NHTSA vehicle safety data
1995 New Flyer D60HF Recalls & Complaints
The 1995 New Flyer D60HF has 4 NHTSA recall campaigns on file as of November 3, 2026. try.vin has no NHTSA owner complaints on file for the 1995 New Flyer D60HF. Recall repairs are usually free at an authorized New Flyer dealer.
NHTSA recall and complaint data for the 1995 New Flyer D60HF. Recall data is refreshed daily from NHTSA.
STEERING U-JOINT ASSEMBLY
NHTSA #07V268000 · Steering · NHTSA notice
Reported June 11, 2007 · NEW FLYER INDUSTRIES LTD
Potentially affected: 1,768 vehicles
Owners notified July 10, 2007 · Vehicles built January 1, 1991 – June 1, 2007 (per NHTSA)
Defect description
ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
Safety consequence
EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
Manufacturer remedy
THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
FLASHING DECELERATION LAMPS/FMVSS 108
NHTSA #07V068000 · Exterior Lighting · NHTSA notice
Reported February 23, 2007 · NEW FLYER INDUSTRIES LTD
Potentially affected: 1,707 vehicles
Owners notified March 17, 2007 · Vehicles built January 1, 1994 – December 31, 1998 (per NHTSA)
Defect description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Safety consequence
THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Manufacturer remedy
DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION1S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
WHEELCHAIR LIFTS/LIFT-U
NHTSA #07V012000 · Equipment Adaptive/Mobility · NHTSA notice
Reported January 18, 2007 · NEW FLYER INDUSTRIES LTD
Potentially affected: 1,421 vehicles
Vehicles built January 1, 1988 – December 31, 1996 (per NHTSA)
Defect description
ON CERTAIN TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS, IT IS POSSIBLE FOR A PERSON TO WEDGE THEIR FEET UNDER THE SOLID BAR BARRIER LINKAGE.
Safety consequence
WHILE SITTING IN A WHEEL CHAIR A PERSON WITH NO SHOES AND DOES NOT HAVE CONTROL OF THEIR FEET, COULD TWIST THEIR FEET AND GET IT FORCED UNDER THE LINKAGE WHICH COULD RESULT IN AN INJURY.
Manufacturer remedy
LIFT-U IS CONDUCTING THIS RECALL (PLEASE SEE 06E-093). OWNERS WILL RECEIVE A FREE REPAIR KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS MAY CONTACT LIFT-U AT 209-838-2400 OR NEW FLYER AT 204-934-4876.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NEW FLYER/WHEEL
NHTSA #04V042000 · Wheels · NHTSA notice
Reported February 2, 2004 · NEW FLYER INDUSTRIES LTD
Potentially affected: 782 vehicles
Owners notified March 26, 2007 · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
Safety consequence
THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.
Manufacturer remedy
NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.
Notes
CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other New Flyer D60HF model years
Check your 1995 New Flyer D60HF VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your New Flyer D60HF at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a New Flyer VIN