NHTSA vehicle safety data

2004 R-Vision TRAIL-LITE B+ Recalls & Complaints

The 2004 R-Vision TRAIL-LITE B+ has 1 NHTSA recall campaign and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized R-Vision dealer.

NHTSA recall and complaint data for the 2004 R-Vision TRAIL-LITE B+. Recall data is refreshed daily from NHTSA.

2004 R-Vision TRAIL-LITE B+ owner complaints

Owners have filed 1 complaint with NHTSA about the 2004 R-Vision TRAIL-LITE B+, describing incidents dated July 3, 2015.

Most-cited components

Electrical System 1 complaint
Exterior Lighting 1 complaint
Vehicle Speed Control 1 complaint

Newest complaints

ODI #10745566 · Filed August 1, 2015
WE SMELLED THE ODOR OF BURNING RUBBER/WIRE. WE LOST SIGNAL INDICATORS, BRAKE LIGHTS, BACK UP LIGHTS AND THE CRUISE CONTROL KICKED OFF WHENEVER WE ATTEMPTED TO SIGNAL. WE CHANGED FUSES SEVERAL TIMES, HOWEVER THEY CONTINUED TO BLOW WITHIN A SHORT TIME. WE TOOK IT INTO A CAMPING WORLD FACILITY IN…

Read the full complaint

SPEED CONTROL DEACTIVATION SWITCH/FORD

NHTSA #06V363000 · Vehicle Speed Control · NHTSA notice

Reported September 21, 2006 · R-VISION

Potentially affected: 135 vehicles

Defect description

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Safety consequence

OVERHEATING COULD RESULT IN SMOKE OR BURN AND IN AN UNDERHOOD FIRE.

Manufacturer remedy

FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286). DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR R-VISION AT 574-268-2111.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2004 R-Vision TRAIL-LITE B+. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2004 R-Vision TRAIL-LITE B+.

Electrical System; Exterior Lighting; Vehicle Speed Control

ODI #10745566

Incident: July 3, 2015 · Filed: August 1, 2015

WE SMELLED THE ODOR OF BURNING RUBBER/WIRE. WE LOST SIGNAL INDICATORS, BRAKE LIGHTS, BACK UP LIGHTS AND THE CRUISE CONTROL KICKED OFF WHENEVER WE ATTEMPTED TO SIGNAL. WE CHANGED FUSES SEVERAL TIMES, HOWEVER THEY CONTINUED TO BLOW WITHIN A SHORT TIME. WE TOOK IT INTO A CAMPING WORLD FACILITY IN GEORGIA (WE WERE ON VACATION FROM SOUTH DAKOTA). THEY SAID IT HAD TO BE REWIRED. THEY GOT IT WORKING AND WE CONTINUED ON OUR WAY. THE CAMPING WORLD COMPANY FAILED TO AFFIX THE TAIL LIGHT PROPERLY AND WE HAD TO GET IT SERVICED AGAIN IN ALABAMA. THE PARTS WERE UNAVAILABLE SO WE HAD THEM SHIPPED TO LOUISIANA. WE DROVE WITHOUT PROPER LIGHTING TO LOUISIANA WHERE WE HAD THE RV SERVICED AGAIN. EACH SERVICE PROVIDER TOLD US THE RV WAS NOT WIRED PROPERLY, WHEN WE RETURNED HOME, WE TOOK THE RV TO A PRIVATE REPAIRMAN. HE FIXED THE RV BUT TOLD US THE RV WAS WIRED INCORRECTLY WHEN IT WAS BUILT. THE WIRES RUN ALONG THE FRAME AND ARE CUT BY THE LEAF SPRING WHENEVER WE HIT A BUMP. THIS IS A SAFETY ISSUE FOR SEVERAL REASONS: BRAKING, DIRECTION CHANGE, BACK UP. MORE SERIOUSLY WE CARRY PROPANE AND RUN ON GASOLINE. TO REWIRE THE RV WILL COST UPWARD OF $1000.00 IN ADDITION TO THE $800 WE ALREADY SPENT. WE HAVE THE BILLS WE PAID AS WELL AS THE STATEMENT WRITTEN BY THE LAST REPAIRMAN IF THAT INFORMATION IS NEEDED.

Other R-Vision TRAIL-LITE B+ model years

Check your 2004 R-Vision TRAIL-LITE B+ VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your R-Vision TRAIL-LITE B+ at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a R-Vision VIN