try.vin
Log in

NHTSA vehicle safety data

1999 Rexhall Aerbus Recalls & Complaints

The 1999 Rexhall Aerbus has 2 NHTSA recall campaigns and 5 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Rexhall dealer.

NHTSA recall and complaint data for the 1999 Rexhall Aerbus. Recall data is refreshed daily from NHTSA.

1999 Rexhall Aerbus owner complaints

Owners have filed 5 complaints with NHTSA about the 1999 Rexhall Aerbus, describing incidents dated November 5, 1999 to June 20, 2012.

Most-cited components

  • Power Train 3 complaints
  • Electrical System 1 complaint
  • Service Brakes 1 complaint

Newest complaints

  • ODI #10467600 · Filed

    BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO…

  • ODI #870845 · Filed

    ANTI-LOCK BRAKING SYSTEM HAS CAUGHT OVERHEATED AND LOCKED UP A COUPLE OF TIMES. MASTER CYLINDER WAS REPLACED, BUT DID NOT STOP THE PROBLEMS. DEALER HAS BEEN CONTACTED. *AK

  • ODI #854877 · Filed

    ON FORD CHASSIS, BOLT THAT HOLD THE DRIVELINE WHICH GOES INTO THE TRANSMISSION, SHEARED OFF WHICH MAY CAUSE A CRASH. *AK

Read all 5 complaints

REFRIGERATOR/DOMETIC

NHTSA #07V417000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported September 5, 2007 · REXHALL INDUSTRIES INC

Potentially affected: 2,345 vehicles

Owners notified July 4, 2008 · Vehicles built June 1, 1998 – June 30, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE REFRIGERATOR BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

REXHALL WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 4, 2008. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR REXHALL AT 1-661-726-0565.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REXHALL/DRIVE SHAFT BOLTS

NHTSA #01V163000 · Power Train — Driveline — Driveshaft · NHTSA notice

Reported May 9, 2001 · REXHALL INDUSTRIES

Potentially affected: 823 vehicles

Owners notified November 3, 2000 · Vehicles built January 1, 1998 – December 31, 1999 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: MOTOR HOMES. THE DRIVE SHAFT BOLTS CAN COME LOOSE AT THE TRANSMISSION AND FALL OFF. WHEN THE DRIVE SHAFT SEPARATES FROM THE TRANSMISSION, THE FORWARD END OF THE SHAFT CAN DROP TO THE GROUND, OR COME THROUGH THE FLOORBOARDS OF THE MOTOR HOME.

Safety consequence

THIS COULD LEAD TO LOSS OF VEHICLE CONTROL AND/OR THE DRIVE SHAFT CONTACTING A FOLLOWING VEHICLE.

Manufacturer remedy

DEALERS WILL REPLACE THE BOLTS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2000. ALL VEHICLES HAVE BEEN REPAIRED.

Other Rexhall Aerbus model years

Check your 1999 Rexhall Aerbus VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Rexhall Aerbus at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Rexhall VIN