NHTSA vehicle safety data
1999 New Flyer D30LF Recalls & Complaints
The 1999 New Flyer D30LF has 4 NHTSA recall campaigns on file as of November 3, 2026. try.vin has no NHTSA owner complaints on file for the 1999 New Flyer D30LF. Recall repairs are usually free at an authorized New Flyer dealer.
NHTSA recall and complaint data for the 1999 New Flyer D30LF. Recall data is refreshed daily from NHTSA.
FLASHING DECELERATION LAMPS/FMVSS 108
NHTSA #07V068000 · Exterior Lighting · NHTSA notice
Reported February 23, 2007 · NEW FLYER INDUSTRIES LTD
Potentially affected: 1,707 vehicles
Owners notified March 17, 2007 · Vehicles built January 1, 1996 – December 31, 2000 (per NHTSA)
Defect description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Safety consequence
THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Manufacturer remedy
DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION1S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
ENGINE TURBOCHARGER/SERIES 40/DETROIT DIESEL
NHTSA #05V320000 · Engine and Engine Cooling — Engine — Other Fuel Types — Turbo/Supercharger · NHTSA notice
Reported July 8, 2005 · NEW FLYER INDUSTRIES LTD
Potentially affected: 321 vehicles
Owners notified December 19, 2007 · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE.
Safety consequence
THIS CAN RESULT IN A FIRE IN THE ENGINE COMPARTMENT.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE THE TURBOCHARGER TO PREVENT THE POSSIBILITY OF AN ENGINE COMPARTMENT FIRE. DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR NEW FLYER AT 1-204-982-8400.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NEW FLYER/VAPOR/DOOR PANEL ADHESIVE
NHTSA #02V059001 · Structure — Body — Door · NHTSA notice
Reported February 14, 2002 · NEW FLYER OF AMERICA, INC.
Potentially affected: 1,771 vehicles
Vehicles built January 1, 1998 – October 31, 2000 (per NHTSA)
Defect description
ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL.
Safety consequence
UNDER THESE CONDITIONS, IF THE PANEL IS SEPARATING OR HAS SEPARATED, A PASSENGER COULD FALL FROM THE BUS ONTO THE ROADWAY, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Manufacturer remedy
VAPOR WILL NOTIFY CUSTOMERS TO HAVE THEIR BUSES INSPECTED AND WILL INSTALL MECHANICAL FASTENERS TO ATTACH THE SKINS TO THE FRAME ELEMENTS FREE OF CHARGE. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VAPOR CORPORATION AT 847-967-8300 OR NEW FLYER AT 1-204-224-1251.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NEW FLYER/VANNER BATTERY EQUALIZER
NHTSA #01V033006 · Electrical System — 12V/24V/48V Battery · NHTSA notice
Reported April 30, 2001 · NEW FLYER INDUSTRIES LIMITED
Potentially affected: 2,100 vehicles
Vehicles built November 1, 1998 – September 30, 2000 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.
Safety consequence
WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.
Manufacturer remedy
DEALERS WILL INSPECT THE BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. NEW FLYER IS CONDUCTING THE OWNER NOTIFICATION FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937 OR NEW FLYER AT 1-204-982-8413.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other New Flyer D30LF model years
Check your 1999 New Flyer D30LF VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your New Flyer D30LF at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a New Flyer VIN