LEAVING YOU IN A VERY DANGEROUS POSITION IF YOU ARE NOT…

Read all 108 complaints

FRONT BRAKE ROTOR

NHTSA #05V452000 · Service Brakes, Hydraulic — Foundation Components — Disc — Rotor · NHTSA notice

Reported October 5, 2005 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 801 vehicles

Manufacturer campaign 99-HQ · Owners notified November 10, 2005 · Vehicles built February 1, 1998 – August 31, 2005 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.

Safety consequence

THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.

Manufacturer remedy

DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.

Notes

SUZUKI RECALL NO. 99-HQ.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SUZUKI/FREEZING INSIDE FUEL PRESSURE REGULATOR

NHTSA #04V427000 · Fuel System, Gasoline · NHTSA notice

Reported August 30, 2004 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 172,093 vehicles

Manufacturer campaign 99-ER · Owners notified September 29, 2004 · Vehicles built June 1, 1998 – June 30, 1999 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

Safety consequence

FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Notes

SUZUKI RECALL NO. 99-ER.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SUZUKI/ACCELERATOR CABLE CASING CAP

NHTSA #03V512000 · Vehicle Speed Control — Cables · NHTSA notice

Reported December 5, 2003 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 196,876 vehicles

Manufacturer campaign EM · Owners notified January 5, 2004 · Vehicles built July 1, 1998 – June 30, 2003 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.

Safety consequence

IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Notes

SUZUKI RECALL NO. EM.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SUZUKI/FUEL PIPE/FUEL HOSE

NHTSA #01V146000 · Fuel System, Gasoline — Fuel Injection System · NHTSA notice

Reported April 27, 2001 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 59,888 vehicles

Owners notified June 4, 2001 · Vehicles built June 1, 1998 – June 7, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER TEMPERATURES BELOW -25 DEGREES, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. FUEL SYSTEM PRESSURE COULD INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

Safety consequence

FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A REDESIGNED INTAKE MANIFOLD VACUUM UNION AND A NEW FUEL PRESSURE REGULATOR. OWNER NOTIFICATION BEGAN JUNE 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SUZUKI/REPLACEMENT STEEL WHEELS

NHTSA #00E080000 · Wheels · NHTSA notice

Reported December 26, 2000 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 98 vehicles

Owners notified December 20, 2000

Defect description

EQUIPMENT DESCRIPTION: STEEL REPLACEMENT WHEELS, PART NO. 4310-665D21-27S, USED FOR SPARE PARTS ON 1999-2001 SUZUKI GRAND VITARA AND 2001 SUZUKI GRAND VITARA XL-7 MULTIPURPOSE PASSENGER VEHICLES. THE AFFECTED WHEELS WERE PRODUCED FROM JULY 30 THROUGH SEPTEMBER 20, 2000. THE THICKNESS OF THE STEEL WHEEL INBOARD OF THE AREA WHERE THE WHEEL RIM IS WELDED TO THE WHEEL DISK IS LESS THAN THE DESIGN SPECIFICATION.

Safety consequence

THIS CONDITION CAN LEAD TO CRACKING OF THE WHEEL, GRADUAL LOSS OF AIR IN THE TIRE, AND POSSIBLE LOSS OF VEHICLE CONTROL.

Manufacturer remedy

DEALERS WERE NOTIFIED TO REMOVE ANY OF THESE AFFECTED WHEELS FROM THE STOCK INVENTORY AND RETURN TO AMERICAN SUZUKI MOTOR COMPANY. SUZUKI WILL NOTIFY ANY END USERS WHICH PURCHASED THE REPLACEMENT WHEELS OF THE DEFECT AND TO RETURN THEIR WHEELS TO SUZUKI FOR A FREE REPLACEMENT.

Notes

DEALER NOTIFICATION BEGAN ON DECEMBER 20, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUZUKI AT 1-714-572-1490.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 1999 Suzuki Grand Vitara. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

108 owner complaints have been filed with NHTSA for the 1999 Suzuki Grand Vitara.

Service Brakes

ODI #11030588

Incident: September 5, 2017 · Filed: September 29, 2017

BRAKE LINE ROTTED AWAY ALL BRAKES AND FLUID LOST

Fuel/Propulsion System

ODI #10764563

Incident: January 1, 2008 · Filed: September 17, 2015

TL* THE CONTACT OWNS A 1999 SUZUKI GRAND VITARA. WHILE DRIVING APPROXIMATELY 5 MPH, A FUEL ODOR EMITTED INSIDE THE VEHICLE. WHEN THE VEHICLE WAS PARKED, THE CONTACT DISCOVERED FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 01V146000 (FUEL SYSTEM, GASOLINE) AND 04V427000 (FUEL SYSTEM, GASOLINE), BUT WAS NOT DIAGNOSED OR REPAIRED TO DUE THE MILEAGE OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.

Power Train; Fuel/Propulsion System

ODI #10496399

Incident: July 5, 2012 · Filed: February 4, 2013

THE VEHICLE AT HIGHWAY SPEEDS FROM 45 TO 55 MILES PER HOUR WILL LOSE COMPLETE POWER DROPPING FROM 45 OR 55 TO 10 OR 15 MPH VERY RAPIDLY WHEN THIS HAPPENS YOU HAVE NO CONTROL OF ACCELERATION OR VEHICLE TILL IT REACHES THE 10 TO 15 MPH RANGE LEAVING YOU IN A VERY DANGEROUS POSITION IF YOU ARE NOT CLOSE ENOUGH TO THE SHOULDER OF THE ROAD TO PULL OFF LEAVING YOU THE POSSIBILITY OF BEING IN A COLLISION WITH FASTER APPROACHING VEHICLES FROM THE REAR THIS IS A SERIOUS PROBLEM THAT COULD RESULT IN DEATH FROM A REAR END COLLISION AND APPEARS TO BE A COMMON PROBLEM WITH THIS VEHICLE. SOMETHING NEEDS TO BE DONE ABOUT THIS AND THE DEALERS HAVE NO EXPLANATION FOR THIS FAILURE. THIS HAS BEEN AN ON GOING PROBLEM FROM JULY OF 2012 TO THE CURRENT DATE OF 2/4/2013. *TR

Steering

ODI #10382635

Incident: June 14, 2010 · Filed: February 14, 2011

TL*THE CONTACT OWNS A 1999 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, SHE WOULD HEAR A LOUD SQUEAKING NOISE. ALSO WHEN SHE MADE TURNS AT LOW SPEEDS, THE NOISE GETS LOUDER. THE VEHICLE WAS INSPECTED BY SEVERAL INDEPENDENT MECHANICS AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000. THE VIN WAS UNAVAILABLE.

Vehicle Speed Control

ODI #10334873

Filed: June 7, 2010

CONSUMER EXPRESSES DISCONTENT REGARDING RECALL FROM SUZUKI CORPORATION *TGW THE CONSUMER STATED HE RECEIVED A RECALL LETTER STATING IT WAS THE SECOND NOTICE, BUT HE NEVER RECEIVED THE FIRST NOTICE. THE CONSUMER WAS TOLD THE REPAIRS WOULD NEED TO BE PERFORMED BY TRAINED MECHANIC WHICH WAS 80 MILES AWAY.

Service Brakes, Hydraulic

ODI #10216603

Incident: January 30, 2008 · Filed: January 31, 2008

TL*THE CONTACT OWNS A 1999 SUZUKI GRAND VITARA. THE CONTACT STATED THAT THE BRAKES MADE A GRINDING NOISE AND THE BRAKE ADJUSTMENT PIN IN THE REAR DRIVER SIDE WHEEL WAS LOOSE. THE SPRING THAT HELD THE WHEEL IN PLACE FAILED, WHICH ALLOWED IT TO MOVE FREELY INSIDE THE BRAKE DRUM. THE SPRING FLIPPED UP AND CAUSED THE BRAKE SHOE, DRUM, AND BRAKING KIT TO FAIL. PRIOR TO THE FAILURE, AAMCO INSPECTED THE REAR AND FRONT BRAKES AND STATED THAT THEY WERE 50% WORN. THE CONTACT PLACED THE WHEEL BACK ON THE VEHICLE AND DROVE APPROXIMATELY SIX BLOCKS WHEN HE HEARD THE NOISE. THE CONTACT TOOK THE VEHICLE BACK TO AAMCO BECAUSE THE GRINDING NOISE BECAME VERY LOUD. AAMCO STATED THAT THE FAILURE WAS NOT CAUSED BY THE INSPECTION. THE CONTACT CALLED SUZUKI'S CUSTOMER SERVICE LINE TO FIND OUT IF THE FAILURE WAS COMMON. SUZUKI STATED THAT NO ONE COULD TALK TO THEIR TECHNICAL DEPARTMENT UNLESS THEY WERE A DEALER. THE CONTACT NOTIFIED THE SUZUKI DEALER SO THAT THEY COULD CALL THE MANUFACTURER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 31,734.

Service Brakes, Hydraulic

ODI #10214831

Incident: November 10, 2007 · Filed: January 14, 2008

WHEN I BRAKE MY CAR PULLS TO ONE SIDE AND LOSES CONTROL. IT IS LIKE IT IS ON ICE AND ONE TIME IT SPUN AROUND, EVEN THOUGHT I WAS GOING SLOW. MY CAR IS REGULARLY MAINTAINED. *TR

Air Bags

ODI #10159127

Incident: July 22, 1999 · Filed: June 6, 2006

DT*: THE CONTACT STATED THE AIRBAG LIGHT IS CONSTANTLY ILLUMINATED. THE DEALERSHIP HAS REPLACED THE AIRBAG SYSTEM MODULE TWICE, BUT THE PROBLEM RETURNED. THE WINDSHIELD WIPERS WERE INOPERATIVE. UPDATED 06/19/06. *JB

Engine and Engine Cooling

ODI #10146941

Incident: December 25, 2005 · Filed: January 5, 2006

VEHICLE SUDDENLY AND UNEXPECTEDLY LOSES COMPLETE ENGINE POWER AT HIGHWAY SPEEDS AND VEHICLE SPEED RAPIDLY DROPS TO UNDER 10 MPH. ENGINE RUNS VERY ROUGH AND THERE IS NO RESPONSE WHEN DEPRESSING ACCELERATOR PEDAL. MUST IMMEDIATELY PULL OVER (IF POSSIBLE) AS VEHICLE IS NOT DRIVABLE. AFTER WAITING SEVERAL MINUTES, ENGINE OPERATION RETURNS TO NORMAL BUT POWER LOSS WILL USUALLY REOCCUR ANYTIME AS QUICKLY AS WITHIN THE NEXT SEVERAL MINUTES OR AS LONG AS A DAY OR TWO. ENGINE POWER LOSS MAY LAST AS LITTLE AS A MINUTE OR TWO OR FOR SEVERAL MINUTES AND CHECK ENGINE LIGHT COMES ON. *JB

Unknown or Other

ODI #10145321

Incident: November 1, 2005 · Filed: November 30, 2005

CONSUMER COMPLAINT REGARDING THERE NO LONGER BEING A SUZUKI DEALER IN HIS AREA AND CAN NOT GET RECALL WORK DONE. *TS *THE CONSUMER REQUESTED THAT SUZUKI COULD MAKE ARRANGEMENTS FOR THE INSTALLATION OF THE SAFETY RECALL. THE CONSUMER WOULD HAVE TO DRIVE 120 MILES IN ORDER TO HAVE THE VEHICLE REPAIRED. *SC

Other Suzuki Grand Vitara model years

Check your 1999 Suzuki Grand Vitara VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Suzuki Grand Vitara at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Suzuki VIN