NHTSA vehicle safety data

2003 Mitsubishi Montero Recalls & Complaints

The 2003 Mitsubishi Montero has 2 NHTSA recall campaigns and 39 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mitsubishi dealer.

NHTSA recall and complaint data for the 2003 Mitsubishi Montero. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Mitsubishi Montero owner complaints

Owners have filed 39 complaints with NHTSA about the 2003 Mitsubishi Montero, describing incidents dated July 10, 2003 to August 12, 2015.

Most-cited components

Service Brakes 11 complaints
Fuel/Propulsion System 6 complaints
Power Train 6 complaints
Electrical System 4 complaints
Air Bags 3 complaints
Engine 3 complaints

Of the 39 complaints on file, 4 report a crash and 1 a fire; across all 39 complaints, owners report 4 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10881447 · Filed June 29, 2016
TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED WHEN THE VEHICLE WAS PURCHASED FROM THE DEALER. THE CONTACT STATED THAT THE VEHICLE HAD A STRONG HESITATION AS THE FAILURE PROGRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT…
ODI #10724898 · Filed June 12, 2015
TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STARTED TO VEER TO THE LEFT INDEPENDENTLY. THE CONTACT STOPPED ON THE SHOULDER TO CHECK THE TIRE PRESSURE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN PUT THE…
ODI #10715411 · Filed May 8, 2015
A SIREN SOUND CAME ON. MY HUSBAND PROCEEDED TO GET OF THE ROAD. IN HIS ATTEMPT, THE BRAKES BECAME VERY HARD TO PRESS. THE VEHICLE CONTINUED TO ROLL AS THE BRAKES WERE BEING APPLIED. HE THE PULL THE EMERGENCY BRAKES TO BRING THE VEHICLE TO A COMPLETE STOP. AAA WAS CALLED TO TOW THE VEHICLE TO A AUTO…

Read all 39 complaints

MITSUBISHI CARIBBEAN/FMVSS 208/AIR BAG LABEL

NHTSA #04V428000 · Equipment — Other — Labels · NHTSA notice

Reported September 1, 2004 · MITSUBISHI CARIBBEAN

Potentially affected: 100,432 vehicles

Vehicles built June 1, 1997 – June 30, 2004 (per NHTSA)

Defect description

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.

Safety consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Manufacturer remedy

MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.

Notes

THE MANUFACTURER'S PETITION WHICH REQUESTED THAT NHTSA DETERMINE THIS FMVSS NONCOMPLIANCE DOES NOT CREATE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY WAS PARTIALLY DENIED ON JANUARY 26, 2005. THEREFORE, THIS MANUFACTURER IS OBLIGATED TO CONDUCT AN OWNER NOTIFICATION AND REMEDY CAMPAIGN.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

MITSUBISHI/FUEL LEAKAGE

NHTSA #04V319000 · Fuel System, Gasoline — Storage · NHTSA notice

Reported July 6, 2004 · MITSUBISHI MOTORS NORTH AMERICA, INC.

Potentially affected: 44,214 vehicles

Mitsubishi campaign SR-04-008 · Owners notified August 30, 2004 · Vehicles built April 4, 2001 – May 21, 2004 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, WHEN THE FUEL TANK IS FULL AND THE VEHICLE IS PARKED FACING FORWARD ON AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE MAY NOT MAINTAIN PROPER SEALING IN THE EVENT THE FUEL EXPANDS FROM A RISE IN THE AMBIENT TEMPERATURE.

Safety consequence

IF THE FUEL LEVELING VALVE DOES NOT SEAL PROPERLY, FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE LEVELING VALVE. THE RECALL BEGAN ON AUGUST 30, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.

Notes

MITSUBISHI RECALL NO. SR-04-008.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2003 Mitsubishi Montero. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

39 owner complaints have been filed with NHTSA for the 2003 Mitsubishi Montero.

Engine and Engine Cooling

ODI #10881447

Incident: August 12, 2015 · Filed: June 29, 2016

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED WHEN THE VEHICLE WAS PURCHASED FROM THE DEALER. THE CONTACT STATED THAT THE VEHICLE HAD A STRONG HESITATION AS THE FAILURE PROGRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Structure

ODI #10724898

Incident: May 26, 2015 · Filed: June 12, 2015

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STARTED TO VEER TO THE LEFT INDEPENDENTLY. THE CONTACT STOPPED ON THE SHOULDER TO CHECK THE TIRE PRESSURE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN PUT THE VEHICLE ON THE LIFT AND DIAGNOSED THAT THE ENTIRE SUB FRAME WAS SEVERELY CORRODED. THE TECHNICIAN STATED THAT THE REPAIRS WOULD HAVE BEEN MORE THAN WHAT THE VEHICLE WAS WORTH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

Service Brakes

ODI #10715411

Incident: May 3, 2015 · Filed: May 8, 2015

A SIREN SOUND CAME ON. MY HUSBAND PROCEEDED TO GET OF THE ROAD. IN HIS ATTEMPT, THE BRAKES BECAME VERY HARD TO PRESS. THE VEHICLE CONTINUED TO ROLL AS THE BRAKES WERE BEING APPLIED. HE THE PULL THE EMERGENCY BRAKES TO BRING THE VEHICLE TO A COMPLETE STOP. AAA WAS CALLED TO TOW THE VEHICLE TO A AUTO SHOP. AFTER A THOROUGH CHECK, THE OWNER (MASTER MECHANIC) DISASSEMBLE THE BRAKING SYSTEM TO CHECK IF THE BOOSTER HAD FAILED, HE STATED THE VEHICLE DID NOT HAVE A BOOSTER. I PICKED THE VEHICLE UP ON FRIDAY, MAY 7 AROUND 4:00PM. AFTER TRAVELING APPROXIMATELY 1 MILE, THE SIREN NOISE CAME BACK ON. WE ARE AWAITING TO HAVE THE TRUCK TOWED AGAIN ON MONDAY. *TR

Steering; Air Bags

ODI #10662222

Incident: December 4, 2014 · Filed: December 4, 2014

THE HORN GOES OFF BY ITSELF THE PADS WHERE STUCK AND IT COST $1000 TO REPAIR SINCE IT NEEDS TO REMOVE THE STEERING AIRBAG,THIS SHOULD BE ON A RECALL.THIS HAS A LOT OF PROBLEMS WHO HAS SAME MODEL ON MITSUBISHI FORUMS FOUND HERE HTTP://MITSUBISHIFORUM.COM/FORUM/MITSUBISHI-MONTERO-MONTERO-SPORT-14/HORN-ACTIVATE-ITSELF-01-MONTERO-LTD-28034/. *TR

Service Brakes, Hydraulic; Service Brakes

ODI #10649213

Incident: October 16, 2014 · Filed: October 22, 2014

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING 5 MPH DOWN A SLIGHT INCLINE, THE BRAKE PEDAL FAILED TO RESPOND AND THE VEHICLE WAS SHIFTED TO NEUTRAL IN ORDER TO STOP. THE CONTACT ALSO STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.

Power Train

ODI #10621355

Incident: August 11, 2014 · Filed: August 11, 2014

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT HEARD A LOUD PIERCING SOUND WHEN THE IGNITION WAS STARTED. ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 230,000.

Service Brakes

ODI #10585588

Incident: October 16, 2013 · Filed: April 29, 2014

I WAS DRIVING ON THE FREEWAY, WHEN ALL OF A SUDDEN MY ABS LIGHT CAME ON AND A BUZZER. I THEN WENT TO APPLY THE BRAKES AND STOP BUT THE BRAKE PEDAL WOULD NOT BUDGE. IT WAS LIKE THERE WAS A BRICK UNDER IT. THERE WAS NO WAY OF STOPPING SAFELY. LUCKILY NO ONE WAS IN FRONT OF ME. I HAD TO YOU THE TRANSMISSION TO SHIFT DOWN. PRESSED AS HARD AS I COULD ON BRAKES AND FINALLY STOPPED. I HAVE RESEARCHED THIS ISSUE AND HAVE DISCOVERED IT IS QUITE COMMON. HOW IS IT SAFE FOR A VEHICLE WITH A ANTILOCK BRAKE MALFUNCTION TO TAKE OUT THE BRAKE SYSTEM COMPLETELY? I HAVE CONTACT MITSUBISHI AND THEY SAID THERE IS NO RECALL!! HOW IS THIS POSSIBLE!?! THIS IS VERY UNSAFE I HAVE HAD THE VEHICLE PARKED SINCE THE INCIDENT. I FEEL MITSUBISHI NEEDS TO PAY FOR THIS AND UPGRADE THE BRAKE SYSTEM. I HAVE RESEARCHED THE PRICE AND WOULD COST ME 1700.00 TO HAVE THE SYSTEM REPLACED. WITH NO GUARANTEE OF IT NOT DOING IT AGAIN. *JS

Service Brakes

ODI #10556663

Incident: October 2, 2013 · Filed: December 19, 2013

I WAS DRIVING, STARTED HEARING OOZING SOUND THEN I APPLIED BRAKES, VERY HARD AND WON'T GO DOWN. THEN I PULLED OVER THE SIDE CURB AND THE CURB STOPPED THE CARD. *TR

Service Brakes, Hydraulic; Equipment

ODI #10525110

Incident: July 9, 2013 · Filed: July 16, 2013

MY HYDRAULIC BRAKE STOP WORKING I HAVE TO USE THE EMERGENCY BRAKE THE REPAIR IS 2500 MY CAR IS A 2003 WITH 90000 MILE. *TR

Service Brakes

ODI #10496520

Incident: January 31, 2013 · Filed: February 5, 2013

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE BRAKES FAILED. THE CONTACT MENTIONED THAT THE ABS, EMERGENCY BRAKE, AND TRACTION CONTROL WARNING LAMPS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ELECTRIC MOTOR IN THE HYDRAULIC BRAKE BOOSTER UNIT FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 135,000.

Other Mitsubishi Montero model years

Check your 2003 Mitsubishi Montero VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mitsubishi Montero at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mitsubishi VIN