NHTSA vehicle safety data

2005 Spartan Mountain Master Recalls & Complaints

The 2005 Spartan Mountain Master has 1 NHTSA recall campaign and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Spartan dealer.

NHTSA recall and complaint data for the 2005 Spartan Mountain Master. Recall data is refreshed daily from NHTSA.

2005 Spartan Mountain Master owner complaints

Owners have filed 1 complaint with NHTSA about the 2005 Spartan Mountain Master, describing incidents dated May 24, 2006.

Most-cited components

Seat Belts 1 complaint

Newest complaints

ODI #10158454 · Filed May 28, 2006
I PURCHASED A 2005 TRAVEL SUPREME MOTORHOME, MODEL 42DS04 IN APRIL OF 2005. THE UNIT WAS PROVIDED WITH A SLEEPER SOFA WHICH SLEEPS TWO ADULTS. THE BEDROOM ALSO SLEEPS TWO ADULTS. I BELIEVE THAT THE UNIT SHOULD BE EQUIPPED WITH SEAT BELTS FOR A MINIMUM OF FOUR PEOPLE. WHILE RESEARCHING THE SITUATION…

Read the full complaint

BATTERY CABLE ROUTING

NHTSA #05V273000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice

Reported June 8, 2005 · SPARTAN CHASSIS, INC.

Potentially affected: 1,298 vehicles

Spartan campaign SPEC 05020 · Owners notified July 26, 2005 · Vehicles built May 1, 2004 – May 24, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE HARNESS AND CABLES WERE ROUTED INCORRECTLY. SHARP CASTING EDGES OF THE TRANSMISSION LIFTING EAR CUT INTO THE CABLES OR THE WIRE HARNESS.

Safety consequence

SMOKE MAY OCCUR WHICH MAY NOT BE VISIBLE TO THE DRIVER AND AN ELECTRICAL SHORT MAY OCCUR WHICH COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REROUTE THE HARNESS AND CABLES AWAY FROM THE TRANSMISSION LIFTING EAR, AVOIDING THE CASTED PART WHICH WAS THE SOURCE OF CHAFFING. THE RECALL BEGAN ON JULY 26, 2005. OWNERS MAY CONTACT SPARTAN AT 517-543-6400.

Notes

SPARTAN RECALL NO. SPEC 05020.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Spartan Mountain Master. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2005 Spartan Mountain Master.

Seat Belts

ODI #10158454

Incident: May 24, 2006 · Filed: May 28, 2006

I PURCHASED A 2005 TRAVEL SUPREME MOTORHOME, MODEL 42DS04 IN APRIL OF 2005. THE UNIT WAS PROVIDED WITH A SLEEPER SOFA WHICH SLEEPS TWO ADULTS. THE BEDROOM ALSO SLEEPS TWO ADULTS. I BELIEVE THAT THE UNIT SHOULD BE EQUIPPED WITH SEAT BELTS FOR A MINIMUM OF FOUR PEOPLE. WHILE RESEARCHING THE SITUATION I FOUND A RECALL, 06V002 WHICH COVERED A SIMILAR SITUATION WHERE NERVE HAD FAILED TO PROVIDE SEAT BELTS CONSISTENT WITH THE SLEEPING ACCOMMODATIONS OF THREE MODELS OF THEIR MOTORHOMES. I DISCUSSED THIS WITH THE CUSTOMER SERVICE MANAGER AT TRAVEL SUPREME AND HE TOLD ME THAT THEY (TRAVEL SUPREME) INSTALLED A STICKER IN THE BEDROOM THAT SPECIFIED THE SLEEPING CAPACITY OF THE MOTORHOME WAS TWO PEOPLE AND THAT RELIEVED THE MANUFACTURER FROM BEING REQUIRED TO INSTALL SEAT BELTS CONSISTENT WITH THE ACTUAL SLEEPING ACCOMMODATIONS. THEY WERE WILLING TO INSTALL ADDITIONAL SEATBELTS, AT A COST TO ME, WHICH I HAD THEM DO. *JB

Other Spartan Mountain Master model years

Check your 2005 Spartan Mountain Master VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Spartan Mountain Master at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Spartan VIN