2017 Subaru Crosstrek Recalls, Ratings & Complaints

Incident: September 24, 2025 · Filed: October 22, 2025

Premature shift fork failure in 2017 Subaru Crosstrek manual transmission at 62,521 miles requiring complete transmission replacement ($10,000 repair, vehicle worth $11,000). EVIDENCE OF DESIGN DEFECT: - Subaru issued TSB 03-83-20R acknowledging shift fork design flaws in 2018-2020 Crosstreks with identical transmission - TSB states original forks required "thicker nylon inserts" proving inadequate design - My VIN (HG269902) is before production change (LG225906), confirming defective pre-improvement design - Shift fork failure can cause sudden inability to shift gears while driving - significant safety hazard MAINTENANCE: Single owner, meticulously maintained with documented service at 20k, 39k, 52k, 58k miles. Never in accident. No abuse. MANUFACTURER RESPONSE: Subaru offered only $1,800 (18% coverage) and blamed my "driving habits" despite TSB proving design defect. REQUEST: NHTSA investigate shift fork failures in 2015-2017 Crosstreks and evaluate if TSB 03-83-20R should extend to these model years. See attached: Complete complaint documentation and TSB 03-83-20R.

Incident: September 28, 2025 · Filed: September 30, 2025

In August of 2024, I got into my car in a parking lot and turned the key in the ignition. The car started revving really high. I waited for it to slow down, and then I put it into reverse. The car shot back and would have hit the building if I hadn't slammed on the brakes. Fortunately, there wasn't anyone behind the car at the time, but the woman who had just walked in back of my car to enter the building stood there looking at me. I slowly put my foot on the gas pedal and drove home. The following day, I had a tow truck come and take the car to the dealer. They did a scheduled maintenance service and replace the throttle body. Everything was fine until 9/28/25. I was driving out of a parking lot and entering the street going very slowly, suddenly the car lurched forward very fast, and I had to slam on my brakes to stop it. I drove it home. I notified a friend who knew a mechanic that he said was familiar with this type of issue. He got in touch with the dealership where the car had been serviced, and I got a call from the Service Department manager. He asked me to bring the car in so they could try to find out what the problem was. He said that if they couldn't find out what it was, an engineer might be called in to inspect the car. I am planning on having the car towed to the dealership this week. On neither occasion did any warning lights come on in the car. It was very fortunate that no one was hurt during either incident, but it could have been tragic. I was only about 15 feet away from a crosswalk when the second incident occurred. I read online that the manufacturer is involved in a lawsuit where several other people have had the same experience, although not the same model as my car. I have driven the same brand of car for about fifteen years and have never had a problem before.

Incident: May 5, 2025 · Filed: August 2, 2025

The harness on my child's Nuna RAVA loosened during a 30 minute drive home (highway and downtown driving) in May of 2025. I learned later that month that there is a recall on Nuna Ravas for that exact reason. It is available for inspection. My child was not properly secured, and I did not know it until we got home; he could have been killed or seriously injured had we gotten into a collision on that drive. The car seat has not been inspected by anyone. Nuna offered me a “remedy kit” with a screwdriver, a brush, and a mismatched fabric cover, but I am not a safety technician and do not have the time or expertise to take the seat apart myself and still trust it to secure my child. The problem with the harness straps we have is intermittent, and does not replicate when the car is parked and I simply “tug” on the straps. I do not feel that this is an adequate safety test anyway, as it doesn’t replicate the forces or conditions in an accident. I requested a replacement seat, but Nuna denied my request on 7/21 and again on 7/28. Nuna has not supplied crash test results on layperson “repaired” car seats. This defect is the subject of NHTSA actions DP24003 and PE24026. Other RAVA owners have complained that their repaired RAVA still malfunctioned even after using Nuna's "remedy kit." I would like a replacement car seat to ensure my child's safety.

Incident: January 19, 2024 · Filed: March 6, 2024

On January 19, 2024 I was slowly pulling in to a parking spot at my doctors office. I did not pull up far enough, as there was a concrete retaining wall at the head of the spot and no tire block for safety. I was maybe 5 feet from the wall when I lightly tapped the gas pedal to inch up (as the back end of the car was sticking out into the passing lane). When I did so, the car slipped into rapid acceleration causing a full head on crash with the retaining wall. I had pressed the break pedal but the brakes did not have enough time to engage before the wall stopped my car. As a result, I had bumper damage, a crooked hood (due to bent hinge on the right side) and a cracked bracket above the light assembly. Thankfully I was not injured, but the repair was costly. I leased this car new in 2017, and am paying off end of lease buyout. I have been the only driver, and I bring my car for regular servicing. At this point I am afraid to drive it because I don't know when or where the next rapid acceleration will occur.

Incident: February 8, 2024 · Filed: February 8, 2024

There is a battery draining problem. I have had to replace the battery 3 times in a two-year period.

Incident: December 1, 2023 · Filed: January 31, 2024

Wheel bearing go out after 40K plus miles. After doing research on my own wheels bearings it appears that this is a very common issue for this vehicle. This is not a lot of miles to have on a car before wheel bearings (rear) go bad. Causing extensive damage if not caught and a safety hazard for those opporating the vehicle.

Incident: August 1, 2023 · Filed: August 23, 2023

The car has 26,000 miles and the heat shield over the muffler has shifted and causing a grinding sound against the back wheel. Told the shield had rusted and needed replacement. There were no warning lights, just the grinding sound from the rear of the car.

Incident: July 1, 2023 · Filed: August 18, 2023

Greetings: As outlined in Service Bulletin 05-70-19, Rear Wheel Backing Plate Design change, I am having an almost overwhelming “whining or humming” sound coming from the rear portion of my vehicle. Given the significance of this WHEEL BEARING & BACKING PLATE issue, I respectfully request an RECALL & subsequent repair be initiated. Coupled with a VERY large number of related customer issues - globally - this issue should have already met-the-bar for a RECALL vs. Safety Bulletin. It’s obvious there are safety-related design flaws - again, given the overall number of required repairs - and this should be addressed accordingly. Thank you.

Incident: May 13, 2023 · Filed: May 16, 2023

Both of the front inner brake pads separated from the backing plate presenting a safety concern since the brake performance was compromised. The front outer brake pads did not separate from the backing plates. All four brake pads were installed by myself along with new rotors in November 2021 and have experienced about 30,000 miles of use. There is plenty of brake pad material remaining. I have experience installing brakes on multiple vehicles and the pads were functional until the pad/backing plate separation. I discovered the issue after hearing a grinding noise from the wheel well while driving. No warning lights were present and other symptoms were not immediately noticeable. The part is available for inspection upon request; however, I was planning on sending both of the defective brake pads to the manufacturer for a warranty claim. I can save one of the two pads for NHTSA inspection, if desired. Please let me know as soon as possible.

Incident: January 28, 2023 · Filed: March 14, 2023

- cam carrier leak, resulting in oil leaking from engine. oil is leaking onto catalytic converter sensor causing it to malfunction. - oil leaking from cars poses a safety and environmental hazard. - michael's subaru of bellevue (washington state) has confirmed it occurring, and it is a problem across subaru models according to a number of forum posts from subaru owners, which has been shared with subaru of america. - i have not had it inspected by anyone officially besides michael's subaru of bellevue (washington state). - there was a warning lamp for the catalytic converter, but upon physical inspection of the vehicle the technician discovered it was oil leaking from the cam carrier onto the sensor that caused the warning lights to turn on in the vehicle. - i have included emails i exchanged with subaru of america regarding the issue.