try.vin
Log in

NHTSA vehicle safety data

2001 Newmar Mountain Aire Recalls & Complaints

The 2001 Newmar Mountain Aire has 7 NHTSA recall campaigns and 5 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Newmar dealer.

NHTSA recall and complaint data for the 2001 Newmar Mountain Aire. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Newmar Mountain Aire owner complaints

Owners have filed 5 complaints with NHTSA about the 2001 Newmar Mountain Aire, describing incidents dated June 8, 2005 to June 20, 2014.

Most-cited components

  • Fuel/Propulsion System 2 complaints
  • Electrical System 1 complaint
  • Engine 1 complaint
  • Equipment 1 complaint
  • Service Brakes 1 complaint
  • Structure 1 complaint

Newest complaints

  • ODI #10641506 · Filed

    VEHICLE RUNNING NORMALLY, ACCELERATED TO MERGE WITH TRAFFIC, ENGINE BEGAN TO MISS THEN BACKFIRED. MISS CONTINUED AND THE VEHICLE WOULDN'T ACCELERATE PAST 55 MPH. PULLED TO SIDE OF THE ROAD TO CHECK FOR ANY VISUAL PROBLEMS, NONE NOTED. ENGINE STARTED NORMALLY AND I FINISHED THE 30 MILE DRIVE HOME…

  • ODI #10418562 · Filed

    I CARRIED MY 2001 NEWMAR MOUNTAIN AIRE, TO DANNY'S RV REPAIR IN DENTON, TX DUETO RECALL 51101-C WORKHRSE REFUSED TO HONOR THE (A) RIGHT FRONT PART# W8001709, $50.91 . AND THE LABOR FOR RIGHT REAR ABSCODE APPEARED ON TEST DRIVE) AND THE RF, LR, LABOR @ 29.40 EACH= $88.20 . I PAID OUT OF POCKET FOR…

  • ODI #10176835 · Filed

    TL* - THE CONTACT'S DOMETIC REFRIGERATOR IN HER 2001 NEWMAR MOUNTAIN AIRE HAD A PETITE CRACK IN THE BOILER TUBE. THE CRACK CAUSED A SUFFICIENT AMOUNT OF SOLUTION/GAS TO BE RELEASED INTO THE AIR. THE CONTACT HAS REPLACED THE DOMETIC REFRIGERATOR WHICH IS ALSO LISTED IN THE RV MAGAZINE AS A RECALL.

Read all 5 complaints

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V809000 · Equipment · NHTSA notice

Reported December 15, 2017 · Newmar Corporation

Potentially affected: 34,699 vehicles

Repair completion: 6.32% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Newmar campaign 17E-062 · Owners notified February 7, 2018 · Vehicles built July 24, 1997 – November 3, 2017 (per NHTSA)

Defect description

Newmar Corporation (Newmar) is recalling various 1995-2018 motorhomes. A list of the affected vehicles available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V809-2309.pdf. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Newmar will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 7, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information or owners may contact Newmar customer service at 1-574-773-7791. Newmar's number for this recall is 17E-062.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Steering Gear Mounting Bracket may Crack

NHTSA #15V829000 · Steering · NHTSA notice

Reported December 9, 2015 · Newmar Corporation

Potentially affected: 1,920 vehicles

Repair completion: 7.08% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Newmar campaign 15V 633 · Owners notified January 4, 2016 · Vehicles built January 5, 1997 – May 26, 2005 (per NHTSA)

Defect description

Newmar Corporation (Newmar) is recalling certain model year 1997-2005 Dutch Star and Mountain Aire, 1998-1999 London Aire, 2004 Essex and 1997-1998 Kountry Aire motorhomes. The affected vehicles have a steering gear mounting bracket that may crack, causing a loss of steering ability.

Safety consequence

A loss of steering increases the risk of a crash.

Manufacturer remedy

Newmar will notify owners, and Spartan dealers will replace the steering gear mounting brackets, free of charge. The recall began on January 4, 2016. Owners may contact Newmar customer service at 1-800-731-8300 or Spartan customer service at 1-800-543-4277. Newmar's number for this recall is 15V 633.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE

NHTSA #09V217000 · Service Brakes, Hydraulic · NHTSA notice

Reported June 11, 2009 · NEWMAR CORPORATION

Potentially affected: 2,578 vehicles

Owners notified May 1, 2009 · Vehicles built July 24, 2000 – March 18, 2009 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

NEWMAR IS RECALLING 2,578 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Safety consequence

THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SPEED CONTROL DEACTIVATION SWITCH/FORD

NHTSA #08V025000 · Vehicle Speed Control · NHTSA notice

Reported January 24, 2008 · NEWMAR CORPORATION

Potentially affected: 5,575 vehicles

Newmar campaign 05S28 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN CLASS A MOTOR HOMES CONSTRUCTED ON FORD F-53TY1 AND P131 MOTOR HOME CHASSIS AND EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Safety consequence

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Manufacturer remedy

NEWMAR IS WORKING WITH FORD IN CONDUCTING THIS RECALL. FORD WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR NEWMAR AT 574-773-7791. (NOTE: ALSO SEE FORD RECALLS 05V017, 05V388, AND 06V286)

Notes

NEWMAR RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #07V075000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 5, 2007 · NEWMAR CORPORATION

Potentially affected: 16,190 vehicles

Owners notified January 30, 2008 · Vehicles built April 1, 1997 – May 31, 2003 (per NHTSA)

Defect description

CERTAIN CLASS A AND DIESEL PUSHER MOTOR HOMES AND FIFTH WHEEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

NEWMAR WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR NEWMAR AT 1-574-773-7791.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

NEWMAR/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V064000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported March 26, 2003 · NEWMAR CORPORATION

Potentially affected: 1,227 vehicles

Owners notified April 14, 2003 · Vehicles built August 31, 1999 – September 26, 2002 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REVISE THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN APRIL 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEWMAR AT 1-574-773-7791.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

NEWMAR/FMVSS 301/VENT HOSE

NHTSA #00V315000 · Fuel System, Gasoline — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported October 7, 2000 · NEWMAR CORPORATION

Potentially affected: 1,263 vehicles

Owners notified October 23, 2000 · Vehicles built January 1, 2000 – August 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: FRONT AND REAR ENGINE MOTOR HOMES BUILT ON FORD, SPARTAN AND WORKHORSE CHASSIS. ALL FRONT ENGINE CLASS A MOTOR HOMES BUILT ON FORD AND WORKHORSE CHASSIS WERE MANUFACTURED FROM JANUARY 1, THROUGH AUGUST 31, 2000. ALL REAR ENGINE MOTOR HOMES BUILT ON SPARTAN CHASSIS WERE BUILT FROM FEBRUARY 23 THROUGH AUGUST 31, 2000. THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." AN INCORRECT VENT HOSE WAS INSTALLED ON THE FILL NOZZLE TO THE FUEL TANK. THE HOSE CAN BREAK DOWN ALLOWING FUEL LEAKAGE.

Safety consequence

FUEL LEAKAGE IN THE PRESENCE TO AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL VENT HOSE.

Notes

OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEWMAR AT 1-800-731-8300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Newmar Mountain Aire model years

Check your 2001 Newmar Mountain Aire VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Newmar Mountain Aire at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Newmar VIN