NHTSA vehicle safety data

2007 Suzuki DL1000 Recalls & Complaints

The 2007 Suzuki DL1000 has 1 NHTSA recall campaign and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Suzuki dealer.

NHTSA recall and complaint data for the 2007 Suzuki DL1000. Recall data is refreshed daily from NHTSA.

2007 Suzuki DL1000 owner complaints

Owners have filed 4 complaints with NHTSA about the 2007 Suzuki DL1000, describing incidents dated April 23, 2007 to May 20, 2014.

Most-cited components

Electrical System 2 complaints
Engine 1 complaint
Fuel/Propulsion System 1 complaint
Suspension 1 complaint

Of the 4 complaints on file, 1 reports a crash; across all 4 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10593691 · Filed May 23, 2014
TL* THE CONTACT OWNS A 2007 SUZUKI DL1000 MOTORCYCLE. THE CONTACT STATED WHILE RIDING APPROXIMATELY 10 MPH THE MOTORCYCLE SUDDENLY STALLED CAUSING THE CONTACT TO LOSE CONTROL OF THE MOTORCYCLE AND CRASH. THE CONTACT SUSTAINED AN INJURY TO HIS LOWER RIGHT LEG. THE FAILURE WAS NOT DIAGNOSED NOR WAS…
ODI #10205323 · Filed October 10, 2007
TL*THE CONTACT OWNS A 2007 SUZUKI DL1000. WHEN THE CLUTCH IS DISENGAGED, THE ENGINE SHUTS DOWN. THE FAILURE WAS NOTICED WHILE RIDING 25 MPH. THE CONTACT WAS ABLE TO AVOID SEVERAL NEAR CRASHES. THE DEALER STATED THAT THERE WAS AN AFTER MARKET REPAIR THAT CONSISTED OF EXCHANGING THE FUEL JET TO ALLOW…
ODI #10189404 · Filed May 1, 2007
RE: 2007 SUZUKI DL1000 V-STROM 1000 MOTORCYCLE FALL-OVER INCIDENT WHILE STOPPED FOR A RED LIGHT, I ATTEMPTED TO PUT MY LEFT FOOT ON THE PAVEMENT. THE BOOT LACE ON MY LEFT BOOT SNAGGED ON THE EXPOSED AIR BLEEDER VALVE ON THE CLUTCH RELEASE CYLINDER NEXT TO MY BOOT AND JUST ABOVE THE GEAR SHIFT LEVER…

Read all 4 complaints

AFTERMARKET BRAKE LEVERS

NHTSA #08E052000 · Equipment · NHTSA notice

Reported August 15, 2008 · MOTION PRO, INC.

Potentially affected: 10,000 vehicles

Owners notified September 11, 2008

Defect description

MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE WHEN THE DRIVER RELEASES THE BRAKE LEVER. THE LEVER CAN BE IDENTIFIED BY THE MARKING "JY 378" AT THE BASE OF THE LEVER NEAR THE PIVOT BUSHING.

Safety consequence

IF THIS OCCURS, THE STOP LAMP WILL REMAIN ON WHICH COULD POSSIBLY RESULT IN A CRASH.

Manufacturer remedy

MOTION PRO WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT MOTION PRO AT 1-877-438-7831.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET MOTION PRO BRAKE LEVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON SUZUKI OR YAMAHA MOTORCYCLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Suzuki DL1000. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2007 Suzuki DL1000.

Electrical System; Engine

ODI #10593691

Crash 1 injury

Incident: May 20, 2014 · Filed: May 23, 2014

TL* THE CONTACT OWNS A 2007 SUZUKI DL1000 MOTORCYCLE. THE CONTACT STATED WHILE RIDING APPROXIMATELY 10 MPH THE MOTORCYCLE SUDDENLY STALLED CAUSING THE CONTACT TO LOSE CONTROL OF THE MOTORCYCLE AND CRASH. THE CONTACT SUSTAINED AN INJURY TO HIS LOWER RIGHT LEG. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 14,000. .... UPDATED 08/05/14 *BF UPDATED 08/11/2014*LJ THE CONSUMER STATED THE RECALLED VOLTAGE REGULATOR FAILURE TOOK OUT THE STATOR AND ROTOR. BURNING ONE AND DESTROYING THE OTHER. THE BATTERY OVERCHARGED AND FAILED. THE INJECTION MAPPER MAY HAVE BEEN TAKEN OUT BY A VOLTAGE SPIKE.. UPDATED 08/19/2014 *JS

Fuel System, Gasoline

ODI #10205323

Incident: October 10, 2007 · Filed: October 10, 2007

TL*THE CONTACT OWNS A 2007 SUZUKI DL1000. WHEN THE CLUTCH IS DISENGAGED, THE ENGINE SHUTS DOWN. THE FAILURE WAS NOTICED WHILE RIDING 25 MPH. THE CONTACT WAS ABLE TO AVOID SEVERAL NEAR CRASHES. THE DEALER STATED THAT THERE WAS AN AFTER MARKET REPAIR THAT CONSISTED OF EXCHANGING THE FUEL JET TO ALLOW THE FUEL TO DISTRIBUTE EVENLY. THE CURRENT MILEAGE WAS 1,000 AND FAILURE MILEAGE WAS 500.

Suspension

ODI #10189404

1 injury

Incident: April 23, 2007 · Filed: May 1, 2007

RE: 2007 SUZUKI DL1000 V-STROM 1000 MOTORCYCLE FALL-OVER INCIDENT WHILE STOPPED FOR A RED LIGHT, I ATTEMPTED TO PUT MY LEFT FOOT ON THE PAVEMENT. THE BOOT LACE ON MY LEFT BOOT SNAGGED ON THE EXPOSED AIR BLEEDER VALVE ON THE CLUTCH RELEASE CYLINDER NEXT TO MY BOOT AND JUST ABOVE THE GEAR SHIFT LEVER, CAUSING THE MOTORCYCLE TO FALL TO THE PAVEMENT ON ITS LEFT SIDE. I SUFFERED INJURIES TO MY LEFT WRIST AND UPPER LEFT BACK. THE MOTORCYCLE SUFFERED A BROKEN GEAR SHIFT LEVER, A BROKEN LEFT FRONT TURN SIGNAL, AND OTHER MINOR SCRAPES AND SCRATCHES. I NOTIFIED AMERICAN SUZUKI CORP. IN WRITING OF WHAT I BELIEVE TO BE A SERIOUS DESIGN DEFECT, WITH THE UNCOVERED AND UNPROTECTED AIR BLEEDER VALVE NEXT TO THE RIDER'S BOOT, AND SENT PHOTOS OF THE INCIDENT; HOWEVER, BRYAN MALYSZEK FROM AMERICAN SUZUKI CALLED ME ON 4/30/07 AND DISAVOWED ANY AMERICAN SUZUKI RESPONSIBILITY FOR THE INCIDENT. *TR

Electrical System

ODI #10189305

Incident: April 30, 2007 · Filed: April 30, 2007

BIKE BOGS DOWN IN 5TH OR 6TH UNLESS YOU KEEP IT REVED UP ABOVE 5K, CRUISING AROUND ALMOST SHUTS DOWN WHEN YOU GET BELOW 2500 RPMS. *AK

Other Suzuki DL1000 model years

Check your 2007 Suzuki DL1000 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Suzuki DL1000 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Suzuki VIN