NHTSA vehicle safety data

2007 Newmar Kountry Star DP Recalls & Complaints

The 2007 Newmar Kountry Star DP has 3 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Newmar dealer.

NHTSA recall and complaint data for the 2007 Newmar Kountry Star DP. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Newmar Kountry Star DP owner complaints

Owners have filed 3 complaints with NHTSA about the 2007 Newmar Kountry Star DP, describing incidents dated December 25, 2006 to August 4, 2008.

Most-cited components

Electrical System 1 complaint
Service Brakes 1 complaint
Visibility/Wiper 1 complaint

Newest complaints

ODI #10289411 · Filed October 22, 2009
THE VEHICLE'S ENGINE BEGAN TO TURN WITHOUT THE IGNITION KEY IN PLACE. THE STARTER WAS RUINED BEFORE ATTEMPTS TO DISENGAGE POWER TO THE STARTER WERE SUCCESSFUL. THE MECHANIC WHO REPLACED THE STARTER BELIEVES THE CAUSE WAS WATER INFILTRATION OF BUSSMAN BOX WHERE ENGINE STARTER FUSES AND RELAYS ARE…
ODI #10238135 · Filed August 14, 2008
MOTOR HOME IS NEW. WINDSHIELDS WIPERS WERE TURNED ON DURING A RAIN STORM. ON THE FIRST SWEEP BOTH WIPER ARMS EXTENDED TOO FAR TO THE LEFT. DRIVERS SIDE WIPER ARM WRAPPED AROUND THE LEFT SIDE OF THE CURVED WINDSHIELD WHILE THE PASSENGER SIDE WIPER ARM ROTATED APPROX 180 DEGREES. WIPERS ARMS FROZE IN…
ODI #10220061 · Filed March 4, 2008
TL*THE CONTACT OWNS A 2007 NEWMAR KOUNTRY STAR DIESEL PUSHE. THE ABS WARNING INDICATOR LIGHT ILLUMINATED, BUT THERE WAS NO FAILURE WHILE DRIVING AND BRAKING. THE DEALER REPLACED THE ABS SENSORS, IN ADDITION TO OTHER REPAIRS. ALL THE REPAIRS THAT WERE MADE WERE UNKNOWN. THE ABS WARNING INDICATOR…

Read all 3 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #11V235000 · Equipment · NHTSA notice

Reported April 12, 2011 · NEWMAR CORPORATION

Potentially affected: 5,486 vehicles

Owners notified March 28, 2011 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

NEWMAR IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200 SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

NEWMAR IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON MARCH 28, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

HITCH FRACTURES/SPARTAN/PUTNAM

NHTSA #08V596000 · Trailer Hitches · NHTSA notice

Reported November 17, 2008 · NEWMAR CORPORATION

Potentially affected: 913 vehicles

Owners notified January 21, 2009 · Vehicles built December 1, 2005 – October 31, 2008 (per NHTSA)

Defect description

NEWMAR IS RECALLING 913 MY 2007-2009 ALL STAR ME, DUTCH STAR DP, MY 2007-2008 KOUNTRY STAR DP, MY 2007 MOUNTAIN AIRE DP, AND MY 2009 DUTCH AIRE DP AND VENTANA DP MOTOR HOMES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTNAM HITCHES. AFTER SOME PERIOD OF USE, CERTAIN TRAILER HITCHES MAY DEVELOP STRESS FRACTURES DUE TO SHARP RADII AND /OR TOOL MARKING.

Safety consequence

FRACTURES IN THE SUSPECT HITCHES MAY RESULT IN HITCH SEPARATION, POTENTIALLY RESULTING IN INJURY AND/OR PROPERTY DAMAGE.

Manufacturer remedy

NEWMAR IS WORKING WITH SPARTAN WHO WILL REPLACE THE TRAILER HITCH FREE OF CHARGE (PLEASE SEE 08V567). OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR NEWMAR AT 1-574-773-7791.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

BUSSMANN BOX FAILURE/SPARTAN

NHTSA #08V075000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice

Reported February 20, 2008 · NEWMAR CORPORATION

Potentially affected: 409 vehicles

Defect description

NEWMAR IS RECALLING 409 MY 2007-2008 ALL STAR, DUTCH STAR, VENTANA, AND KOUNTRY STAR DIESEL PUSHERS MOTOR HOME CHASSIS. THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Safety consequence

EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN- FUEL SEPARATOR.

Manufacturer remedy

NEWMAR IS WORKING WITH SPARTAN TO REPAIR THESE MOTOR HOMES (PLEASE SEE 07V363). THE DVEC BUSSMANN BOX WILL BE REPLACED. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR NEWMAR AT 574-773-7791.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Newmar Kountry Star DP. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2007 Newmar Kountry Star DP.

Electrical System

ODI #10289411

Incident: October 18, 2007 · Filed: October 22, 2009

THE VEHICLE'S ENGINE BEGAN TO TURN WITHOUT THE IGNITION KEY IN PLACE. THE STARTER WAS RUINED BEFORE ATTEMPTS TO DISENGAGE POWER TO THE STARTER WERE SUCCESSFUL. THE MECHANIC WHO REPLACED THE STARTER BELIEVES THE CAUSE WAS WATER INFILTRATION OF BUSSMAN BOX WHERE ENGINE STARTER FUSES AND RELAYS ARE LOCATED. A BUSSMAN BOX HAS BEEN THE SUBJECT OF OTHER SAFETY RECALLS ON NEWMAR BRAND DIESEL PUSHERS. WHEN CONTACTED, BOTH THE CHASSIS MANUFACTURER (SPARTAN) AND THE COACH MANUFACTURER (NEWMAR) DENY RESPONSIBILITY FOR THE PROBLEM. NO REMEDY HAS BEEN OFFERED BY EITHER MANUFACTURER. *TR

Visibility

ODI #10238135

Incident: August 4, 2008 · Filed: August 14, 2008

MOTOR HOME IS NEW. WINDSHIELDS WIPERS WERE TURNED ON DURING A RAIN STORM. ON THE FIRST SWEEP BOTH WIPER ARMS EXTENDED TOO FAR TO THE LEFT. DRIVERS SIDE WIPER ARM WRAPPED AROUND THE LEFT SIDE OF THE CURVED WINDSHIELD WHILE THE PASSENGER SIDE WIPER ARM ROTATED APPROX 180 DEGREES. WIPERS ARMS FROZE IN THAT POSITION. WIPER MOTOR WAS BURNT UP, FUSE WAS BLOWN, AND SPLINES IN THE WIPER ARMS WHERE MOUNTED TO WIPER ROTATING SYSTEM WERE GROUND SMOOTH. WIPER ARMS AND MOTOR WERE REPLACED UNDER WARRANTY. SECOND TIME WIPERS TURNED ON DURING A RAIN STORM THEY OPERATED APPROXIMATELY 24 CYCLES AND DID THE SAME THING. CHECKED THE NEWMAR OWNER SITE ON IRV2.COM AND FIND THAT MANY OTHER NEWMAR OWNERS REPORT THE SAME / SIMILAR EXPERIENCE WITH WIPERS. FIRST OCCURRENCE WAS ON SECONDARY ROAD. MINIMUM TRAFFIC, NO PLACE TO STOP SO PROCEEDED WITH DIMINISHED VISIBILITY. SECOND OCCURRENCE OCCURRED ON BUSY I-80 IN THE MIDDLE OF HEAVY SEMI TRUCK TRAFFIC. AGAIN NO PLACE TO SAFELY STOP SO PROCEEDED WITH GREATLY DIMINISHED VISIBILITY UNTIL COULD SAFELY STOP AND WAIT FOR RAIN AND WATER THROWN BY TRAFFIC TO CEASE. CURRENTLY WAITING FOR NEWMAR TO FIND SOMEONE WHO CAN ADDRESS PROBLEM. *TR

Service Brakes, Air

ODI #10220061

Incident: December 25, 2006 · Filed: March 4, 2008

TL*THE CONTACT OWNS A 2007 NEWMAR KOUNTRY STAR DIESEL PUSHE. THE ABS WARNING INDICATOR LIGHT ILLUMINATED, BUT THERE WAS NO FAILURE WHILE DRIVING AND BRAKING. THE DEALER REPLACED THE ABS SENSORS, IN ADDITION TO OTHER REPAIRS. ALL THE REPAIRS THAT WERE MADE WERE UNKNOWN. THE ABS WARNING INDICATOR LIGHT HAS ILLUMINATED AGAIN. THE ENGINE SIZE AND NUMBER OF CYLINDERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 2,000 AND CURRENT MILEAGE WAS 19,000.

Other Newmar Kountry Star DP model years

Check your 2007 Newmar Kountry Star DP VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Newmar Kountry Star DP at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Newmar VIN