NHTSA vehicle safety data

2009 Starcraft Lexion Recalls & Complaints

The 2009 Starcraft Lexion has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Starcraft dealer.

NHTSA recall and complaint data for the 2009 Starcraft Lexion. Recall data is refreshed daily from NHTSA.

2009 Starcraft Lexion owner complaints

Owners have filed 2 complaints with NHTSA about the 2009 Starcraft Lexion, describing incidents dated April 5, 2009 to July 30, 2010.

Most-cited components

Power Train 1 complaint
Structure 1 complaint

Newest complaints

ODI #10347221 · Filed August 4, 2010
TL* THE CONTACT OWNS A 2009 STARCRAFT STAR STREAM RV. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE CONTACT OBSERVED A LOUD NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE THEN BEGAN TO DRAG FROM THE REAR. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR FACILITY WHERE THE CONTACT WAS INFORMED THAT A…
ODI #10281755 · Filed August 25, 2009
TL*THE CONTACT OWNS A 1998 SUNDOWNER VALUE-LITE HORSE TRAILER. THE HORSE TRAILER WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE. THE TECHNICIAN DISCOVERED THE STRUCTURAL FRAME EXHIBITED SEVERE RUST CORROSION. THERE WAS AN ESTIMATED COST OF $8,000 FOR THE REPLACEMENT OF THE FRAME. THE…

Read all 2 complaints

MISSING GROUND WIRE/JAYCO

NHTSA #09V106000 · Electrical System — Wiring · NHTSA notice

Reported April 1, 2009 · STARCRAFT RV, INC.

Potentially affected: 12 vehicles

Owners notified April 6, 2009 · Vehicles built June 23, 2008 – October 20, 2008 (per NHTSA)

Defect description

STARCRAT IS RECALLING 12 MY 2009 LEXION SERIES 32RLTS, 34IKTS, AND 36RLTS FIFTH WHEEL TRAILERS. THERE MAY BE A MISSING GROUND WIRE BETWEEN THE TRAILER FRAME AND THE 12-VOLT BUS BAR.

Safety consequence

IF THIS CONDITION IS NOT ADDRESSED, IT MAY RESULT IN A FIRE, INJURY OR DEATH.

Manufacturer remedy

DEALERS WILL INSTALL THE APPROPRIATE GROUND WIRE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR APRIL 6, 2009. OWNERS MAY CONTACT STARCRAFT AT 1-800-945-4787.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2009 Starcraft Lexion. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2009 Starcraft Lexion.

Power Train

ODI #10347221

Incident: July 30, 2010 · Filed: August 4, 2010

TL* THE CONTACT OWNS A 2009 STARCRAFT STAR STREAM RV. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE CONTACT OBSERVED A LOUD NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE THEN BEGAN TO DRAG FROM THE REAR. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR FACILITY WHERE THE CONTACT WAS INFORMED THAT A SPRING WITHIN THE REAR AXLE WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 4,000.

Structure

ODI #10281755

Incident: April 5, 2009 · Filed: August 25, 2009

TL*THE CONTACT OWNS A 1998 SUNDOWNER VALUE-LITE HORSE TRAILER. THE HORSE TRAILER WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE. THE TECHNICIAN DISCOVERED THE STRUCTURAL FRAME EXHIBITED SEVERE RUST CORROSION. THERE WAS AN ESTIMATED COST OF $8,000 FOR THE REPLACEMENT OF THE FRAME. THE TRAILER HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. BL

Other Starcraft Lexion model years

Check your 2009 Starcraft Lexion VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Starcraft Lexion at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Starcraft VIN