NHTSA vehicle safety data

2004 Safari Coach Cheetah Recalls & Complaints

The 2004 Safari Coach Cheetah has 3 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Safari Coach dealer.

NHTSA recall and complaint data for the 2004 Safari Coach Cheetah. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Safari Coach Cheetah owner complaints

Owners have filed 4 complaints with NHTSA about the 2004 Safari Coach Cheetah, describing incidents dated December 1, 2004 to March 6, 2009.

Most-cited components

Suspension 3 complaints
Electrical System 1 complaint
Steering 1 complaint

Newest complaints

ODI #10290461 · Filed October 31, 2009
THE MOTORHOME (MH) WAS BROUGHT IN TO TRUCK REPAIR FACILITY FOR ALIGNMENT OF REAR AXLE DUE TO EXCESSIVE TIRE WEAR ATTRIBUTED TO REAR AXLE MISALIGNMENT. WHEN TECH'S GOT UNDER THE MH IT WAS FOUND THAT BOTH TRAILING ARMS WERE CRACKED WHERE THE AXLE MOUNTS TO THE ARMS. ONE WAS SLIGHTLY CRACKED, THE OTHER…
ODI #10133201 · Filed August 17, 2005
DT: THE CONSUMER STATED ON 2004 SAFARI CHEETAH MOTOR HOME MONACO THE GENERATOR ROLLED OUT OF ITS LATCHES. IT ROLLED FORWARD TO THE END OF THE STOP. THE GENERATOR WAS ON RAILS AND LATCHES DOWN. THERE WERE BOLTS ON EACH SIDE THAT WERE SUPPOSE TO HOLD THE GENERATOR IN PLACE. THE BOLTS BROKE AND THE…
ODI #10105897 · Filed January 6, 2005
THIS COMPLAINT IS IN REGARD TO A SAFARI TREK 31 MOTORHOME MANUFACTURED BY MONACO COACH CORP VIN # [XXX]. THE COACH IS ON A WORKHORSE 22 CHASSIS MANUFACTURED BY WORKHORSE CUSTOM CHASSIS LLC. THE PROBLEM IS THE STEERING AND SUSPENSION PROVIDE UNSAFE HANDLING. THE COACH "RABBIT HUNTS", BOUNDS, SWAYS…

Read all 4 complaints

TRAILING ARMS/SUSPENSION

NHTSA #05V053000 · Suspension — Rear — Springs — Leaf Spring Assembly · NHTSA notice

Reported February 14, 2005 · MONACO COACH CORPORATION

Potentially affected: 2,827 vehicles

Manufacturer campaign R04062 · Owners notified March 29, 2005 · Vehicles built November 30, 2001 – October 1, 2004 (per NHTSA)

Defect description

ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.

Safety consequence

THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.

Manufacturer remedy

DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Notes

MONACO RECALL NO. R04062.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

MONACO/I-BEAM IMITATOR

NHTSA #04V038000 · Suspension — Front · NHTSA notice

Reported January 28, 2004 · MONACO COACH CORPORATION

Potentially affected: 2,156 vehicles

Manufacturer campaign R03024 · Owners notified March 1, 2004 · Vehicles built February 4, 2002 – October 24, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.

Safety consequence

THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.

Notes

MONACO RECALL NO. R03024.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

MONACO/CERTIFICATION LABEL/INCORRECT PSI

NHTSA #03V526000 · Equipment — Other — Labels · NHTSA notice

Reported December 12, 2003 · MONACO COACH CORPORATION

Potentially affected: 121 vehicles

Manufacturer campaign RO3056 · Owners notified January 7, 2004 · Vehicles built November 11, 2002 – October 24, 2003 (per NHTSA)

Defect description

CERTAIN 36', 38', AND 40' MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF PART 567, "CERTIFICATION." THE REAR PSI STATES 85 OR 115 LBS. THE CORRECT REAR PSI IS 95 LBS.

Safety consequence

UNDER OR OVER-INFLATED TIRES CAN CAUSE PREMATURE TIRE FAILURE AND COULD RESULT IN A SUDDEN BLOWOUT OR OTHER FAILURE RESULTING IN A LOSS OF CONTROL OF THE MOTORHOME.

Manufacturer remedy

DEALERS WILL INSTALL THE CORRECT LABELS AT NO CHARGE. OWNER NOTIFICATION BEGAN JANUARY 7, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-477-6226.

Notes

MONACO RECALL NO. R03056.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2004 Safari Coach Cheetah. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2004 Safari Coach Cheetah.

Suspension

ODI #10290461

Incident: March 6, 2009 · Filed: October 31, 2009

THE MOTORHOME (MH) WAS BROUGHT IN TO TRUCK REPAIR FACILITY FOR ALIGNMENT OF REAR AXLE DUE TO EXCESSIVE TIRE WEAR ATTRIBUTED TO REAR AXLE MISALIGNMENT. WHEN TECH'S GOT UNDER THE MH IT WAS FOUND THAT BOTH TRAILING ARMS WERE CRACKED WHERE THE AXLE MOUNTS TO THE ARMS. ONE WAS SLIGHTLY CRACKED, THE OTHER WAS CRACKED APPROX 75% THROUGH. HAD EITHER ARM BROKEN COMPLETELY THROUGH THE MH BODY WOULD HAVE DROPPED DOWN WITH POSSIBLE CATASTROPHIC RESULTS. MILEAGE AT THIS TIME WAS APPROX 52,000. BOTH OF THESE ARMS HAD BEEN PREVIOUSLY REPLACED BY MONACO AT APPROX 17,000 MILE UNDER RECALL IN JULY OF 2005. BOTH ARMS REPLACED AT THIS TIME WITH THE SAME TYPE OF ARMS THAT CRACKED AS THERE WERE NO ALTERNATIVE ARMS AVAILABLE. EXPERIENCE BY OTHER OWNERS WITH SAME PROBLEM HAS SHOWN THAT IN ALL LIKELIHOOD THESE REPLACEMENT ARMS WILL ALSO BREAK. *TR

Electrical System

ODI #10133201

Incident: June 6, 2005 · Filed: August 17, 2005

DT: THE CONSUMER STATED ON 2004 SAFARI CHEETAH MOTOR HOME MONACO THE GENERATOR ROLLED OUT OF ITS LATCHES. IT ROLLED FORWARD TO THE END OF THE STOP. THE GENERATOR WAS ON RAILS AND LATCHES DOWN. THERE WERE BOLTS ON EACH SIDE THAT WERE SUPPOSE TO HOLD THE GENERATOR IN PLACE. THE BOLTS BROKE AND THE GENERATOR ROLLED. THE CONSUMER TALKED TO THE FACTORY REPAIR CENTER, AND HAD THE PROBLEM FIXED. THE CONSUMER WANTED TO BE SURE THAT THIS WAS REPORTED. *AK

Steering; Suspension

ODI #10105897

Incident: December 1, 2004 · Filed: January 6, 2005

THIS COMPLAINT IS IN REGARD TO A SAFARI TREK 31 MOTORHOME MANUFACTURED BY MONACO COACH CORP VIN # [XXX]. THE COACH IS ON A WORKHORSE 22 CHASSIS MANUFACTURED BY WORKHORSE CUSTOM CHASSIS LLC. THE PROBLEM IS THE STEERING AND SUSPENSION PROVIDE UNSAFE HANDLING. THE COACH "RABBIT HUNTS", BOUNDS, SWAYS, AND ROCKS FROM SIDE TO SIDE TO THE POINT WHERE IT IS NEARLY UNCONTROLLABLE. TO DATE I HAVE ADDED A TRUE CENTER STEERING CONTROL SYSTEM MADE BY BLUE OX. THIS HELPED THE STEERING PROBLEM, BUT DID NOT CORRECT IT OR THE OTHER UNSAFE HANDLING CHARACTERISTICS. THE DEALER WHO SOLD US THE UNIT INDICATED THAT WORKHORSE HAD A "FIX" THAT INVOLVED REPLACING THE SHOCK ABSORBERS WITH HEAVY DUTY SHOCK ABSORBERS AND ADDING A ANTI-SWAY BAR. THESE I WAS INFORMED MUST BE PAID FOR BY THE OWNER. WORKHORSE AND SAFARI DID NOT AGREE TO FIX THIS KNOWN HANDLING SAFETY PROBLEM EVEN THOUGH THEY ARE AWARE OF IT AND KNOW THE "FIX". *AK UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Suspension

ODI #10081925

Filed: June 28, 2004

RECALL REGARDING 2004 SAFARI CHEETAH'S FRONT SUSPENSION.*MR THE DEALER NEVER DISCLOSED THE RECALL AT THE TIME THE VEHICLE WAS PURCHASED. THE RECALL WAS FOR THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION AND THE REAR AXLE PANARD BAR. THE RECALL STATED THAT THEY HAD FAULTY WELDS THAT COULD CRACK AND CAUSE THE DRIVER TO LOSE CONTROL AND CRASH. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT THE REAR REPAIRS HAD BEEN DONE BUT THE FRONT HAD NOT. THE MECHANIC ASSURED THE CONSUMER THAT THE WELDS WERE HOLDING AND NO CRACKS WERE VISUALLY EVIDENT. THE CONSUMER CONTACTED THE MANUFACTURER WHO ORDERED THE PARTS FOR THE RECALL. THE VEHICLE WAS FINALLY REPAIRED. *NM

Other Safari Coach Cheetah model years

Check your 2004 Safari Coach Cheetah VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Safari Coach Cheetah at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Safari Coach VIN